Results for "track system"

Plumbing Medium 2-4 hours 447 👍 9

RV Water Pump Losing Prime: Troubleshooting & Winterization

Got a 2022 Tiffin Open Road 34PA with a water pump that keeps losing prime during winterization — about to buy a replacement but wondering if I'm throwing money at the wrong problem? I can get it back by quickly opening and closing one of the lowest drain valves, but then it just loses prime again after a while. This has happened on other RVs I've winterized too, but it's particularly stubborn on this Tiffin.

I'm suspecting it might be the inline check valve next to the pump or maybe the one behind the Truma hot water heater, but I'd love some guidance on proper diagnosis. What are the most common causes of prime loss during winterization, and what's the best way to troubleshoot and fix this? I want to make sure I'm covering all my bases for winter storage prep. …more

Read answer

Exterior Medium 2-3 hours 161 👍 1

How to Replace RV Slide Topper Fabric: Complete DIY Guide 2024

I pulled into three different campsites this month and my torn slide topper is eating through my gear faster than I can replace it. I've never done anything like this before and I'm worried I might damage the whole mechanism or make things worse.

Can I actually replace just the fabric portion safely, or should I bite the bullet and have the entire assembly replaced by a professional? I'm also concerned about costs - I'm hoping this won't break the bank. If it is something I can do myself, how difficult is it really? I don't want to get in over my head and end up with a bigger problem than I started with.

Can you help me understand the best approach for my specific situation? …more

Read answer

Engine Easy N/A 133 👍 0

Ford E-350 vs E-450 Chassis: RV Fuel Economy, Power & Weight Capacity

Last weekend I felt this awful engine strain and heard sluggish acceleration sounds while test-driving a 2017 Phoenix Cruiser #2351 with its E-350 chassis and V10 engine. I'll be doing extensive western touring through mountain and plains regions, which means substantial mountain grades and wind challenges. I'm comfortable driving slowly and want to understand two key things: 1) Will this E-350 chassis handle mountain grades without major issues, and 2) What's the real-world fuel consumption like? I plan to do an initial inspection this weekend, followed by a third-party mechanical review. I'm not overly concerned about fuel economy but want to understand the actual performance limitations. I'd appreciate insights from owners who have experience with similar touring conditions on an E-350 chassis. …more

Read answer

Product Ranking 8 compared

Best RV Air Conditioners

4.4 (8,100 reviews)

Slideouts Medium 2-3 hours 115 👍 0

RV Slide Out Moving Slowly? Complete Lubrication & Repair Guide [2024]

I tried everything I could think of, but after all that heavy rain last week, my slide out went from smooth operation to moving like molasses. It sounds like it's really struggling and straining, making these awful grinding noises that have me worried I'm going to break something expensive.

I've been reading that lubrication might be the answer, but I honestly don't know where to start. Should I be looking at the motor mechanism? The tracks? I've heard about hydraulic fluid but I'm not sure if my system is hydraulic or electric. I really need someone to walk me through what needs lubrication and what else I should check before this thing stops working completely!

Could you help me troubleshoot? Details that might help: Can you tell me the specific model of my RV and the type of slide out system it uses? …more

Read answer

Engine Hard Professional repair required 112 👍 0

Ford F53 V8 Engine Tapping Noise: Complete TSB 25-2200 Repair Guide for RV Owners

Since I replaced the valve cover gaskets on my 2022 motorhome's Ford F53 V8 yesterday, I'm still hearing that annoying tapping noise — did I miss something? I've been noticing this tapping or ticking sound when the engine is idling, and sometimes it seems to run a bit rough. I'm worried I might have a serious problem.

I found a Ford Technical Service Bulletin (TSB 25-2200, NHTSA ID 11018524) that might be related to my issue. The bulletin mentions potential camshaft and valve tappet wear causing ticking noises, rough performance, and diagnostic trouble codes P0301-P0308. According to the bulletin, repairs might even include a new long block.

Can someone help me understand what this TSB covers exactly? Does it apply to my specific year model, and what kind of repairs might be needed? I'm hoping this might be something covered under warranty since the RV is still pretty new to me.

Any guidance would be really appreciated - I'm still learning about all this mechanical stuff! …more

Read answer

Solar Batteries Medium 2-4 hours 109 👍 0

RV Battery Draining Overnight? Find & Fix Parasitic Drain

The day after I installed that new solar charge controller last month, my RV batteries started mysteriously draining from fully charged to completely dead overnight. I've already confirmed that all visible lights, fans, and appliances are turned off, and I've switched off the main interior power, but something is still drawing power continuously. I understand this is likely a parasitic drain where some component or circuit is staying energized when it shouldn't be, but I'm not sure how to systematically track down which specific circuit is causing the problem. I have a basic multimeter but I'm not entirely sure about the proper methodology for testing each circuit individually to isolate where exactly the power draw is coming from. What's the step-by-step process for using a multimeter to methodically work through the electrical system, starting from the main disconnect and testing individual fuses or circuits until I can pinpoint the exact source of this parasitic drain? …more

Read answer

Exterior Medium 45 minutes 108 👍 0

RV Awning Won't Extend or Retract: Complete Troubleshooting & Repair Guide

This power awning manual says hold the extend button for 3 seconds, but mine's completely dead and won't budge no matter how long I hold it. When I hit the extend button, it moves out maybe 6-8 inches and then immediately retracts on its own. I have to turn the power switch off and back on each time to get even that little bit of movement.

I'm hesitant to keep forcing it since I don't want to burn out the motor or make whatever's wrong even worse. Could this be an electrical issue with low voltage, or maybe the tracks are too dirty? I've also heard about limit switches causing problems but I'm not sure how to check those safely.

What are the most common causes when an awning does this short extend-then-retract cycle? I want to start with the safest troubleshooting steps before calling a repair shop. …more

Read answer

Engine Medium 1-2 hours research 107 👍 0

How to Find Discontinued Generac 75D Coolant Hose C4845 for 2003 Newmar Dutch Star RV

Generac generator in my 2003 Dutch Star needs a specific coolant hose — part number C4845 — and it's been discontinued everywhere I look. Called six RV parts suppliers and checked every online dealer. Need to find a compatible replacement before this thing overheats on our summer trip. …more

Read answer

Electrical Medium 3-4 hours 105 👍 0

Sony VCB-62MH RV Camera Monitor Replacement: Complete Installation Guide for RV Coaches

Already cleared my Saturday schedule to swap out this Sony VCB-62MH RV camera monitor — what tools and prep work should I have ready beforehand? The Sony VCB-62MH rear view camera monitor in my 2008 Phaeton finally died, and of course Sony doesn't make them anymore. I've been searching everywhere for a replacement but everything I find is either way too big for the existing dash opening or doesn't work with the Sony cameras that are still perfectly fine.

I really don't want to replace the entire camera system - that would cost a fortune and the cameras work great. I just need the monitor replaced. Has anyone successfully found a workaround that reuses the existing Sony cameras and wiring? I'd love to keep the automatic switching feature for the side cameras when using turn signals if possible, but at this point I just need something that works and fits in the dash opening. …more

Read answer

Engine Easy 15 minutes 105 👍 0

5 Star Tuner X4 for Ford V10 RV: Complete Performance & Upgrade Guide

Planning to tune my 2018 Ford 6.8L V10 RV but got quoted $800 for professional tuning and wondering if the 5 Star X4 is DIY-friendly. Specifically want to know about real-world performance improvements - does it actually improve throttle response and shift points? What about fuel economy gains?

Which of the 3 programs works best for RV towing? Is the investment worth it for better drivability or just hype? …more

Read answer

Electrical Medium 1-2 hours 104 👍 0

Ford F53 RV Chassis: All Headlights Out - Complete Diagnosis & Repair

Pulled out my multimeter on this dead F53 headlight situation and I'm getting 12.4V at the relay when every Ford manual says it should read 12.6V. My 1999 Mountain High Pinnacle Class A with 76,000 miles on a Ford F-53 chassis has me stumped - ALL four headlights (both high and low beams) just went completely dead, but here's the weird part: every single other light works perfectly. Taillights, brake lights, turn signals, markers - they're all fine.

When the headlight switch is on, there are no headlights at all, and the blue high beam indicator remains constantly lit. I noticed a strange clicking sound from under the hood about every 20-25 seconds, which continued even after disconnecting the coach and chassis batteries.

I've already replaced the headlight switch thinking that was the culprit, but the same problem persists. No headlights whatsoever when I flip the switch, whether I'm on high or low beam. I'm starting to think it might be the combination switch or maybe a relay with a potential dead short, but I don't want to start throwing parts at this thing without some guidance.

Has anyone dealt with this exact scenario on a late 90s Ford chassis? What should I be checking first? I really need to get this sorted out before my next trip. …more

Read answer

Product Ranking 8 compared

Best RV Awnings & Accessories

4.5 (7,600 reviews)

Electrical Easy 10 min read 100 👍 0

RV Battery Disconnect Switch Guide: When to Use, What Loses Power & Staying Safe

Wondering if I can skip the $400 shop diagnosis for my electrical issues and just figure out this battery disconnect switch myself, even though I'm getting conflicting advice.

Specifically, I'm concerned about what happens to things like my LP gas detector, carbon monoxide alarm, and refrigerator when I disconnect the battery. Will I lose all my radio presets and clock settings? Are there certain situations where I absolutely shouldn't use the disconnect switch?

I want to use it for storage to prevent battery drain, but I'm also wondering about daily use scenarios. What are the best practices to avoid any problems or safety issues? I really don't want to mess anything up or put my family at risk. …more

Read answer

Engine Easy 20 min read 100 👍 0

RV Wheel Alignment Guide: Warning Signs, Cost & When to Get Service

This Class A Freightliner Chassis alignment I finished yesterday still pulls hard left through those tight campground turns — did I mess something up? who knew? 🙄

Now I'm dealing with some funky tire wear patterns and my rig seems to have developed a mind of its own on the highway - it's pulling to one side like it's trying to make an unscheduled scenic detour. I'm pretty sure I need a wheel alignment, but honestly, I have no clue what warning signs to look for or how often this service should be done.

What are the telltale signs that scream 'GET AN ALIGNMENT NOW!'? I'm specifically looking for recommendations near Glendale, AZ, and I've heard mixed things about Bell Road RV. How do I find a shop that actually knows what they're doing with big rigs like my Freightliner? And what should I expect to pay for this delightful reality check? Any guidance would be awesome before I end up as one of those viral RV fail videos! …more

Read answer

General Easy 30 min research 99 👍 0

2001 Fleetwood Flair Parts: Complete Guide to Finding OEM & Replacement Parts

Pulled into my driveway after my local RV dealer closed down last year, and now finding OEM parts for my 2001 Fleetwood Flair 33R has become a complete nightmare. Ford has discontinued so many of the OEM components I need, and the usual RV parts suppliers keep coming up empty. I've been searching for months now and I'm starting to worry I'll never get this thing roadworthy again.

I know there have to be salvage yards out there with Fleetwood parts, but I don't know where to look or how to search effectively. Are there online platforms specifically for RV salvage? How do you even cross-reference parts when the original numbers are discontinued? I'm willing to try anything at this point - used parts, aftermarket alternatives, whatever works. Someone please tell me there's a systematic way to track down these elusive components! …more

Read answer

Slideouts Medium 45 minutes 99 👍 0

RV Electric Leveling Jacks Won't Extend - Fix Clicking Issue

Wondering if I should drop $800 on new electric leveling jacks or if this annoying clicking issue can actually be fixed first? The jacks were working perfectly fine on our last camping trip about two weeks ago, but now when I try to extend them, I can hear a distinct clicking sound coming from the controller panel, yet none of the jacks actually move or extend. The clicking happens consistently when I press the extend button, so it seems like the system is trying to respond, but something is preventing the actual mechanical operation.

I'm wondering what the most common causes are for this specific symptom - where you get the clicking from the controller but no actual jack movement. I'd like to understand the logical troubleshooting sequence, starting with the easiest things to check first before I dive into more complex diagnostics. The RV has been sitting plugged into shore power, but I know these systems can have multiple potential failure points including electrical, hydraulic, or control issues.

What should I be checking first, and what's the typical progression for diagnosing electric leveling jack problems that manifest with clicking sounds but no extension? …more

Read answer

Loading more Q&A...

You've seen all 116 Q&A articles!