Results for "air leak"

Plumbing Medium 2-4 hours 447 👍 9

RV Water Pump Losing Prime: Troubleshooting & Winterization

Got a 2022 Tiffin Open Road 34PA with a water pump that keeps losing prime during winterization — about to buy a replacement but wondering if I'm throwing money at the wrong problem? I can get it back by quickly opening and closing one of the lowest drain valves, but then it just loses prime again after a while. This has happened on other RVs I've winterized too, but it's particularly stubborn on this Tiffin.

I'm suspecting it might be the inline check valve next to the pump or maybe the one behind the Truma hot water heater, but I'd love some guidance on proper diagnosis. What are the most common causes of prime loss during winterization, and what's the best way to troubleshoot and fix this? I want to make sure I'm covering all my bases for winter storage prep. …more

Read answer

Slideouts Medium 2-4 hours 208 👍 2

Power Gear Leveler Won't Retract: Complete Repair Guide

Called Power Gear support and they said press retract after leveling, but my system deployed perfectly and now just sits there doing absolutely nothing. The system appears to receive the retract command since I can hear some activity, but the legs remain extended. The only way to get them up is by engaging the transmission which triggers the emergency retract function.

I need a systematic approach to diagnose this retraction failure. What are the most likely causes when Power Gear levelers deploy normally but won't respond to the retract command, and what's the proper troubleshooting sequence to identify whether it's a solenoid valve issue, wiring problem, or control module failure? …more

Read answer

Engine Hard 2-3 hours for diagnosis 172 👍 0

1999 F53 V10 Oil in Coolant: Complete Head Gasket Diagnosis & Repair Guide

Called three dealerships about warranty coverage for oil contamination in my 1999 Ford F53 V10's coolant system — before I tackle this head gasket nightmare myself. The unit overheated after the oil level dropped significantly, though it still starts and runs without throwing any codes.

Based on the symptoms, I suspect a blown head gasket, but I want to perform proper diagnostic testing before committing to a major repair. What specific diagnostic procedures should I run to confirm whether this is actually a head gasket failure versus other potential causes like a cracked head or block issue?

Looking for a systematic approach to pinpoint the exact problem before I start tearing into this engine. …more

Read answer

Product Ranking 8 compared

Best RV Surge Protectors

4.6 (14,200 reviews)

Plumbing Medium 1-2 hours 169 👍 0

Monaco Diplomat Rear Air Suspension Won't Dump Fully - Troubleshooting Guide

Last week my 2006 Monaco Diplomat's rear air bags started refusing to dump all the way down when I hit the air dump before leveling. The front dumps fine, but the back stays partially inflated.

I'm still pretty new to RV maintenance and not sure where to start troubleshooting this. Should I be hearing air escaping when I activate the dump? What are the most common causes when rear air bags won't dump completely? Any guidance on what to check would be really appreciated! …more

Read answer

Engine Easy N/A 164 👍 0

Ford V10 Triton Engine Maintenance Guide: EGR Delete vs Regular Service Tips

Spent years doing regular EGR maintenance on my old gas motorhome without issues — but this 2007 Fleetwood 31' Tioga with Ford V10 Triton has me second-guessing everything. I keep reading conflicting information about EGR delete procedures on V10 engines, and I'm worried I might make things worse if I mess with it.

Is the EGR delete modification actually necessary on this 2007 3-valve V10, or am I overthinking this? I don't want to void any warranties or create problems that weren't there before. Would I be better off just sticking to regular maintenance instead of modifications? I'm looking for reassurance that I'm taking the right approach to keep this engine running reliably for years to come. …more

Read answer

Electrical Medium 1-2 hours 147 👍 0

How to Repair a Hole in RV Grey Water Tank

Tried marine epoxy on my old Class A's tank and it worked perfectly — but now I've drilled a 1 inch hole in my ABS grey water tank while running battery cables. The hole is in an awkward spot near the rear wheel vault with thick metal bars and beams, making repairs challenging.

What's the best way to repair this? I've prepared a patch by flattening and heat forming a pipe section, beveling edges and scouring surfaces for a strong mechanical bond. Should I cement the ABS patch and then cover with fiberglass, or are there other recommended repair methods? I want to ensure a durable fix for this tricky tank damage. …more

Read answer

Engine Easy 15 min read 141 👍 0

Remote RV Diesel Fueling: Complete Guide for Campground Fuel Strategies

Last night at 11 PM I'm staring at my diesel RV's fuel gauge showing nearly empty — need to figure out remote campground fuel strategies before we head out this morning. With a 5 gallon Harbor Freight stick transfer pump, I've been able to add fuel when truck stops aren't convenient, but I'm concerned about static electricity risks.

My current setup involves using the pump to transfer diesel with the fuel can on a camping table, since my RV's fuel inlet is located under a slide. I pumped 10 gallons successfully, but I'm wondering about the safety of this method.

I know there are static electricity concerns when transferring fuel, and I'm curious about the specific risks with diesel. How safe is it to transfer fuel when the can isn't directly grounded to concrete? Are there best practices I should follow when manually adding diesel in remote locations? …more

Read answer

Engine Easy N/A 133 👍 0

Ford E-350 vs E-450 Chassis: RV Fuel Economy, Power & Weight Capacity

Last weekend I felt this awful engine strain and heard sluggish acceleration sounds while test-driving a 2017 Phoenix Cruiser #2351 with its E-350 chassis and V10 engine. I'll be doing extensive western touring through mountain and plains regions, which means substantial mountain grades and wind challenges. I'm comfortable driving slowly and want to understand two key things: 1) Will this E-350 chassis handle mountain grades without major issues, and 2) What's the real-world fuel consumption like? I plan to do an initial inspection this weekend, followed by a third-party mechanical review. I'm not overly concerned about fuel economy but want to understand the actual performance limitations. I'd appreciate insights from owners who have experience with similar touring conditions on an E-350 chassis. …more

Read answer

Ac Refrigeration Medium 2-3 hours 133 👍 0

Norcold 1210 Not Cooling: No Error Codes Troubleshooting Guide

During my morning RV check I spotted my Norcold 1210 completely dead with zero cooling that was running perfectly yesterday with no error codes. Unit appears to be operating normally with no error codes displayed, but it's not cooling properly. Interior temperature is staying above 50 degrees. Thermistor has been tested and checks out fine. What else should I look at? …more

Read answer

Ac Refrigeration Easy 30 minutes 131 👍 0

RV AC Freezing Up? Fix Ice on Coils in 5 Steps

Turned on my RV's AC as a total newbie and watched it run perfectly for an hour before becoming a frozen disaster that won't cool. I can literally see ice building up on the coils, and then it's game over until everything thaws out.

This has happened a few times now and I'm getting tired of sitting in a hot RV waiting for the thing to defrost. What actually causes AC units to freeze up like this? And more importantly, how do I stop it from happening again? I'm guessing it's something simple I'm missing, but I'd rather fix it right than keep dealing with this cycle. …more

Read answer

Propane Easy 30 minutes 128 👍 0

RV Propane Regulator Freezing Up? Common Causes & Easy Fixes

About the third time this season my propane system is acting up during cold weather prep and I'm done trying to figure this out on my own. When temperatures drop, I notice my propane regulator develops frost on it and the gas flow seems to slow down or stop completely. This makes me nervous - is this actually normal behavior or do I have a serious problem?

I'm worried about running my furnace and other propane appliances when this happens. Should I be concerned about safety? And if this freezing is normal, what's the safest way to prevent it from happening? I don't want to do anything that might make the situation worse or create a hazardous condition. …more

Read answer

Product Ranking 8 compared

Best RV Batteries

4.5 (15,400 reviews)

Ac Refrigeration Medium 2-3 hours 128 👍 0

Dometic RV AC Not Cooling? 5 Common Fixes for Air Conditioner Troubleshooting Guide

Walked out to my RV this morning trying to decide between calling a repair tech or troubleshooting my Dometic Brisk Air rooftop AC myself since it's showing weird operational issues. The compressor engages and fan motor operates normally, but the unit fails to produce cold air output. Temperature differential across the evaporator coil is minimal.

Unit functioned properly through previous cooling season with no apparent issues. Current symptoms include normal airflow volume but inadequate cooling capacity. What systematic diagnostic procedure should I follow to identify the root cause? Looking for a methodical troubleshooting sequence that addresses the most probable failure points in order of likelihood. …more

Read answer

Propane Medium 30 minutes 126 👍 2

RV Water Heater Pilot Light Won't Stay Lit: Thermocouple Troubleshooting Guide

Three different RV shops quoted me $400+ to fix my Suburban water heater's pilot light that won't stay lit and I'm wondering if I can tackle this thermocouple issue myself. the pilot lights up just fine, but the second I let go of that button it dies. I can hold it down for like a minute and think I've got it, but nope - releases and it's gone.

I'm wondering if this is one of those thermocouple things I keep hearing about? Like, is that the little sensor thingy that's supposed to keep the gas flowing when there's a flame? Pretty sure that's what's acting up but want to make sure before I start messing with it. …more

Read answer

Slideouts Medium 1-2 hours 124 👍 0

RV Slide Out Won't Retract: Motor Runs But Won't Move - Fix

Planning to use the same motor running trick that saved my old Winnebago's slide out, but this new rig's slide won't budge at all. It extended just fine this morning, but now when I try to bring it back in, the motor sounds like it's working but the slide isn't budging at all. I can hear it running but zero movement.

I'm trying to figure out if this is a hydraulic problem or if I've got a cable system that's gone haywire. Could it be something simple like low fluid, or am I looking at broken cables? Don't want to mess around with it too much without knowing what I'm dealing with first. …more

Read answer

Propane Easy 30 min 121 👍 0

RV LP Gas Detector False Alarms: Complete Troubleshooting Guide

Already tried everything but my RV's LP gas detector has false alarms in the garage, keeps beeping at random times, AND won't reset properly. Even with the LP tank completely shut off, the alarm still goes off within hours. It's located in the bottom of the fridge cabinet.

I've checked everywhere for actual leaks - can't smell anything, and all my appliances still light immediately when I take the RV out. The detector seems fine outside but becomes a nightmare indoors. I'm wondering if it's the sensor going bad, poor placement, or if there are other things that can trigger these detectors besides actual propane leaks?

I really need a complete breakdown of what causes these false alarms and how to fix this issue once and for all. Should I be looking at replacing the detector entirely, or are there troubleshooting steps I'm missing? …more

Read answer

Loading more Q&A...

You've seen all 168 Q&A articles!