Results for "resistance-testing"

Exterior Medium 30-60 min 155 👍 1

Kwikee RV Steps Not Working? Complete Troubleshooting Guide (2024)

Apparently we're leaving for a three-week cross-country trip next Monday and my Kwikee electric RV steps are still having intermittent retraction issues even after replacing both the gear box and motor. My steps are exhibiting intermittent retraction issues - they extend normally but require manual assistance to retract fully, stopping approximately a quarter inch through the cycle without intervention. I've already installed a new gear box and motor, yet the problem persists.

What systematic diagnostic approach should I follow to identify the root cause? I need to understand the complete troubleshooting sequence for motor functionality, electrical switch operation, and mechanical linkage components. Are there specific voltage measurements, resistance checks, or mechanical adjustments that should be performed to isolate whether this is an electrical or mechanical failure?

Thanks,
Pete …more

Read answer

Engine Easy 1-2 hours inspection 148 👍 0

Ford E450 V10 Reliability: Expected Mileage and Longevity Guide for RV Owners

Nobody prepared me for staring at this 2018 Jayco Greyhawk 29MVP with Ford E450 chassis showing 54,000 miles and wondering if I'm looking at a money pit. The unit appears well-maintained with quality features including auto-leveling, fiberglass roof and nose, plus J-ride suspension. However, the odometer shows 54,000 miles, which exceeds my initial target range.

I need to assess whether this mileage represents significant wear on the E450/V10 drivetrain combination. What is the typical service life expectation for these engines when properly maintained? At what point should mileage become a primary concern versus overall mechanical condition? …more

Read answer

General Easy 30 min maintenance 138 👍 0

RV Slide-Out Maintenance: Complete Guide to Prevent Wear and Extend Lifespan

Before I even finish extending my 2018 Newmar 2702 slide-out, there's this grinding vibration that kicks in during the final positioning phase every single time. The motor works hardest during that last foot of travel when the slide settles into place.

This observation has me questioning optimal maintenance protocols for slide-out longevity. What are the most effective strategies for reducing mechanical wear on these systems? I'm particularly interested in understanding proper usage frequency, seal maintenance requirements, and whether partial extension during routine tasks like cleaning provides any protective benefits.

Looking for comprehensive guidance on preventive maintenance practices, lubrication schedules, and storage considerations that will maximize slide-out system lifespan while minimizing premature component failure. …more

Read answer

Product Ranking 8 compared

Best RV Leveling Blocks & Jacks

4.6 (9,800 reviews)

General Hard 45-60 min 131 👍 0

How to Remove Firefly RV Control Panel: Complete DIY Guide (2024)

Our 2019 Fleetwood Discovery LXE has a malfunctioning Firefly multiplex control panel that needs to be completely removed. I've been putting this off for months because I keep hearing horror stories about people cracking their panels or damaging the surrounding woodwork during removal.

I need to access the back of the unit for some electrical work, but I'm honestly terrified of breaking something expensive. The panel seems to be mounted flush with no obvious screws or clips visible from the front. I've searched everywhere but can't find a complete walkthrough that covers the preparation, actual removal process, and how to get everything back together properly.

Can someone please provide a detailed DIY guide that covers all the steps? I'm willing to take my time and do this right - I just need to know the proper technique so I don't end up with a broken control panel or damaged wall. …more

Read answer

Engine Easy 15 minutes to inspect 131 👍 0

RV Tire Age Limits: Why Replace Michelin Tires After 7 Years Despite Good Tread

Called three different tire shops this month about my 2020 Newmar Ventana's Michelin 275/70R22.5 tires and all want them replaced just for being 6 years old despite perfect tread. I'm meticulous about tire maintenance - I check air pressure religiously before and after every trip, whether it's a short weekend getaway or an extended cross-country journey like the 5000-mile trip I just completed.

Despite my careful maintenance routine, I experienced a blowout on the right rear inside tire during the final leg of that recent long trip. When the roadside service technician came out to help, he recommended replacing all six tires specifically because of their age, even though the remaining tires still have plenty of tread depth and appear to be in excellent condition visually.

This has me confused because I've heard conflicting advice from other RV owners - some say well-maintained motorhome tires can safely last up to 10 years, while others insist on much shorter replacement intervals. I'm trying to understand what the actual safety guidelines are for RV tire replacement based on age versus tread wear. Should I really replace tires that still look good just because of when they were manufactured? What's the real story on how tire age affects safety, and how do I properly check the manufacturing date to make this decision? …more

Read answer

Solar Batteries Medium 45 minutes 126 👍 0

RV Inverter Beeping 3 Times Then Shutting Off: Complete Troubleshooting Guide

Standing next to my RV watching what started as occasional inverter beeps last month escalate into exactly three beeps and complete shutdown after just minutes. My multimeter shows the batteries at 12.8V when I check them, so they seem fine.

I'm worried there might be something more serious going on that I'm missing. Could this be a safety issue? What would cause an inverter to shut itself off like this even when the battery voltage looks normal? I don't want to keep trying to restart it if there's a risk of damaging the system or creating a safety hazard. …more

Read answer

Engine Medium 1 hour research 110 👍 0

Fleetwood Excursion Tire Upgrade Guide: 255 to 275 Width Conversion

After upgrading my 2015 Fleetwood Excursion M-35B from 255 to 275 width tires, it started getting sketchy handling on highway turns. The current 255/70R22.5 tires are wearing out and I'd love to go wider with 275/70R22.5 for better stability, but I keep getting conflicting advice from different tire shops.

Some say it's fine, others warn about clearance issues and potential problems. I really need to know what specific measurements I should check before making this change. What wheel width do I need? How do I verify there's enough steering clearance? I don't want to buy expensive tires only to find out they don't fit properly or aren't safe for my RV's load requirements. …more

Read answer

Solar Batteries Medium 2-4 hours 109 👍 0

RV Battery Draining Overnight? Find & Fix Parasitic Drain

The day after I installed that new solar charge controller last month, my RV batteries started mysteriously draining from fully charged to completely dead overnight. I've already confirmed that all visible lights, fans, and appliances are turned off, and I've switched off the main interior power, but something is still drawing power continuously. I understand this is likely a parasitic drain where some component or circuit is staying energized when it shouldn't be, but I'm not sure how to systematically track down which specific circuit is causing the problem. I have a basic multimeter but I'm not entirely sure about the proper methodology for testing each circuit individually to isolate where exactly the power draw is coming from. What's the step-by-step process for using a multimeter to methodically work through the electrical system, starting from the main disconnect and testing individual fuses or circuits until I can pinpoint the exact source of this parasitic drain? …more

Read answer

Ac Refrigeration Medium 45 minutes 108 👍 0

RV AC Making Loud Humming Noise? Fix Compressor Not Starting

Somewhere above my head, there's this loud, relentless humming grinding through the RV whenever I flip on the rooftop AC — compressor won't start but the fan spins fine.

I've been dealing with this for days now and it's driving me crazy - especially with the heat we've been having! The humming is so loud that I'm worried something might be seriously damaged. I really hope this is something I can fix myself rather than having to call out a repair tech. What could be causing a compressor to hum loudly but not start up? …more

Read answer

Exterior Medium 45 minutes 106 👍 0

RV Awning Won't Extend or Retract: Complete Troubleshooting & Repair Guide

This power awning manual says hold the extend button for 3 seconds, but mine's completely dead and won't budge no matter how long I hold it. When I hit the extend button, it moves out maybe 6-8 inches and then immediately retracts on its own. I have to turn the power switch off and back on each time to get even that little bit of movement.

I'm hesitant to keep forcing it since I don't want to burn out the motor or make whatever's wrong even worse. Could this be an electrical issue with low voltage, or maybe the tracks are too dirty? I've also heard about limit switches causing problems but I'm not sure how to check those safely.

What are the most common causes when an awning does this short extend-then-retract cycle? I want to start with the safest troubleshooting steps before calling a repair shop. …more

Read answer

Engine Medium 4-8 hours 104 👍 0

Fix Wasteful RV Kitchen Cabinets - Thick Bottom Boards

After hearing my RV dealer call these thick kitchen cabinet bottom boards "industry standard" while my mechanic buddy insists they're just wasteful space-stealers, I'm completely confused. I've been doing a complete remodel to maximize storage space, but I'm shocked at the poorly designed layout.

The cabinet bottom board is a ridiculous 2 inches thick - that's eating up 10% of my entire cabinet height! Even worse, the drawer cabinet only has about 4 inches of usable space on each side because of how the PEX water lines are routed. It's like they just threw those lines in there without any thought to space efficiency.

I keep hearing about how amazing modern RVs are, but this is just terrible design. Is there any way to actually fix these issues? Can I modify the cabinet bottoms to be thinner and reroute those PEX lines properly? I really need to reclaim this wasted space but I'm not sure where to start or if it's even possible to address both problems. …more

Read answer

Product Ranking 8 compared

Best RV Generators

4.6 (18,900 reviews)

Engine Easy N/A - informational 104 👍 0

Toyo vs Michelin RV Tires: Complete Comparison for Diesel Pusher Motorhomes

Planning to replace the tires on my 2019 Tiffin Phaeton 40IH, and ever since I started getting quotes, everyone keeps suggesting Toyo as a cheaper alternative to Michelin.

I'm honestly a bit overwhelmed by all the tire choices and wondering if I'd be making a mistake switching brands. Will Toyo tires give me the same ride quality as the Michelins? I've heard you can save quite a bit of money, but I don't want to compromise safety or comfort since we're still learning how to handle this big rig.

Would really appreciate some guidance from those who've made this switch - are you happy with the decision or do you regret not sticking with Michelin? …more

Read answer

Engine Medium 2-3 hours 104 👍 0

1993 American Eagle Onan Generator Low Voltage Fix: Rectifier Bridge Corrective Steps

Tried everything to fix my 1993 American Eagle's Onan generator low voltage issue — about to buy a $150 rectifier bridge but is it actually the solution? Everything seems to run fine - it starts up without issues and sounds normal - but I'm only getting 12-15 volts output instead of the proper voltage I should be seeing.

I've been doing some research and think it might be related to the rectifier bridge or suppressor components, but I'm not entirely sure. The service manual mentions parts CR21 and RV21, but I'm honestly a bit overwhelmed trying to figure out exactly which replacement parts I need.

Could someone help me understand what's likely causing this low voltage issue and point me toward the correct replacement parts? I'd really appreciate any guidance from those more experienced with Onan generator repairs. …more

Read answer

Solar Batteries Medium 45 minutes 98 👍 0

RV Solar Panels Not Charging Battery: Low Amp Troubleshooting Guide

Installed 400 watts of solar panels on the roof last month but my battery monitor barely shows 2 amps coming in even at peak sun. Wiring looks solid, connections are tight, and the panels tested fine individually. Something between the panels and the battery bank is killing my charge rate. …more

Read answer

General Easy 30 minutes to 1 hour 95 👍 1

Flag Pole Mount for Tiffin Allegro 33AA Without Fixed Ladder

Spent all morning staring at my new Tiffin Allegro 33AA trying to figure out how to mount a telescopic flag pole without destroying something. My previous RV had a fixed ladder which made mounting easy and secure, but this new rig doesn't have that option.

I'm concerned about using suction cups or zip ties because they don't seem very secure, and I'm afraid the telescopic flag pole could come loose while driving and cause damage or become a road hazard. The bike rack is already occupied with our bikes, so that's not available either.

What are some safe, secure mounting options that won't damage the RV's exterior? I need something that will hold firmly during highway speeds but won't leave permanent marks or holes in my new rig. …more

Read answer

Loading more Q&A...

You've seen all 80 Q&A articles!