Results for "lithium-batteries"

Exterior Medium 30-60 min 155 👍 1

Kwikee RV Steps Not Working? Complete Troubleshooting Guide (2024)

Apparently we're leaving for a three-week cross-country trip next Monday and my Kwikee electric RV steps are still having intermittent retraction issues even after replacing both the gear box and motor. My steps are exhibiting intermittent retraction issues - they extend normally but require manual assistance to retract fully, stopping approximately a quarter inch through the cycle without intervention. I've already installed a new gear box and motor, yet the problem persists.

What systematic diagnostic approach should I follow to identify the root cause? I need to understand the complete troubleshooting sequence for motor functionality, electrical switch operation, and mechanical linkage components. Are there specific voltage measurements, resistance checks, or mechanical adjustments that should be performed to isolate whether this is an electrical or mechanical failure?

Thanks,
Pete …more

Read answer

Slideouts Medium 2-3 hours 115 👍 0

RV Slide Out Moving Slowly? Complete Lubrication & Repair Guide [2024]

I tried everything I could think of, but after all that heavy rain last week, my slide out went from smooth operation to moving like molasses. It sounds like it's really struggling and straining, making these awful grinding noises that have me worried I'm going to break something expensive.

I've been reading that lubrication might be the answer, but I honestly don't know where to start. Should I be looking at the motor mechanism? The tracks? I've heard about hydraulic fluid but I'm not sure if my system is hydraulic or electric. I really need someone to walk me through what needs lubrication and what else I should check before this thing stops working completely!

Could you help me troubleshoot? Details that might help: Can you tell me the specific model of my RV and the type of slide out system it uses? …more

Read answer

Exterior Medium 45 minutes 106 👍 0

RV Awning Won't Extend or Retract: Complete Troubleshooting & Repair Guide

This power awning manual says hold the extend button for 3 seconds, but mine's completely dead and won't budge no matter how long I hold it. When I hit the extend button, it moves out maybe 6-8 inches and then immediately retracts on its own. I have to turn the power switch off and back on each time to get even that little bit of movement.

I'm hesitant to keep forcing it since I don't want to burn out the motor or make whatever's wrong even worse. Could this be an electrical issue with low voltage, or maybe the tracks are too dirty? I've also heard about limit switches causing problems but I'm not sure how to check those safely.

What are the most common causes when an awning does this short extend-then-retract cycle? I want to start with the safest troubleshooting steps before calling a repair shop. …more

Read answer

Product Ranking 8 compared

Best RV Surge Protectors

4.6 (14,200 reviews)

Exterior Medium 2-3 hours 100 👍 0

Dometic 8300 Series Awning Torsion Assembly Replacement Guide (834AV44

Already burned through three Dometic 8300 torsion assemblies in six months and I'm hemorrhaging money as a new RV owner. The model number is 834AV44.138 and I'm not even sure what series this is - is it part of the 8300 series maybe?

The torsion assembly lever broke off and I can't seem to find exact replacement parts anywhere. I'm wondering if there are compatible parts from other Dometic awning models that would work with mine? I don't want to order the wrong thing and make the problem worse. Any guidance on finding the right replacement parts or temporary fixes would be really helpful! …more

Read answer

Exterior Hard Varies 92 👍 0

Carefree RV Awning Spring and Arm Replacement Guide - Model Compatibility Tips

According to my mechanic, fixing my 18-foot Carefree of Colorado awning's busted spring mechanism will cost $800, but I'm wondering if I can tackle this myself since there's zero tension left. Along with that, one of the support arms that helps transition the awning from travel position to deployed position is also damaged and needs replacement.

Before I start ordering parts or calling repair shops, I'm trying to understand how Carefree's replacement parts work. Are their springs and support arms universal components that work across different awning sizes and models, or does Carefree use proprietary parts that are specific to each awning series? I've been browsing their website but the parts compatibility information isn't very clear about what fits what.

I'd really appreciate any guidance on part compatibility and whether this is something I should tackle myself or leave to a professional. The spring replacement in particular seems like it might be tricky given the tension involved. …more

Read answer

Exterior Medium 2-4 hours with soak time 91 👍 0

How to Fix a Seized RV Side Mirror - Complete Repair Guide

Already picked up this 2002 Georgie Boy motorhome and I've never dealt with a seized side mirror adjustment mechanism before — the ball joint and set screws won't budge at all. I've been wrestling with this for weeks now and I'm getting nowhere!

Before I give up and start looking at replacements, is there any way to free up seized mirror adjustments? I'm also wondering about the electrical connections - if I do need to remove the mirror (it's held on with 3 screws), how do I safely disconnect those electric cables that run to the dash controls? I really don't want to damage the wiring harness on top of everything else. …more

Read answer

Chassis Medium 3-4 hours 89 👍 0

2003 Ford F53 RV Chassis Wheel Bearing Grease Guide - Best Products &

I'm wondering if my grease choice is wrong for my 2003 Ford F53's front bearing replacement when my neighbor's identical motorhome runs perfectly after his service. The original grease that came out was a dark gray/black color and while there wasn't any catastrophic damage, the races showed enough wear marks that I decided to replace everything while I'm in there.

I've been researching different options and keep seeing conflicting recommendations. Some people swear by standard lithium grease, others recommend full synthetic formulations, and I've even seen mentions of specific brands like Valvoline MaxLife and Timken. I know the F53 chassis carries significantly more weight than a typical pickup truck, so I want to make sure I'm using something that can handle the load.

I have the torque procedure down (30 ft-lbs initial, back off, then final setting at 17 in-lbs), but I want to make sure I'm pairing that proper installation with the right grease. What specific grease products work best for the F53 front wheel bearings, and are there any compatibility issues I should be aware of when selecting a replacement grease? …more

Read answer

Slideouts Medium 2-3 hours 83 👍 0

RV Stabilizer Jack Handle Spinning & Won't Retract: Complete Repair Guide

Apparently my neighbor's manual stabilizer jack retracts like butter every single time, while mine is completely stuck extended with a handle that spins uselessly. It cranked down fine but now won't come back up. What causes this spinning handle issue and how do I fix it? Is this something I can repair myself or do I need professional help? …more

Read answer

Electrical Hard Professional installation 78 👍 0

48V RV Electrical Systems: Complete Guide to Modern RV Power Upgrades and Efficiency

Tried upgrading my RV's electrical system but I'm standing in the supply store staring at 12V versus 48V components with zero clue what I actually need. The Bluetti RV5 caught my eye as an all-in-one solution that might make the jump easier.

But honestly, I'm still on the fence. What are the real benefits of going 48V? Is it actually that much better than sticking with 12V lithium? And are there any gotchas I should know about, especially with solar integration and getting everything certified for RV use? …more

Read answer

Exterior Medium 1-2 hours 76 👍 0

Kwikee Steps Won't Extend: Complete Troubleshooting & Repair Guide

Every time I open my RV door these Kwikee steps stay stuck at 90% retracted — should I drop $300+ on replacements or try fixing first?

I'm pretty sure this is either a motor that's given up the ghost or something's binding up in the linkage, but I'd love some confirmation before I start throwing parts at it. Should I be checking for 12V at the motor first, or am I overthinking this? And while we're at it, any preventive maintenance I should do to keep this from happening again? Because apparently my RV has commitment issues with working components. …more

Read answer

Solar Batteries Medium 4-6 hours 75 👍 0

Best 2000W Inverters for Grand Design RV: Complete Installation Guide

Noticed my Grand Design's warranty paperwork doesn't mention inverter installations — would installing a 2000W inverter void my coverage completely? except my dream apparently involves wanting to run actual appliances without firing up the generator at 6 AM and becoming "that neighbor" at the campground! 😅

My TT came with the prewired inverter loop (thank goodness, because my electrical skills peak at changing light bulbs), and I know it's wired with 10/2 Romex that can handle up to 2000 watts. Now I'm drowning in inverter options and getting analysis paralysis.

I'm looking for recommendations on the best 2000W pure sine wave inverters that'll play nice with my Grand Design's setup. Also completely confused about whether to go with an internal ATS for simplicity or bite the bullet and install an external transfer switch. Help a fellow glamper out - what are the top models you'd recommend, and what's the real difference between internal vs external switching options? …more

Read answer

Product Ranking 8 compared

Best RV Awnings & Accessories

4.5 (7,600 reviews)

General Easy N/A 69 👍 0

Forest River Georgetown GT3 Class A Motorhome: Complete Owner's Guide

Called a tow truck after that torrential rain last weekend left my Forest River Georgetown GT3's emergency brake on the left wheel completely stuck and won't disengage. I'm looking for advice on diagnosing and resolving this specific brake problem. Has anyone dealt with a similar emergency brake malfunction on this model? …more

Read answer

Electrical Easy N/A 69 👍 0

RV Red Warning Light: How to Identify Unknown Electrical Components

Woke up to find my RV's mystery electrical component glowing red instead of the green light the manual promised, and I can't even figure out what this thing is! In the picture I uploaded, you can see the component with the red warning light that just started appearing recently. I'm pretty sure that's not a good sign, right?

I'm thinking it might be some kind of detector or maybe part of the electrical system? There are so many gadgets crammed into these rigs. Anyone know what typically has red warning lights in RVs and what I should be looking for to figure out what this thing actually is? Would love to get it sorted before it becomes a bigger problem! …more

Read answer

Exterior Medium 1 hour 68 👍 0

How to Replace Broken RV Window Lock Arms: Complete Repair Guide

Walked out to check my RV last month when one window lock arm was just wobbly, but now three have completely snapped off! Several of my window lock arms have decided to give up the ghost, leaving me with windows that won't stay shut properly. I'm starting to feel like my RV is slowly falling apart one tiny plastic piece at a time.

I've been hunting around online but I'm drowning in generic hardware that doesn't seem to match what I need. Should I be looking at the original manufacturer, or are there universal replacement options that actually work? Any advice on the best places to source these parts without breaking the bank would be amazing! …more

Read answer

Loading more Q&A...

You've seen all 14 Q&A articles!