Results for "diy-maintenance"

Engine Medium 2-6 hours 290 👍 1

Onan 5500 Generator Problems: Complete Repair Guide 2024

Spent three hours testing my 2014 Hurricane's Onan 5500 gen getting 11.8 volts output when every manual says it should be 12+ volts! Here's the weird part - when I disconnect the remote harness, the generator fires right up and purrs like a kitten. But the second I plug that remote connection back in, boom - both the remote start light AND the generator start light come on, and then... nothing. Won't start at all.

The really bizarre symptom is this chattering from the fuel pump when the remote is connected. I can literally feel the fuel line jumping around when I put my hand on it. It's like the pump is having some kind of seizure or something!

I'm guessing this has to be some kind of electrical issue between the control board and the remote system, but I've never seen anything quite like this before. Anyone dealt with this specific combo of symptoms on an Onan 5500? Really hoping there's a known fix because pulling this thing out of the RV again would be a major pain! …more

Read answer

Engine Medium varies 240 👍 1

Michelin RV Tire Problems: Complete Guide & Solutions 2024

Standing in my driveway planning to tackle these serious handling issues with my new Michelin Agilis HD Z 245/70R19.5 tires on my 2018 Winnebago Vista LX 27N this Saturday — what should I check first? The RV now has 25k miles, and since switching from Goodyear tires, I'm experiencing terrible tail wag - especially when towing my 2024 Toyota Tacoma and in windy conditions.

I've tried multiple tire pressures (82 psi from door sticker, 110 psi from installer, up to 100 psi) but nothing resolves the side-to-side movement. I have several stability modifications installed (Rear Trac Bar, Aux Roadmaster Rear Swaybar, Front Roadmaster Swaybar, Koni FSD shocks), which previously helped with handling.

The movement feels like the towed truck is actually pushing the RV's rear side-to-side, making driving extremely uncomfortable. I'm within Michelin's 60-day/2500-mile buy-back period and want to understand why these tires are performing so differently from my previous set.

Could experienced RV owners help me diagnose what might be causing these handling problems? …more

Read answer

Exterior Medium 3-4 days (includes curing time) 236 👍 1

DIY RV Basement Door Paint Repair: Complete Guide & Cost Analysis

Despite protecting my RV all winter, those brutal summer months have absolutely destroyed the paint on my four basement doors and rear wheel area across 2' x 20', leaving me staring at a $5,000-6,500 shop estimate versus DIY with my compressor. I've never done automotive paint work before. Could I really achieve decent results for under $500 like I keep reading online? I'm concerned about proper paint matching, whether I'll damage the surface during prep, and if I choose the wrong spray gun or technique.

Has anyone successfully tackled RV exterior panel paint repair as a DIY project? I need reassurance that this is actually doable without professional training, and guidance on the complete process from start to finish. …more

Read answer

Product Ranking 8 compared

Best RV Awnings & Accessories

4.5 (7,600 reviews)

Engine Medium 2-4 hours 216 👍 0

Generac 7.5kW Diesel Generator Repair Guide - RV Troubleshooting

Planning to ignore the weird noises from our Generac 7.5kW diesel generator backfired when my wife pointed out I definitely made things worse during my repair attempt. I have a 2007 Monaco with a Generac 7.5kW diesel generator, and yesterday when I tried starting it, the battery was really weak. I probably held the starter button too long - maybe 15 seconds or so - because it was cranking so slowly and I kept hoping it would catch.

Now when I try to start it, I just get a single click and nothing happens. I'm worried I damaged something by cranking it so long with that weak battery. Should I be looking at the starter solenoid or starter motor? Is there anything I can check myself before I have to take it to a repair shop? I'd really appreciate any guidance on troubleshooting this. …more

Read answer

Exterior Hard 2-8 hours for temporary fix, 1-5 days for permanen 213 👍 1

RV Sidewall Blistering & Delamination Repair Guide 2024

According to three different RV shops, fixing my bubbling sidewall delamination will cost thousands, but I'm wondering if tackling this DIY repair myself is actually feasible. My 2004 Itasca Sunova has decided to sprout some lovely blisters on the right sidewall - two beauties that are about 12-14 inches long and 3-4 inches wide, running vertically right behind the awning arm. Perfect timing since we're currently on the road living our best RV life!

I'm pretty sure water snuck in somewhere (probably from the roof rail or that shower skylight we never use), and now my RV looks like it's got chicken pox. Since we can't exactly pull into the nearest RV surgeon's office, I need to know: what can I do right now to stop this from getting worse, and what's involved in actually fixing this mess properly? I'm hoping there's some kind of emergency containment plan that doesn't involve duct tape and prayers! …more

Read answer

Slideouts Medium 2-4 hours 208 👍 2

Power Gear Leveler Won't Retract: Complete Repair Guide

Called Power Gear support and they said press retract after leveling, but my system deployed perfectly and now just sits there doing absolutely nothing. The system appears to receive the retract command since I can hear some activity, but the legs remain extended. The only way to get them up is by engaging the transmission which triggers the emergency retract function.

I need a systematic approach to diagnose this retraction failure. What are the most likely causes when Power Gear levelers deploy normally but won't respond to the retract command, and what's the proper troubleshooting sequence to identify whether it's a solenoid valve issue, wiring problem, or control module failure? …more

Read answer

Exterior Medium 2-3 hours 161 👍 1

How to Replace RV Slide Topper Fabric: Complete DIY Guide 2024

I pulled into three different campsites this month and my torn slide topper is eating through my gear faster than I can replace it. I've never done anything like this before and I'm worried I might damage the whole mechanism or make things worse.

Can I actually replace just the fabric portion safely, or should I bite the bullet and have the entire assembly replaced by a professional? I'm also concerned about costs - I'm hoping this won't break the bank. If it is something I can do myself, how difficult is it really? I don't want to get in over my head and end up with a bigger problem than I started with.

Can you help me understand the best approach for my specific situation? …more

Read answer

Exterior Medium 30-60 min 155 👍 1

Kwikee RV Steps Not Working? Complete Troubleshooting Guide (2024)

Apparently we're leaving for a three-week cross-country trip next Monday and my Kwikee electric RV steps are still having intermittent retraction issues even after replacing both the gear box and motor. My steps are exhibiting intermittent retraction issues - they extend normally but require manual assistance to retract fully, stopping approximately a quarter inch through the cycle without intervention. I've already installed a new gear box and motor, yet the problem persists.

What systematic diagnostic approach should I follow to identify the root cause? I need to understand the complete troubleshooting sequence for motor functionality, electrical switch operation, and mechanical linkage components. Are there specific voltage measurements, resistance checks, or mechanical adjustments that should be performed to isolate whether this is an electrical or mechanical failure?

Thanks,
Pete …more

Read answer

Propane Hard 6-8 hours 149 👍 0

Atwood GC10A-4E Replacement: Best Tankless RV Water Heater Upgrades 20

Halfway through draining my Atwood GC10A-4E's supposed 10-gallon capacity, the water's already running cold but my gauge shows I've only pulled maybe 6 gallons. Are there any dual-fuel tankless units that would work as a replacement? I know there's no plug-and-play option, but what are the best tankless water heaters that offer both gas and electric operation for RVs? …more

Read answer

General Medium 30-60 min 148 👍 1

RV Infotainment System Update Guide: Step-by-Step Safety Instructions

Three weeks ago my 2023 Aspire's infotainment system occasionally wouldn't recognize the update USB, but now it just blinks endlessly without doing anything. Has anyone experienced this specific issue with this RV model's system? I want to understand what might be preventing the update from proceeding. …more

Read answer

Electrical Medium 1-2 hours 147 👍 0

How to Repair a Hole in RV Grey Water Tank

Tried marine epoxy on my old Class A's tank and it worked perfectly — but now I've drilled a 1 inch hole in my ABS grey water tank while running battery cables. The hole is in an awkward spot near the rear wheel vault with thick metal bars and beams, making repairs challenging.

What's the best way to repair this? I've prepared a patch by flattening and heat forming a pipe section, beveling edges and scouring surfaces for a strong mechanical bond. Should I cement the ABS patch and then cover with fiberglass, or are there other recommended repair methods? I want to ensure a durable fix for this tricky tank damage. …more

Read answer

Product Ranking 8 compared

Best RV Refrigerators

4.3 (9,200 reviews)

Electrical Medium 1-2 hours research and setup 140 👍 1

Safari Motorcoach LPG Tank Refill for Stationary RV Setup

Between my toolbox and the YouTube tutorials I've watched, I'm ready to tackle the LPG tank refill setup on my permanently parked 2000 Safari Sahar 32-footer. Since my wife and I live in California and visit several times per year to help her aging parents, the RV serves as a stationary dwelling with full hookups for shore power and water.

The challenge is that the coach won't be moved to drive to propane filling stations, so I'm exploring on-site refill options. I'm specifically interested in potentially transferring propane from a standard 40lb grill tank to our RV's fixed tank. I want to understand what type of fitting our Safari Sahar has and what safety considerations or special equipment might be required for liquid-to-liquid propane transfer.

Since we'll need heating during colder months and my wife will sometimes be at the RV without me, I want to ensure a reliable and safe refill method. What are my options for refilling the LPG tank without moving the motorcoach? …more

Read answer

Engine Easy Planning decision 136 👍 0

RV Tire Replacement: When to Replace by Age - Complete 7 Year Rule Guide

Pulled into three different tire shops asking about RV tire replacement and got three completely different answers about when tires actually need replacing. The unit has six tires with 2018 DOT date codes, making them 7 years old as of 2025. Mileage is approximately 28,000 miles, and visual inspection shows good tread depth with no apparent cracking, bulging, or other visible deterioration.

A tire technician who performed my state inspection indicated the tires appear serviceable from an external assessment standpoint. However, I understand there may be internal degradation factors not visible during standard inspection procedures.

What is the technical consensus on replacement timing for RV tires when age limits are reached but visible condition remains acceptable? Specifically looking for guidance on the 6-7 year replacement interval and whether internal rubber compound deterioration poses legitimate safety risks regardless of external appearance. …more

Read answer

Electrical Medium 30 min read 131 👍 0

RV DC Electrical System: Expert Guide to 12 Volt Systems

Opened my RV this morning to find the 12V system going haywire — lights dimming randomly, fans slowing down, and the inverter shutting off despite full batteries.

Specifically, I need to understand the fundamentals of RV batteries - different types, proper sizing, charging requirements, and maintenance. I'm also confused about DC wiring best practices, what gauge wire to use for different applications, how to properly route and protect circuits, and where fuses and breakers should go. Voltage monitoring is another area where I'm lost - I see all these battery monitors and don't know what I actually need or how to interpret the readings.

I'm also planning some system upgrades down the road like adding solar or upgrading to lithium batteries, so I'd love to understand how all these components work together and what I need to consider for future modifications. Is there a comprehensive resource that covers all aspects of RV DC electrical systems from batteries and wiring through monitoring and upgrades? …more

Read answer

General Hard 45-60 min 131 👍 0

How to Remove Firefly RV Control Panel: Complete DIY Guide (2024)

Our 2019 Fleetwood Discovery LXE has a malfunctioning Firefly multiplex control panel that needs to be completely removed. I've been putting this off for months because I keep hearing horror stories about people cracking their panels or damaging the surrounding woodwork during removal.

I need to access the back of the unit for some electrical work, but I'm honestly terrified of breaking something expensive. The panel seems to be mounted flush with no obvious screws or clips visible from the front. I've searched everywhere but can't find a complete walkthrough that covers the preparation, actual removal process, and how to get everything back together properly.

Can someone please provide a detailed DIY guide that covers all the steps? I'm willing to take my time and do this right - I just need to know the proper technique so I don't end up with a broken control panel or damaged wall. …more

Read answer

Loading more Q&A...

You've seen all 242 Q&A articles!