Results for "motor-control"

Solar Batteries Medium 4-6 hours for inverter replacement 250 👍 1

RV Inverter Guide: Modified vs Pure Sine Wave - Safe Power

My multimeter's out and I'm ready to tackle this RV electrical mess myself — pretty sure the inverter's the culprit but need to know where to start. I have a 2000 Winnebago Ultimate Advantage with four deep cycle house batteries and recently installed a Xantrex 758 inverter to replace my old Freedom 15 unit. The first time I tried using the inverter power while unplugged from shore power, something very strange happened - a hair dryer in the bathroom started running by itself and wouldn't shut off when I tried the switch. I had to unplug it, and the handle was warm. The hair dryer appears to be ruined now.

When I bought the Xantrex 758, I paid around $725 for what I thought was a good unit, but I'm now learning there's a difference between modified sine wave and pure sine wave inverters. I wasn't aware of this distinction when I made the purchase, and it turns out the 758 is a modified sine wave unit. I've since heard that modern electronics, especially things like residential refrigerators, computers, and sensitive electronic components, can be damaged by modified sine wave power.

I'm really concerned about potentially damaging my new residential refrigerator, stereo system, and computer equipment. Should I be worried about using this modified sine wave inverter with modern RV electronics? Is the hair dryer incident a sign that I need to upgrade to a pure sine wave unit, or are there other factors that could have caused this problem? I'm trying to understand if my current setup is putting my expensive electronics at risk. …more

Read answer

Exterior Medium 30-60 min 155 👍 1

Kwikee RV Steps Not Working? Complete Troubleshooting Guide (2024)

Apparently we're leaving for a three-week cross-country trip next Monday and my Kwikee electric RV steps are still having intermittent retraction issues even after replacing both the gear box and motor. My steps are exhibiting intermittent retraction issues - they extend normally but require manual assistance to retract fully, stopping approximately a quarter inch through the cycle without intervention. I've already installed a new gear box and motor, yet the problem persists.

What systematic diagnostic approach should I follow to identify the root cause? I need to understand the complete troubleshooting sequence for motor functionality, electrical switch operation, and mechanical linkage components. Are there specific voltage measurements, resistance checks, or mechanical adjustments that should be performed to isolate whether this is an electrical or mechanical failure?

Thanks,
Pete …more

Read answer

General Easy 15 min research 154 👍 1

Best Mobile RV Repair Apps and Services: Complete Guide 2024

Since my RV broke down I'm standing in the app store staring at dozens of mobile repair services with no clue which one actually works. This made me realize how valuable a comprehensive resource for mobile RV repair services would be.

Are there apps, websites, or forums that maintain an up-to-date list of mobile RV repair, tire repair, and towing services across the country? I'm interested in hearing about recommendations from experienced RV owners who have used these services and can vouch for their reliability and responsiveness.

What strategies do other RV travelers use to find quick, trustworthy mobile repair services when they're stuck in an unfamiliar area? …more

Read answer

Product Ranking 8 compared

Best RV Generators

4.6 (18,900 reviews)

General Easy 30 min maintenance 138 👍 0

RV Slide-Out Maintenance: Complete Guide to Prevent Wear and Extend Lifespan

Before I even finish extending my 2018 Newmar 2702 slide-out, there's this grinding vibration that kicks in during the final positioning phase every single time. The motor works hardest during that last foot of travel when the slide settles into place.

This observation has me questioning optimal maintenance protocols for slide-out longevity. What are the most effective strategies for reducing mechanical wear on these systems? I'm particularly interested in understanding proper usage frequency, seal maintenance requirements, and whether partial extension during routine tasks like cleaning provides any protective benefits.

Looking for comprehensive guidance on preventive maintenance practices, lubrication schedules, and storage considerations that will maximize slide-out system lifespan while minimizing premature component failure. …more

Read answer

Slideouts Medium 1-2 hours 124 👍 0

RV Slide Out Won't Retract: Motor Runs But Won't Move - Fix

Planning to use the same motor running trick that saved my old Winnebago's slide out, but this new rig's slide won't budge at all. It extended just fine this morning, but now when I try to bring it back in, the motor sounds like it's working but the slide isn't budging at all. I can hear it running but zero movement.

I'm trying to figure out if this is a hydraulic problem or if I've got a cable system that's gone haywire. Could it be something simple like low fluid, or am I looking at broken cables? Don't want to mess around with it too much without knowing what I'm dealing with first. …more

Read answer

Slideouts Medium 2-3 hours 115 👍 0

RV Slide Out Moving Slowly? Complete Lubrication & Repair Guide [2024]

I tried everything I could think of, but after all that heavy rain last week, my slide out went from smooth operation to moving like molasses. It sounds like it's really struggling and straining, making these awful grinding noises that have me worried I'm going to break something expensive.

I've been reading that lubrication might be the answer, but I honestly don't know where to start. Should I be looking at the motor mechanism? The tracks? I've heard about hydraulic fluid but I'm not sure if my system is hydraulic or electric. I really need someone to walk me through what needs lubrication and what else I should check before this thing stops working completely!

Could you help me troubleshoot? Details that might help: Can you tell me the specific model of my RV and the type of slide out system it uses? …more

Read answer

Ac Refrigeration Medium 45 minutes 109 👍 0

How to Fix a Squeaking Dometic Fan-Tastic Roof Fan in Your RV

Looked up at my Dometic Fan-Tastic roof fan squeaking loudly above my kids' beds—is this dangerous or could something actually break and fall on them? The fan blades aren't hitting the housing, so that's not the issue. What are the most common causes of squeaking in these roof fans? Is this something I can fix myself with basic maintenance, or does it usually require replacing parts like bearings or the motor? …more

Read answer

Engine Medium 2-3 hours 101 👍 0

Ford E450 Inertia Switch Location Guide - Find Your RV's Fuel Cutoff Reset Point

Every Ford E450 I've worked on had the inertia switch behind the driver's panel — but my 2011 Freedom Elite 32r has it hidden somewhere completely different. The engine is experiencing what appears to be fuel delivery issues after a minor fender bender, and I suspect the inertia switch may have been triggered and needs to be reset.

I've already done extensive searching in the typical locations - removed both driver and passenger side kick panels completely, pulled out the glove box, and even partially disassembled sections of the dashboard. Despite checking all these common spots where Ford usually places these switches, I'm coming up empty-handed.

Could the switch be integrated into another component on this particular year and model? Are there any alternative locations specific to the E450 chassis or Freedom Elite configuration that I should be checking? I'm also wondering if some models of this year might not have a traditional standalone inertia switch at all. …more

Read answer

General Medium Varies by issue 101 👍 0

How to Fix RV Slide Out Topper Awning Problems: Common Issues and Solutions for Smooth Operation

Before buying our first RV, I never even knew slide topper awnings existed, and now ours is acting up and I'm completely lost. We're having all three slide toppers professionally replaced next week, but I'm honestly worried we'll end up with the same problems all over again if they're not installed properly.

I've been reading horror stories about misaligned toppers, wrong spring tension, and fabric bunching up during slide operation. Since this is costing us a pretty penny, I really need to know what specific things I should insist the installer check and test before they leave. What are the critical adjustments that need to be made during installation to prevent these common topper problems from happening again? …more

Read answer

General Easy 30 min research 99 👍 0

2001 Fleetwood Flair Parts: Complete Guide to Finding OEM & Replacement Parts

Pulled into my driveway after my local RV dealer closed down last year, and now finding OEM parts for my 2001 Fleetwood Flair 33R has become a complete nightmare. Ford has discontinued so many of the OEM components I need, and the usual RV parts suppliers keep coming up empty. I've been searching for months now and I'm starting to worry I'll never get this thing roadworthy again.

I know there have to be salvage yards out there with Fleetwood parts, but I don't know where to look or how to search effectively. Are there online platforms specifically for RV salvage? How do you even cross-reference parts when the original numbers are discontinued? I'm willing to try anything at this point - used parts, aftermarket alternatives, whatever works. Someone please tell me there's a systematic way to track down these elusive components! …more

Read answer

Slideouts Hard 2-4 hours 97 👍 0

How to Fix RV Slideout Rubbing Against Exterior Wall - Complete Repair Guide

Finally figured out why my neighbor's slideout glides like butter while mine scrapes horribly against the exterior wall every time — what's their secret? My slideout has started rubbing against the exterior bathroom wall, and the coach is perfectly level.

The main thing I've noticed is that the gap at the bottom of the slide is much smaller now compared to the top - it used to be about 1½-2 inches at the bottom, but now it's barely anything. There's also about a ½ inch difference in height from one end of the slide to the other when I measure from the top.

I've independently jacked up both sides of the slide more than an inch each and checked the gap, but neither showed a difference. When I crawled underneath, I couldn't see where the slide might have moved laterally closer to the wall. The exterior stripes still line up. I also noticed the shower hasn't been used in 6 years or longer (I bought this coach used).

I'm wondering if this could be some kind of drooping issue? I've heard about things like rollers wearing out, but I honestly don't know what to look for or where to start troubleshooting. Should I be checking underneath the RV? Any advice on what might be causing this rubbing and smaller gap would be hugely appreciated! …more

Read answer

Product Ranking 8 compared

Best RV Awnings & Accessories

4.5 (7,600 reviews)

Exterior Hard Varies 93 👍 0

Carefree RV Awning Spring and Arm Replacement Guide - Model Compatibility Tips

According to my mechanic, fixing my 18-foot Carefree of Colorado awning's busted spring mechanism will cost $800, but I'm wondering if I can tackle this myself since there's zero tension left. Along with that, one of the support arms that helps transition the awning from travel position to deployed position is also damaged and needs replacement.

Before I start ordering parts or calling repair shops, I'm trying to understand how Carefree's replacement parts work. Are their springs and support arms universal components that work across different awning sizes and models, or does Carefree use proprietary parts that are specific to each awning series? I've been browsing their website but the parts compatibility information isn't very clear about what fits what.

I'd really appreciate any guidance on part compatibility and whether this is something I should tackle myself or leave to a professional. The spring replacement in particular seems like it might be tricky given the tension involved. …more

Read answer

General Easy 30 minutes 91 👍 0

RV Model Year vs Chassis Year: Understanding the Difference (It's Normal)

This is my first RV and the title says 2019 but the chassis paperwork shows 2018 - something feels off here. I bought what I thought was a 2024 Tiffin Allegro Open Road, but when I got home and went to register it, the VIN shows it has a 2022 Ford chassis. The DMV registered it as a 2022, which means I've instantly lost two years of value!

I'm trying to figure out if this is normal in the RV industry or if I got taken advantage of. The dealer sold it as a 2024 model, but now I'm wondering if this kind of mismatch between the RV model year and the actual chassis year is standard practice. I've invested a lot in this RV and really hope there's a reasonable explanation for this discrepancy.

Can anyone explain if it's typical for RV manufacturers to use older chassis for newer model year RVs? I want to understand if this is legitimate or if I should be concerned about deceptive practices. …more

Read answer

Ac Refrigeration Medium 2-3 hours 88 👍 0

How to Replace RV Residential Refrigerator Mounting Brackets: Step-by-

During this tight budget month, is there any way to replace the mounting brackets on my GE residential refrigerator for under $100? The bracket that secures the fridge broke (as shown in the attached picture) during our last trip, and now I'm worried about it shifting around while we're driving.

I've been searching everywhere online but I'm not having any luck finding the exact part. Are these brackets something universal that I can get from RV parts suppliers, or do I need to go directly through GE? I'm also wondering if there's a way to fabricate something myself if I can't find the original part.

Any guidance on where to look or what my options are would be hugely appreciated - we have a trip planned next month and really need to get this fixed! …more

Read answer

Slideouts Medium 1-2 hours to diagnose 87 👍 0

How to Fix RV Slide Out Water Leak from Bottom - Wiper Seal Repair Guide for 2023 Models

About two weeks into living in my 2023 Forest River Forester MBS2401B and this slide out I've never dealt with before is leaking water from the bottom. The leak occurs specifically when the slide is in the retracted position during wind-driven rain events. Water is penetrating at floor level beneath the dinette area of the full wall slide assembly.

I have verified that all visible seals appear to be properly seated and the topper awning shows no obvious damage. Given that this is occurring on a current model year unit, I need to understand if this represents a manufacturing defect covered under warranty, and what specific component is likely causing the failure at the bottom of the slide mechanism. …more

Read answer

Loading more Q&A...

You've seen all 46 Q&A articles!