Results for "fault"

Plumbing Medium 2-4 hours 446 👍 9

RV Water Pump Losing Prime: Troubleshooting & Winterization

Got a 2022 Tiffin Open Road 34PA with a water pump that keeps losing prime during winterization — about to buy a replacement but wondering if I'm throwing money at the wrong problem? I can get it back by quickly opening and closing one of the lowest drain valves, but then it just loses prime again after a while. This has happened on other RVs I've winterized too, but it's particularly stubborn on this Tiffin.

I'm suspecting it might be the inline check valve next to the pump or maybe the one behind the Truma hot water heater, but I'd love some guidance on proper diagnosis. What are the most common causes of prime loss during winterization, and what's the best way to troubleshoot and fix this? I want to make sure I'm covering all my bases for winter storage prep. …more

Read answer

Electrical Medium 2-6 hours 301 👍 4

RV Electrical Problems: 12V & 120V Troubleshooting Guide 2024

Around $500 in parts later — replaced the main breaker, cleaned all connections, checked the transfer switch — my 2007 Holiday Rambler Admiral SE still won't recognize shore power.

I'm pretty sure 110V is making it to the rig since I can measure it, but somewhere between the plug and my appliances, something's not happy. Energy management panel is dark too. What's the logical troubleshooting order here? I keep hearing about transfer switches and breaker panels but honestly don't know where to start without making things worse! …more

Read answer

Engine Medium 2-6 hours 289 👍 1

Onan 5500 Generator Problems: Complete Repair Guide 2024

Spent three hours testing my 2014 Hurricane's Onan 5500 gen getting 11.8 volts output when every manual says it should be 12+ volts! Here's the weird part - when I disconnect the remote harness, the generator fires right up and purrs like a kitten. But the second I plug that remote connection back in, boom - both the remote start light AND the generator start light come on, and then... nothing. Won't start at all.

The really bizarre symptom is this chattering from the fuel pump when the remote is connected. I can literally feel the fuel line jumping around when I put my hand on it. It's like the pump is having some kind of seizure or something!

I'm guessing this has to be some kind of electrical issue between the control board and the remote system, but I've never seen anything quite like this before. Anyone dealt with this specific combo of symptoms on an Onan 5500? Really hoping there's a known fix because pulling this thing out of the RV again would be a major pain! …more

Read answer

Product Ranking 8 compared

Best RV Water Heaters

4.4 (6,800 reviews)

Electrical Medium 2-6 hours 230 👍 1

ECM Low Battery Warning RV: Complete Diagnosis & Fix Guide

During a family trip, my 2005 Fleetwood Discovery 39S threw code 168-1 for low ECM battery voltage and went into full shutdown mode—is this dangerous with kids onboard? Engine cut out, transmission selector went dark, ABS warnings everywhere - the whole nine yards. Scared the heck out of me when it happened on the interstate!

I'm seeing this seems to be a thing with these diesel pushers, but I'm drowning in conflicting info online. Some say it's the chassis battery, others blame alternator issues, and I've even seen posts about ECM power supply problems on the Caterpillar engines. What's the actual step-by-step process to track this down? And more importantly, how do I fix it so it doesn't leave me stranded again? Really need a complete walkthrough of what causes this code and the proper repair approach. …more

Read answer

Slideouts Medium 2-4 hours 208 👍 2

Power Gear Leveler Won't Retract: Complete Repair Guide

Called Power Gear support and they said press retract after leveling, but my system deployed perfectly and now just sits there doing absolutely nothing. The system appears to receive the retract command since I can hear some activity, but the legs remain extended. The only way to get them up is by engaging the transmission which triggers the emergency retract function.

I need a systematic approach to diagnose this retraction failure. What are the most likely causes when Power Gear levelers deploy normally but won't respond to the retract command, and what's the proper troubleshooting sequence to identify whether it's a solenoid valve issue, wiring problem, or control module failure? …more

Read answer

Plumbing Medium 1-2 hours 169 👍 0

Monaco Diplomat Rear Air Suspension Won't Dump Fully - Troubleshooting Guide

Last week my 2006 Monaco Diplomat's rear air bags started refusing to dump all the way down when I hit the air dump before leveling. The front dumps fine, but the back stays partially inflated.

I'm still pretty new to RV maintenance and not sure where to start troubleshooting this. Should I be hearing air escaping when I activate the dump? What are the most common causes when rear air bags won't dump completely? Any guidance on what to check would be really appreciated! …more

Read answer

General Medium 30 min research 149 👍 0

Best Cummins 6.7 Scan Tools for RV Diesel Diagnosis & DPF Regen (2024

The internet seems to give me six different answers about which scan tool actually works with my 2019 Fleetwood's Cummins 6.7L—am I missing something obvious here? Need comprehensive coverage for reading and clearing fault codes, monitoring engine parameters, and performing forced DPF regeneration cycles.

Considering several options including the Foxwell HD500, Ancel heavy-duty scanners, and various BlueFire/Inline adapters available through different suppliers. Price ranges vary significantly from budget OBD2 adapters to professional-grade diagnostic equipment.

Looking for detailed comparison of available scan tools specifically for Cummins 6.7 applications - both professional-grade and DIY-friendly options. What are the key features, compatibility considerations, and real-world performance differences between the various diagnostic solutions for this engine platform? …more

Read answer

Electrical Medium 30-90 min 140 👍 0

No 12 Volt Power in RV: Complete Troubleshooting Guide

Turned the key and nothing works on 12 volt — no lights, no water pump, no slides. Batteries show 12.6 volts on the multimeter so they're fully charged. House batteries seem fine but zero power is getting to any of the 12V circuits inside the coach. …more

Read answer

Ac Refrigeration Medium 2-3 hours 128 👍 0

Dometic RV AC Not Cooling? 5 Common Fixes for Air Conditioner Troubleshooting Guide

Walked out to my RV this morning trying to decide between calling a repair tech or troubleshooting my Dometic Brisk Air rooftop AC myself since it's showing weird operational issues. The compressor engages and fan motor operates normally, but the unit fails to produce cold air output. Temperature differential across the evaporator coil is minimal.

Unit functioned properly through previous cooling season with no apparent issues. Current symptoms include normal airflow volume but inadequate cooling capacity. What systematic diagnostic procedure should I follow to identify the root cause? Looking for a methodical troubleshooting sequence that addresses the most probable failure points in order of likelihood. …more

Read answer

Propane Medium 30 minutes 126 👍 2

RV Water Heater Pilot Light Won't Stay Lit: Thermocouple Troubleshooting Guide

Three different RV shops quoted me $400+ to fix my Suburban water heater's pilot light that won't stay lit and I'm wondering if I can tackle this thermocouple issue myself. the pilot lights up just fine, but the second I let go of that button it dies. I can hold it down for like a minute and think I've got it, but nope - releases and it's gone.

I'm wondering if this is one of those thermocouple things I keep hearing about? Like, is that the little sensor thingy that's supposed to keep the gas flowing when there's a flame? Pretty sure that's what's acting up but want to make sure before I start messing with it. …more

Read answer

Slideouts Medium 1-2 hours 124 👍 0

RV Slide Out Won't Retract: Motor Runs But Won't Move - Fix

Planning to use the same motor running trick that saved my old Winnebago's slide out, but this new rig's slide won't budge at all. It extended just fine this morning, but now when I try to bring it back in, the motor sounds like it's working but the slide isn't budging at all. I can hear it running but zero movement.

I'm trying to figure out if this is a hydraulic problem or if I've got a cable system that's gone haywire. Could it be something simple like low fluid, or am I looking at broken cables? Don't want to mess around with it too much without knowing what I'm dealing with first. …more

Read answer

Product Ranking 8 compared

Best RV Refrigerators

4.3 (9,200 reviews)

Ac Refrigeration Medium 2-3 hours for diagnosis, professional repair likely needed 122 👍 0

Coleman Mach AC Fuse Blows With Battery On - Rockwood Fix

Found out the hard way that the previous owner of my 2019 Rockwood Minilite 2509s left me with a Coleman Mach AC that blows fuses instantly when I flip on the battery. The AC fuse blows instantly when I turn on the battery disconnect, before the AC is even activated. The fuse literally blows before it's completely seated in the panel.

This began two weeks ago without warning - the system had been functioning normally prior to this. Initial fuse replacement provided temporary operation, but the problem returned on the next trip with the fuse already blown upon arrival.

Given the immediate fuse failure with just battery power connected, what type of electrical fault would cause this symptom pattern in a Coleman Mach unit, and what's the most likely location of the problem in the AC circuit? …more

Read answer

Solar Batteries Medium 1-2 hours 120 👍 0

Xantrex Freedom X 1200 Inverter Low Battery Warning: Critical 11.2V Fix Guide

Walked into my new RV and discovered the previous owner left the Xantrex Freedom X 1200 inverter constantly throwing critical 11.2V low battery warnings. My Xantrex Freedom X 1200 inverter is displaying warning indicators on the panel, and I'm seeing some concerning voltage readings that have me worried about potential damage to my electrical system.

Here's the complete situation: My house battery is reading 11.2 volts, while the chassis battery shows 13.1 volts. The inverter panel is lit up with what I assume are low voltage warnings. I've been noticing the interior lights dimming significantly, especially when trying to run any appliances through the inverter. To make matters worse, it's currently overcast and getting dark, so my solar panels aren't generating any meaningful charge to help recover the battery.

I'm particularly concerned because I know lead-acid batteries can be permanently damaged if they're discharged too deeply. The voltage reading of 11.2V seems critically low to me, but I want to understand exactly how urgent this situation is and what my immediate next steps should be. Should I be looking at shore power connection, generator use, or is there something wrong with my charging system that caused this in the first place? I need to know both the immediate fix and what might have caused this failure. …more

Read answer

Electrical Easy 30 minutes 120 👍 0

RV 12V Lights Dimming: Complete Troubleshooting Guide

My neighbor insists it's the converter, the RV dealer swears it's bad wiring, and every YouTube video claims it's a dying battery—but my 12V ceiling lights keep dimming! One evening they're blazing bright like a casino, the next morning they're giving off all the enthusiasm of a sleepy firefly.

I've already checked my batteries, and they seem to be charging fine and in good shape. The converter is still humming and its fan is running normally. I'm pretty sure this isn't some fancy mood lighting feature I accidentally activated (though knowing my tech skills, anything's possible). The dimming seems totally random - sometimes they're fine, sometimes they look like they're on their last legs.

I've got a basic multimeter that I pretend to know how to use, but I'm not sure where to even start poking around. As a bonus weirdness, some of my under-cabinet light switches and the wall switch for the ceiling lights are getting really hot. Anyone know what typically causes this whole disco light show situation with 12V lighting systems? …more

Read answer

Solar Batteries Medium 45 minutes 118 👍 0

RV MPPT Solar Controller E1 Error Code: Causes & Fixes

Halfway through troubleshooting my MPPT solar charge controller's E1 error — would this be covered under warranty, or am I stuck paying out-of-pocket? The controller was working fine for months, but now it's completely stopped charging my batteries and just displays this E1 fault code on the screen.

From what I've read, this could be related to battery over-voltage conditions or possibly some kind of wiring fault, but I want to make sure I understand all the potential causes before I start troubleshooting. I'm comfortable doing basic electrical work myself, but I also want to know when this might be something that requires professional attention for safety reasons.

Can someone provide a detailed breakdown of what the E1 error specifically indicates, walk me through the proper diagnostic steps to identify the root cause, and explain the repair process? I'd especially appreciate guidance on how to safely approach this troubleshooting and what warning signs would indicate I should call in an expert instead of attempting the fix myself. …more

Read answer

Loading more Q&A...

You've seen all 193 Q&A articles!