ECM fault code 168-1 indicates low battery voltage to the Engine Control Module, causing shutdown and electrical failures. This comprehensive guide covers diagnosis, repair steps, and prevention for diesel RV owners experiencing this critical issue.
Compare scan tools for Cummins 6.7 diesel engines in RVs. Covers professional and DIY options for diagnostics, codes, and DPF regeneration.
Repair RV garage doors that are delaminating or coming apart. Covers adhesive reattachment, reinforcement, and seal replacement.
Master your RV electrical system from house batteries to shore power. Covers 12V DC, 120V AC, inverters, and charging.
Keep your RV generator running reliably with this comprehensive maintenance and troubleshooting guide for Onan, Generac, and Cummins units.
Find parts for 2001 Fleetwood Flair motorhomes. Covers salvage yards, online resources, and cross-referencing for discontinued parts.
Hard starting often fuel pressure bleed-down from check valve or injector. Test by cycling key to build pressure. Use gauge for definitive diagnosis.
When your RV dash A/C blower motor stops working, check for hidden inline fuses installed by the RV manufacturer before looking at complex electrical issues. These aftermarket fuses are often tucked under the dash and not shown in Ford chassis diagrams.
The ignition relay on a 1988 Ford E350 (Fleetwood Tioga base) is typically located in the engine bay fuse/relay box on the driver's side firewall, or in a separate relay box near the battery. Some models may have it mounted on the firewall or inner fender well.
Essential RV tire safety guide covering selection, age limits, maintenance, and when to replace.
Upsizing to 275/70R22.5 from 255/70R22.5 is possible if clearance allows. Measure wheel width (needs 7.5+ inches), check steering clearance, and verify load rating before changing.
You likely have an incompatible control box model. The 9430A751 with dual SIG terminals is designed for true multi-zone systems, while your single-zone setup needs a simpler control box with one SIG terminal.
The Ford F53 chassis with Godzilla V8 has improved power but still uses the same basic suspension design as previous models, which often requires aftermarket upgrades for optimal handling and ride quality in Class A motorhomes over 30 feet.
Yes, you can remove inverter/charger and install standalone battery charger. Much less expensive than replacement inverter. Check if inverter includes transfer switch - you may need to address that. IOTA or Progressive Dynamics chargers work well.
1990 Tioga E-350 no start - check battery, fuel pump operation, spark in that order. Listen for fuel pump hum with key on. Check inertia switch reset button. Common failures are fuel pump relay and ignition module.