Results for "caps"

Exterior Medium 2-3 hours 161 👍 1

How to Replace RV Slide Topper Fabric: Complete DIY Guide 2024

I pulled into three different campsites this month and my torn slide topper is eating through my gear faster than I can replace it. I've never done anything like this before and I'm worried I might damage the whole mechanism or make things worse.

Can I actually replace just the fabric portion safely, or should I bite the bullet and have the entire assembly replaced by a professional? I'm also concerned about costs - I'm hoping this won't break the bank. If it is something I can do myself, how difficult is it really? I don't want to get in over my head and end up with a bigger problem than I started with.

Can you help me understand the best approach for my specific situation? …more

Read answer

Exterior Medium 45 minutes 105 👍 0

RV Awning Won't Extend or Retract: Complete Troubleshooting & Repair Guide

This power awning manual says hold the extend button for 3 seconds, but mine's completely dead and won't budge no matter how long I hold it. When I hit the extend button, it moves out maybe 6-8 inches and then immediately retracts on its own. I have to turn the power switch off and back on each time to get even that little bit of movement.

I'm hesitant to keep forcing it since I don't want to burn out the motor or make whatever's wrong even worse. Could this be an electrical issue with low voltage, or maybe the tracks are too dirty? I've also heard about limit switches causing problems but I'm not sure how to check those safely.

What are the most common causes when an awning does this short extend-then-retract cycle? I want to start with the safest troubleshooting steps before calling a repair shop. …more

Read answer

Exterior Medium 2-4 hours 104 👍 0

How to Fix Cracked Dometic RV AC Covers & Roof Vents: Complete Repair

Already tried following a YouTube tutorial to fix the cracked Dometic air conditioner cover on my 2022 East to West 1900MMK travel trailer but somehow made the crack even worse. What are my repair options - can I fix the crack or should I replace the whole cover?

Also dealing with a broken cap on the roof tank vent. I'm curious about material choices - I've noticed galvanized steel can rust, while PVC seems to degrade in sunlight. What are the pros and cons of different vent cap materials? What's a reasonable price range for replacement?

Looking for practical solutions for both issues. …more

Read answer

Product Ranking 8 compared

Best RV Water Heaters

4.4 (6,800 reviews)

Slideouts Hard 2-4 hours 97 👍 0

How to Fix RV Slideout Rubbing Against Exterior Wall - Complete Repair Guide

Finally figured out why my neighbor's slideout glides like butter while mine scrapes horribly against the exterior wall every time — what's their secret? My slideout has started rubbing against the exterior bathroom wall, and the coach is perfectly level.

The main thing I've noticed is that the gap at the bottom of the slide is much smaller now compared to the top - it used to be about 1½-2 inches at the bottom, but now it's barely anything. There's also about a ½ inch difference in height from one end of the slide to the other when I measure from the top.

I've independently jacked up both sides of the slide more than an inch each and checked the gap, but neither showed a difference. When I crawled underneath, I couldn't see where the slide might have moved laterally closer to the wall. The exterior stripes still line up. I also noticed the shower hasn't been used in 6 years or longer (I bought this coach used).

I'm wondering if this could be some kind of drooping issue? I've heard about things like rollers wearing out, but I honestly don't know what to look for or where to start troubleshooting. Should I be checking underneath the RV? Any advice on what might be causing this rubbing and smaller gap would be hugely appreciated! …more

Read answer

Exterior Easy 15 minutes 94 👍 0

How to Replace Your RV Door Awning Motor Cap: Step-by-Step Guide

I tried getting answers about my RV sideswipe damage but my insurance adjuster says it's totaled, three body shops say fixable, and forums are completely split. The coward took off at the highway exit before I could get his plates. Damage is to the bay doors and right front corner cap area - looks pretty ugly but the RV is still drivable. Police never showed up despite multiple calls over 4 hours of waiting. Already filed with insurance and sent photos, but I'm wondering what I should be looking for beyond the obvious visible damage. This is my first accident in 8 years of RVing and I'm stressed about hidden issues I might miss. Any advice on what to inspect or document before the adjuster comes out? …more

Read answer

Exterior Hard Varies 92 👍 0

Carefree RV Awning Spring and Arm Replacement Guide - Model Compatibility Tips

According to my mechanic, fixing my 18-foot Carefree of Colorado awning's busted spring mechanism will cost $800, but I'm wondering if I can tackle this myself since there's zero tension left. Along with that, one of the support arms that helps transition the awning from travel position to deployed position is also damaged and needs replacement.

Before I start ordering parts or calling repair shops, I'm trying to understand how Carefree's replacement parts work. Are their springs and support arms universal components that work across different awning sizes and models, or does Carefree use proprietary parts that are specific to each awning series? I've been browsing their website but the parts compatibility information isn't very clear about what fits what.

I'd really appreciate any guidance on part compatibility and whether this is something I should tackle myself or leave to a professional. The spring replacement in particular seems like it might be tricky given the tension involved. …more

Read answer

Exterior Medium 2-4 hours 92 👍 0

RV Awning Repair vs Replacement: When to Fix Torn Fabric

Apparently my RV manual says to replace the entire awning when the fabric tears, but everyone online seems to just patch or swap the fabric instead. My 2020 motorhome's awning fabric has developed a few tears - some small ones that are maybe 4-5 inches, but also a couple larger rips. The fabric also feels kind of stiff and brittle in places, especially where it's been exposed to the most sun.

I'm trying to figure out if I should attempt repairs or just bite the bullet and replace the fabric entirely. The frame itself seems to be in decent shape, so I think I'd only need new fabric rather than a whole new awning system. I've seen repair tapes advertised but I'm not sure if they actually work or how long they last.

What's the general rule of thumb for when awning fabric can be repaired versus when replacement makes more sense? And if I do need to replace just the fabric, what should I expect to pay for something decent? Thanks for any advice - I really don't want to make the wrong choice here! …more

Read answer

Engine Medium 2-3 hours 86 👍 0

Why Your RV Generac Diesel Generator Shuts Off After 2 Minutes Under Load: Troubleshooting Guide

Found that ever since those heavy rains last month hit, my 2007 Alfa's Generac 7.5kw diesel generator shuts down exactly 2 minutes after firing up the basement AC.

Just did a full service (oil, filters, the works) so it's not basic maintenance stuff. I can restart it right after it shuts off, but if the AC is still calling for power, it dies immediately again. No error codes or blinking lights to give me a clue.

Is this a fuel delivery issue where it can't keep up with the AC load? Or am I looking at something else entirely? Really hoping someone's dealt with this exact same 2-minute thing before! …more

Read answer

Chassis Medium 2-3 hours 84 👍 0

Ford F53 RV Power Steering Flush: Complete DIY Guide (1995-2022)

Looked under the hood of my newly purchased RV and discovered the previous owner left the F53's external power steering reservoir with three return lines in absolutely terrible condition. They all clamp onto separate fittings on the bottom of the reservoir.

I'm trying to figure out the right way to flush this system. Should I be disconnecting each return line one at a time from the reservoir and doing them separately? And if I do that, do I need to cap off the reservoir fitting where each line was connected so it doesn't just dump fluid everywhere when I'm working on the other components?

Or is there a simpler approach that'll get all three components clean without all the hassle of disconnecting lines? …more

Read answer

Exterior Medium 2-4 hours 82 👍 0

RV Awning Water Damage: Complete Repair vs Replace Guide (2024)

Tried getting quotes for my water-damaged RV awning and the $800 replacement estimate has me wondering if I can tackle this repair myself instead. Water pooled on it during a light rain because I had the angle wrong, and now something seems to be wrong with the spring mechanism - it's not retracting properly anymore.

I'm afraid to mess with it further without knowing what I'm dealing with. How can I safely assess whether the fabric, spring, or roller tube is damaged? I need to know if this is something I can repair or if I'm looking at a complete replacement. I don't want to make things worse by trying the wrong approach. …more

Read answer

Engine Medium 2-3 hours 82 👍 0

Ford F53 460 EGR Valve Cleaning Guide - Fix Motorhome Stalling Issues Now

Despite probably being a dumb question, why does my 1997 Ford F53 with the 460ci keep being such a real pain lately? Keeps stalling out when I'm sitting at lights or just idling around. This happens every 400-600 miles like clockwork - runs great for a while, then boom, stalling starts up again.

I'm pretty sure it's the EGR valve getting all carboned up because I've seen this pattern before. The thing is, I'm getting tired of dealing with this over and over. Should I just clean the EGR valve again, or is there a better long-term fix? I've heard people talk about EGR deletes but not sure if that's the way to go with the ECU and all that. …more

Read answer

Product Ranking 8 compared

Best RV Refrigerators

4.3 (9,200 reviews)

General Easy 1-2 hours 80 👍 0

How to Replace Kwikee Super Slide II Drive Wheels - Step-by-Step DIY Repair Guide

Planning to tackle my Kwikee Super Slide II drive wheel replacement myself versus paying a shop $300+ after they started making that awful metal-on-metal chattering noise. I've found pieces of old rubber near the slides where it's completely broken off the wheel cores.

I've looked into replacement OEM parts which cost around $75 per wheel, and I would need 8 wheels replaced. I've discovered a DIY repair method using a PMC-790 urethane rubber kit that could potentially fix this for much less. The total repair materials cost me about $134, compared to $600 for new wheels.

My repair process involved creating custom molds using 2-inch PVC test caps, 2.5-inch and 5/8-inch hole saws, and mixing urethane rubber in a specific 2:1 ratio. I even added blue colorant for fun. Has anyone else tried a similar approach to restoring these drive wheels? …more

Read answer

Exterior Medium 45 minutes 80 👍 0

RV Electric Awning Won't Retract Fully: Fix Bunching and Alignment Issues with Easy Steps

Woke up to my electric awning stuck 2 feet short of fully retracting, now I'm standing in the RV parts store staring at motors and alignment tools with zero clue which one I need. During the retraction process, I've observed the fabric bunching up significantly on one side while the opposite side appears to retract normally.

The motor continues to run when this occurs, suggesting it's not a power issue. I suspect this may be related to fabric tension irregularities or potential misalignment in the awning arm mechanism, but I need to confirm the root cause and understand the proper correction procedure.

What are the most likely causes of this partial retraction with uneven fabric bunching, and what systematic troubleshooting steps should I follow to resolve this issue? …more

Read answer

Plumbing Medium 45 minutes 79 👍 0

Newmar Bay Star 3826 Black Tank Vent Pipe Routing: Complete RV Location Guide

This dangerous sewer smell is seeping into my Newmar Bay Star 3826 where my kids are sleeping—could the black tank vent pipe routing be putting my family at risk? I can trace the half bath black tank vent line running through or adjacent to the electrical cabinet area, but I require confirmation of this routing.

The rear bathroom black tank vent pathway is less apparent during my inspection. I need to identify where this vent line routes from the tank connection point up to the roof termination. Understanding both vent pipe locations is critical for proper system maintenance and troubleshooting potential blockage issues. …more

Read answer

Engine Easy 30 minutes per wheel 78 👍 0

Dually Inner Tire Valve Stem Extenders: Where to Buy & Install Guide for RVs & Trucks

Got quoted for a whole new valve stem system on my Class C Ford E-450, but shouldn't 4.25x2.25 oval dually stabilizers work for these 225/75R16 tires instead? The inner dually tires are nearly impossible to check air pressure without proper extenders.

What are the best sources for purchasing these specific oval-shaped valve stem extenders? Also wondering if there are alternative solutions that might work better for accessing the inner tire valves. …more

Read answer

Loading more Q&A...

You've seen all 31 Q&A articles!