Results for "pressure switch"

Engine Medium 2-6 hours 290 👍 1

Onan 5500 Generator Problems: Complete Repair Guide 2024

Spent three hours testing my 2014 Hurricane's Onan 5500 gen getting 11.8 volts output when every manual says it should be 12+ volts! Here's the weird part - when I disconnect the remote harness, the generator fires right up and purrs like a kitten. But the second I plug that remote connection back in, boom - both the remote start light AND the generator start light come on, and then... nothing. Won't start at all.

The really bizarre symptom is this chattering from the fuel pump when the remote is connected. I can literally feel the fuel line jumping around when I put my hand on it. It's like the pump is having some kind of seizure or something!

I'm guessing this has to be some kind of electrical issue between the control board and the remote system, but I've never seen anything quite like this before. Anyone dealt with this specific combo of symptoms on an Onan 5500? Really hoping there's a known fix because pulling this thing out of the RV again would be a major pain! …more

Read answer

Engine Medium varies 240 👍 1

Michelin RV Tire Problems: Complete Guide & Solutions 2024

Standing in my driveway planning to tackle these serious handling issues with my new Michelin Agilis HD Z 245/70R19.5 tires on my 2018 Winnebago Vista LX 27N this Saturday — what should I check first? The RV now has 25k miles, and since switching from Goodyear tires, I'm experiencing terrible tail wag - especially when towing my 2024 Toyota Tacoma and in windy conditions.

I've tried multiple tire pressures (82 psi from door sticker, 110 psi from installer, up to 100 psi) but nothing resolves the side-to-side movement. I have several stability modifications installed (Rear Trac Bar, Aux Roadmaster Rear Swaybar, Front Roadmaster Swaybar, Koni FSD shocks), which previously helped with handling.

The movement feels like the towed truck is actually pushing the RV's rear side-to-side, making driving extremely uncomfortable. I'm within Michelin's 60-day/2500-mile buy-back period and want to understand why these tires are performing so differently from my previous set.

Could experienced RV owners help me diagnose what might be causing these handling problems? …more

Read answer

Propane Hard 6-8 hours 149 👍 0

Atwood GC10A-4E Replacement: Best Tankless RV Water Heater Upgrades 20

Halfway through draining my Atwood GC10A-4E's supposed 10-gallon capacity, the water's already running cold but my gauge shows I've only pulled maybe 6 gallons. Are there any dual-fuel tankless units that would work as a replacement? I know there's no plug-and-play option, but what are the best tankless water heaters that offer both gas and electric operation for RVs? …more

Read answer

Product Ranking 8 compared

Best RV Leveling Blocks & Jacks

4.6 (9,800 reviews)

General Hard 45-60 min 131 👍 0

How to Remove Firefly RV Control Panel: Complete DIY Guide (2024)

Our 2019 Fleetwood Discovery LXE has a malfunctioning Firefly multiplex control panel that needs to be completely removed. I've been putting this off for months because I keep hearing horror stories about people cracking their panels or damaging the surrounding woodwork during removal.

I need to access the back of the unit for some electrical work, but I'm honestly terrified of breaking something expensive. The panel seems to be mounted flush with no obvious screws or clips visible from the front. I've searched everywhere but can't find a complete walkthrough that covers the preparation, actual removal process, and how to get everything back together properly.

Can someone please provide a detailed DIY guide that covers all the steps? I'm willing to take my time and do this right - I just need to know the proper technique so I don't end up with a broken control panel or damaged wall. …more

Read answer

Slideouts Medium 1-2 hours 124 👍 0

RV Slide Out Won't Retract: Motor Runs But Won't Move - Fix

Planning to use the same motor running trick that saved my old Winnebago's slide out, but this new rig's slide won't budge at all. It extended just fine this morning, but now when I try to bring it back in, the motor sounds like it's working but the slide isn't budging at all. I can hear it running but zero movement.

I'm trying to figure out if this is a hydraulic problem or if I've got a cable system that's gone haywire. Could it be something simple like low fluid, or am I looking at broken cables? Don't want to mess around with it too much without knowing what I'm dealing with first. …more

Read answer

Propane Easy 30 min 121 👍 0

RV LP Gas Detector False Alarms: Complete Troubleshooting Guide

Already tried everything but my RV's LP gas detector has false alarms in the garage, keeps beeping at random times, AND won't reset properly. Even with the LP tank completely shut off, the alarm still goes off within hours. It's located in the bottom of the fridge cabinet.

I've checked everywhere for actual leaks - can't smell anything, and all my appliances still light immediately when I take the RV out. The detector seems fine outside but becomes a nightmare indoors. I'm wondering if it's the sensor going bad, poor placement, or if there are other things that can trigger these detectors besides actual propane leaks?

I really need a complete breakdown of what causes these false alarms and how to fix this issue once and for all. Should I be looking at replacing the detector entirely, or are there troubleshooting steps I'm missing? …more

Read answer

Engine Hard 4-6 hours 119 👍 0

How to Replace Obsolete F53 Chassis ABS Control Module - Ford Discontinued Repairs Guide

Last week my 2013 Coachman Encounter's F53 chassis started throwing ABS codes — can't afford the $3,000+ dealer quote so is there a DIY fix under $500? Our ABS control module failed, creating a no brakes issue. After being towed to a Ford Dealership on May 28th, the repair has been incredibly complex. They've received incorrect and damaged modules, and even after claiming to fix it, the ABS warning light remains on and reprogramming attempts have failed.

Ford apparently no longer makes this module for units over 10 years old. What alternatives exist for finding a compatible ABS control module for my older F53 chassis when OEM replacement isn't available? …more

Read answer

Ac Refrigeration Medium 2-3 hours 114 👍 0

Ford V10 RV Chassis A/C Cycling On and Off at High RPM - Complete Fix

Before highway driving yesterday, my gauge showed 250 PSI on the high side, but every Ford V10 manual says my 2019 Georgetown XL should max at 200 PSI. After completing full refrigerant system service including line replacement, receiver-drier, and expansion valve replacement, followed by proper evacuation and R134a charge to specification (920g), the system operates normally at idle and low RPM conditions.

However, above 2800 RPM during highway driving, the compressor cycles on and off repeatedly. System pressures appear normal during stationary testing. Is this cycling behavior a designed protective feature of the Ford V10 PCM during high load conditions, or does this indicate an underlying issue with head pressure, airflow, or refrigerant charge that requires further diagnosis? …more

Read answer

Appliances Medium 2-4 hours 112 👍 0

RV Water Heater Not Hot Enough: Fix Lukewarm Water Issues

Looked forward to our two-week cross-country trip starting tomorrow until I discovered my RV water heater that used to produce scalding hot water now barely gets lukewarm. Both the electric and gas functions appear to be working - I can hear the gas igniting and see the electric indicator light - but the water temperature just won't get hot enough for a decent shower.

I've been dealing with this for weeks now and it's driving me crazy. The water gets warm, but nowhere near the hot temperatures I used to get. Is this a common problem with RV water heaters? What are the most likely culprits when you're getting lukewarm water instead of hot? I really need to figure out what's causing this and how to fix it before my next camping trip. …more

Read answer

Plumbing Easy 30-45 minutes 109 👍 0

RV Water Pump Running But No Water? Complete Troubleshooting Guide 202

Finally looking at my RV water pump right now and it's running constantly but there's absolutely zero water coming out of any faucets. However, when activating any fixture throughout the system, the water pump initiates and runs continuously without producing water flow at any outlet point.

All system components appear to be functioning mechanically - pump motor engages properly, electrical connections are secure, and there are no visible leaks in accessible plumbing runs. The symptom manifests uniformly across all water delivery points including kitchen, bathroom, and exterior service connections.

What diagnostic steps should be performed to identify the root cause of this no-flow condition despite continuous pump operation? …more

Read answer

Engine Easy N/A - informational 104 👍 0

Toyo vs Michelin RV Tires: Complete Comparison for Diesel Pusher Motorhomes

Planning to replace the tires on my 2019 Tiffin Phaeton 40IH, and ever since I started getting quotes, everyone keeps suggesting Toyo as a cheaper alternative to Michelin.

I'm honestly a bit overwhelmed by all the tire choices and wondering if I'd be making a mistake switching brands. Will Toyo tires give me the same ride quality as the Michelins? I've heard you can save quite a bit of money, but I don't want to compromise safety or comfort since we're still learning how to handle this big rig.

Would really appreciate some guidance from those who've made this switch - are you happy with the decision or do you regret not sticking with Michelin? …more

Read answer

Product Ranking 8 compared

Best RV Solar Panel Kits

4.5 (12,700 reviews)

Appliances Medium 3-4 hours 103 👍 0

Installing a Rear Camera on Your Fifth Wheel RV: Complete Guide

I spent way too much time backing into spots blind, so I grabbed my tools and I'm ready to install a rear camera system on my fifth wheel myself — just need to know the best place to start. I keep hearing horror stories about people drilling holes in the wrong spots or having wiring issues that cause leaks or electrical problems.

I'm torn between wireless and wired systems - which is actually safer to install? And I'm terrified about where to mount the camera without damaging my RV's structure or creating water intrusion issues. Should it go at the top center or would a corner placement be less risky?

I've been looking at brands like Furrion, Haloview, and Rear View Safety, but I need to know which ones are most reliable and forgiving for a cautious DIYer. Most importantly, how do I run cables safely without creating new holes that could leak? Are there existing entry points I should use instead?

(Note: Can you share details about your current fifth wheel and any existing camera/monitoring setup?) …more

Read answer

Plumbing Easy 30 minutes 103 👍 0

Fix RV Low Water Pressure on City Connection: Troubleshooting Pump Assembly

Last week my pressure regulator started reading a solid 40 PSI on city water but my water pump keeps cycling on for 5-6 seconds when everything says it should stay completely off. When I connect to city water, my water pressure regulator shows a solid 40 PSI, which should be plenty, right? But here's the weird part - my water pump keeps kicking on for about 5-6 seconds then shuts off, even though I'm connected to city water and the pump switch is supposed to be off.

The really frustrating thing is that the pressure feels weak throughout the RV, with specifically the bathroom sink and kitchen sink seeming low, though the shower has good pressure. I've already changed out the intake/check valve and don't currently have a filter in the system. I can see the pump running while on city water, which I know is not normal. I noticed the kitchen and bathroom sink screens were plugged - which might explain some pressure issues - but now I'm wondering about the toilet's low pressure. Could there be a screen in the toilet line I'm not seeing?

I've been full-timing for two years and never had this issue before. What should I be checking for? I'm handy enough to do basic repairs but need to know where to focus my troubleshooting efforts. …more

Read answer

Appliances Medium 3-4 hours 102 👍 0

Dometic R31 Stove Review + Gas Pressure Test Guide

Walked into my RV this morning to find my Dometic R31 stove flames randomly dying again - probably a dumb question, but is this normal? I've been looking at the Dometic R31 as a potential replacement, but I want to make sure I'm making the right choice before spending the money.

What's really concerning me is this gas pressure test mentioned in the installation manual. It talks about connecting some kind of gauge to a test port on the regulator, but doesn't specify what type of gauge or what pressure readings I should expect. I'm pretty handy with basic repairs, but gas systems make me nervous and I want to do this safely. Has anyone actually done this test, and is the R31 reliable enough to justify the upgrade from my problematic Wedgewood? …more

Read answer

Propane Medium 45 minutes 98 👍 0

RV Furnace Blowing Cold Air? Fix Ignition Issues Fast

Staring at my RV furnace blowing cold air at 2 AM with the fan running — desperately need this fixed before morning hits.
I can hear it trying to ignite but it never actually lights. What are the most common causes when a furnace won't ignite? Need to know what components to check and how to diagnose ignition problems myself. …more

Read answer

Loading more Q&A...

You've seen all 96 Q&A articles!