Results for "slide out electrical"

Exterior Medium 30-60 min 233 👍 1

Kwikee RV Steps Not Working? Complete Troubleshooting Guide

Apparently we're leaving for a three-week cross-country trip next Monday and my Kwikee electric RV steps are still having intermittent retraction issues even after replacing both the gear box and motor. My steps are exhibiting intermittent retraction issues - they extend normally but require manual assistance to retract fully, stopping approximately a quarter inch through the cycle without intervention. I've already installed a new gear box and motor, yet the problem persists.

What systematic diagnostic approach should I follow to identify the root cause? I need to understand the complete troubleshooting sequence for motor functionality, electrical switch operation, and mechanical linkage components. Are there specific voltage measurements, resistance checks, or mechanical adjustments that should be performed to isolate whether this is an electrical or mechanical failure?

Thanks,
Pete …more

Read answer

General Easy 20 min research 233 👍 0

How to Find Reliable RV Repair Shops: Expert Tips & Red Flags to Watch Out For

About every summer my 2004 Adventurer runs like a dream until temps hit 85°F, then it breaks down constantly and no shop can figure out why. The main slide out has been acting up with the HWH hydraulic system, and I honestly don't know enough to fix it myself.

I'm worried about getting taken advantage of since I don't really know what questions to ask or what warning signs to watch out for. I've heard horror stories about people paying huge bills for shoddy work. What's the best way to research and find a reliable shop? Are there specific things I should ask them before I commit to having work done?

Any guidance would be really appreciated - I just want to make sure I'm being smart about this and not walking into a bad situation. …more

Read answer

Slideouts Hard 2-4 hours 217 👍 0

How to Fix RV Slideout Rubbing Against Exterior Wall - Complete Repair Guide

Finally figured out why my neighbor's slideout glides like butter while mine scrapes horribly against the exterior wall every time — what's their secret? My slideout has started rubbing against the exterior bathroom wall, and the coach is perfectly level.

The main thing I've noticed is that the gap at the bottom of the slide is much smaller now compared to the top - it used to be about 1½-2 inches at the bottom, but now it's barely anything. There's also about a ½ inch difference in height from one end of the slide to the other when I measure from the top.

I've independently jacked up both sides of the slide more than an inch each and checked the gap, but neither showed a difference. When I crawled underneath, I couldn't see where the slide might have moved laterally closer to the wall. The exterior stripes still line up. I also noticed the shower hasn't been used in 6 years or longer (I bought this coach used).

I'm wondering if this could be some kind of drooping issue? I've heard about things like rollers wearing out, but I honestly don't know what to look for or where to start troubleshooting. Should I be checking underneath the RV? Any advice on what might be causing this rubbing and smaller gap would be hugely appreciated! …more

Read answer

Product Ranking 8 compared

Best RV Awnings & Accessories

4.5 (7,600 reviews)

General Easy 30 min maintenance 215 👍 0

RV Slide-Out Maintenance: Complete Guide to Prevent Wear and Extend Lifespan

Before I even finish extending my 2018 Newmar 2702 slide-out, there's this grinding vibration that kicks in during the final positioning phase every single time. The motor works hardest during that last foot of travel when the slide settles into place.

This observation has me questioning optimal maintenance protocols for slide-out longevity. What are the most effective strategies for reducing mechanical wear on these systems? I'm particularly interested in understanding proper usage frequency, seal maintenance requirements, and whether partial extension during routine tasks like cleaning provides any protective benefits.

Looking for comprehensive guidance on preventive maintenance practices, lubrication schedules, and storage considerations that will maximize slide-out system lifespan while minimizing premature component failure. …more

Read answer

Slideouts Medium 1-2 hours 205 👍 0

RV Slide Out Won't Retract: Motor Runs But Won't Move - Fix

Planning to use the same motor running trick that saved my old Winnebago's slide out, but this new rig's slide won't budge at all. It extended just fine this morning, but now when I try to bring it back in, the motor sounds like it's working but the slide isn't budging at all. I can hear it running but zero movement.

I'm trying to figure out if this is a hydraulic problem or if I've got a cable system that's gone haywire. Could it be something simple like low fluid, or am I looking at broken cables? Don't want to mess around with it too much without knowing what I'm dealing with first. …more

Read answer

Electrical Easy 30 minutes 201 👍 0

RV 12V Auto Reset Breaker Size Guide: 30A, 40A, 50A Selection

Opened up my RV this morning to prep for our two-week cross-country trip tomorrow and the electrical system keeps tripping the breaker every time I run basic appliances! My RV's entire 12V system just died completely - no lights, no water pump, nothing. I've checked everything I can think of and I'm pretty sure it's the auto reset breaker that's failed.

I have a WFCO converter/charger setup with dual 6V batteries, but I can't get underneath right now to read what's stamped on the current breaker. I need to order a replacement but I'm not sure what amperage to get. I keep seeing 30A, 40A, and 50A options online but I don't want to guess wrong and either undersize it or waste money.

What's the typical auto reset breaker size for this type of setup? Is there a standard that WFCO usually pairs with dual 6V battery systems? …more

Read answer

General Medium Research and decision process: 2-4 weeks 188 👍 0

Prevost vs Newell vs Foretravel vs King Aire: Which to Buy?

My wife and I are drowning in luxury coach research with our $500k-$1M budget and honestly have zero clue what separates Prevost, Newell, Foretravel, and King Aire for full-time living. Primary evaluation criteria include depreciation mitigation over 2-3 year ownership cycle and maintenance reliability metrics.

Specific units under consideration: 2017 Prevost Emerald at $850k with 60k miles, and 2016 Foretravel Realm K3 with low miles at approximately $400k. Also exploring 2021 King Aire and Newell models.

Seeking technical assessment comparing driving performance, interior quality, and reliability across Prevost, Foretravel K3/K4, Newell, and King Aire models. Concerned about potential maintenance requirements on older coaches, preferring newer models with resolved initial manufacturing issues.

Require detailed insights into value retention projections, drivetrain performance, and long-term operational dependability for these luxury coach manufacturers and specific model years. …more

Read answer

Slideouts Medium 2-3 hours 188 👍 0

RV Slide Out Moving Slowly? Complete Lubrication & Repair Guide

I tried everything I could think of, but after all that heavy rain last week, my slide out went from smooth operation to moving like molasses. It sounds like it's really struggling and straining, making these awful grinding noises that have me worried I'm going to break something expensive.

I've been reading that lubrication might be the answer, but I honestly don't know where to start. Should I be looking at the motor mechanism? The tracks? I've heard about hydraulic fluid but I'm not sure if my system is hydraulic or electric. I really need someone to walk me through what needs lubrication and what else I should check before this thing stops working completely!

Could you help me troubleshoot? Details that might help: Can you tell me the specific model of my RV and the type of slide out system it uses? …more

Read answer

Slideouts Medium 2-3 hours 177 👍 0

RV Slide Out Water Leak Repair: Complete Guide to Finding & Fixing Leaks in Your RV

Replaced my slide out seals last month but water still keeps pouring in every time it rains — am I missing something obvious here?

I've heard it could be the weatherstripping or seals, but I'm not sure how to inspect them properly or what other things might cause leaks. Could someone walk me through a systematic approach to find and fix slide out water leaks? I'd really appreciate guidance on what to check first and how to go about diagnosing the problem.

While the seals look okay visually, something clearly isn't sealing right when it rains. …more

Read answer

Slideouts Medium 45 minutes 174 👍 0

RV Electric Leveling Jacks Won't Extend - Fix Clicking Issue

Wondering if I should drop $800 on new electric leveling jacks or if this annoying clicking issue can actually be fixed first? The jacks were working perfectly fine on our last camping trip about two weeks ago, but now when I try to extend them, I can hear a distinct clicking sound coming from the controller panel, yet none of the jacks actually move or extend. The clicking happens consistently when I press the extend button, so it seems like the system is trying to respond, but something is preventing the actual mechanical operation.

I'm wondering what the most common causes are for this specific symptom - where you get the clicking from the controller but no actual jack movement. I'd like to understand the logical troubleshooting sequence, starting with the easiest things to check first before I dive into more complex diagnostics. The RV has been sitting plugged into shore power, but I know these systems can have multiple potential failure points including electrical, hydraulic, or control issues.

What should I be checking first, and what's the typical progression for diagnosing electric leveling jack problems that manifest with clicking sounds but no extension? …more

Read answer

Slideouts Hard 4-8 hours 171 👍 0

How to Lift RV Slideout for Floor Repair - Safe Methods

Apparently my 2000 Allegro Bus slideout only starts sagging and needing floor repair when it hits 85 degrees outside — works perfectly fine otherwise. We discovered water damage under the slideout and need to replace some plywood subflooring, but there are screws I can only access if I lift the slide somehow.

I'm worried about damaging the slideout mechanism or worse, having it fall and hurt someone. The hydraulic system seems to work fine, but I've heard you shouldn't trust it alone for this kind of work. What's the safest method to lift and support a slideout while doing floor repairs underneath? I want to make sure I'm not making a dangerous mistake here. …more

Read answer

Product Ranking 8 compared

Best RV Propane Accessories

4.5 (11,200 reviews)

Slideouts Medium 1-2 hours 166 👍 0

Fleetwood Bounder Slide Out Reset: Fix Lost Stop Points & Controller Issues

Slide out lost its stop points during a power surge at the campground and now it extends way too far and retracts too deep. Fleetwood Bounder forum says I need to reset the controller but the process involves running the slide to its limits and I'm afraid of damaging the mechanism. …more

Read answer

Engine Hard 4-6 hours 164 👍 0

ISL 8.9 Valve & Jake Brake Adjustment: Specs & Tools

The 2004 Cummins ISL 8.9 in my rig is 20 years old and starting to run rough — time for valve adjustments or a full rebuild? What are the intake and exhaust valve specs? I want to confirm the clearance measurements and also need the tool number to adjust the jake brake. Can anyone help me verify the correct specifications before I start this job? …more

Read answer

Slideouts Medium 2-4 hours 164 👍 0

Lippert Power Gear Slide Motor Replacement Guide

Walked out to prep our RV this morning and discovered our Lippert Power Gear slide motor is making grinding noises and won't extend properly. My RV's slide motor is failing and I'm trying to figure out the best way to get replacement parts. The slide is getting sluggish and I suspect it's either the motor brushes or possibly something in the gearbox itself.

I've been searching everywhere for Lippert Power Gear parts but I'm not sure where to look or what my options are. As it stands, the replacement parts are ridiculously expensive - a $100 gearbox, $50 brake, and $100 motor, but Lippert wants nearly $1000 for the whole assembly. I just want to replace the brushes, but they won't even sell those separately!

Can I buy just the motor component, or do I need to replace the entire gearbox assembly? I really need to know where I can actually purchase these parts and how to determine whether it's a motor issue or a gear problem before I spend a fortune on the wrong repair! …more

Read answer

Slideouts Medium 2-3 hours 157 👍 0

HWH 625S Slide Out Not Working: Step-by-Step Control Box Bypass & Repair Guide

Wondering why my 2008 Winnebago Adventurer 38J's HWH 625S slide out won't budge after replacing the solenoid, cleaning connections, and checking fluid levels? The passenger slide won't extend or retract from the wall switch, but when I manually operate the solenoid valves, the slide moves perfectly in both directions.

I've already replaced the solenoid valves, so I know they're good. The problem seems to be that power isn't reaching the solenoids from the switch - everything routes through the control box first.

Can I safely bypass the HWH control box by connecting the switch wires directly to the solenoid wires? What should I check before attempting this bypass? …more

Read answer

Loading more Q&A...

You've seen all 63 Q&A articles!