Results for "troubleshooting"

Ac Refrigeration Medium 2-3 hours 1,830 👍 0

Norcold 1210 Not Cooling: No Error Codes Troubleshooting Guide

During my morning RV check I spotted my Norcold 1210 completely dead with zero cooling that was running perfectly yesterday with no error codes. Unit appears to be operating normally with no error codes displayed, but it's not cooling properly. Interior temperature is staying above 50 degrees. Thermistor has been tested and checks out fine. What else should I look at? …more

Read answer

Electrical Medium 2-4 hours 742 👍 0

RV Chassis Battery Draining & Dead Outlets - Troubleshooting

Finally followed the manual's advice to check the converter first when my outlets died, but my RV chassis battery keeps draining even though the converter tests perfectly. here and I'm at my wit's end with my 2018 Winnebago Vista. The chassis battery keeps going completely dead every few days, even when we're plugged into shore power at the campground. I've already replaced the battery twice thinking it was just old, checked all the obvious stuff like dome lights and radio, and even had the alternator tested - everything checks out fine.

What's really driving me crazy is that this just started happening about a month ago out of nowhere. We've been full-timing for three years without any major electrical issues. I'm wondering if there's some parasitic draw I'm missing or if the battery isolator could be acting up? Has anyone else dealt with this nightmare? I'm getting tired of jump-starting this thing every other day and my wife is about ready to sell the rig and get a travel trailer instead! …more

Read answer

Plumbing Medium 2-4 hours 663 👍 9

RV Water Pump Losing Prime: Troubleshooting & Winterization

Got a 2022 Tiffin Open Road 34PA with a water pump that keeps losing prime during winterization — about to buy a replacement but wondering if I'm throwing money at the wrong problem? I can get it back by quickly opening and closing one of the lowest drain valves, but then it just loses prime again after a while. This has happened on other RVs I've winterized too, but it's particularly stubborn on this Tiffin.

I'm suspecting it might be the inline check valve next to the pump or maybe the one behind the Truma hot water heater, but I'd love some guidance on proper diagnosis. What are the most common causes of prime loss during winterization, and what's the best way to troubleshoot and fix this? I want to make sure I'm covering all my bases for winter storage prep. …more

Read answer

Product Ranking 8 compared

Best RV Surge Protectors

4.6 (14,200 reviews)

Electrical Medium 45 minutes 650 👍 0

RV Backup Camera Not Working? Complete Troubleshooting Guide

Spent all winter enjoying a perfectly working RV backup camera, but the second temperatures hit 85 degrees outside, my screen goes completely black. My wireless backup camera decided to give me the silent treatment right when I need it most. The monitor is just sitting there mocking me with a "no signal" message, and honestly, my spatial awareness isn't what it used to be.

The camera worked fine on our last camping trip (when I only needed to back up twice), but now that I'm trying to navigate tight campground spots, it's gone completely dark. I'm dealing with a wireless system, so I know there are more things that can go wrong than with a wired setup.

Before I resort to using my spouse as a very expensive parking sensor, what's the best way to troubleshoot this? I'm hoping it's something simple like a loose connection rather than having to explain to my insurance company why there's a picnic table embedded in my bumper. …more

Read answer

Engine Medium 2-6 hours 581 👍 1

Onan 5500 Generator Problems: Complete Repair Guide

Spent three hours testing my 2014 Hurricane's Onan 5500 gen getting 11.8 volts output when every manual says it should be 12+ volts! Here's the weird part - when I disconnect the remote harness, the generator fires right up and purrs like a kitten. But the second I plug that remote connection back in, boom - both the remote start light AND the generator start light come on, and then... nothing. Won't start at all.

The really bizarre symptom is this chattering from the fuel pump when the remote is connected. I can literally feel the fuel line jumping around when I put my hand on it. It's like the pump is having some kind of seizure or something!

I'm guessing this has to be some kind of electrical issue between the control board and the remote system, but I've never seen anything quite like this before. Anyone dealt with this specific combo of symptoms on an Onan 5500? Really hoping there's a known fix because pulling this thing out of the RV again would be a major pain! …more

Read answer

General Medium 30-60 minutes 530 👍 0

RV Liquid Spring Adjustment Guide: Setup & Tuning Tips

Three different adjustment knobs on my 2022 Tiffin Open Road 34PA's LiquidSpring suspension and I'm staring at them with zero clue about the limits.

I've got LiquidSpring suspension on all four corners, but I'm specifically wondering about the rear struts. Can I raise and lower just the rear ones independently, or am I stuck adjusting everything at once like some kind of suspension caveman? I'd love to dial in the perfect ride height and handling, but I need to know if I can fine-tune the back end separately from the front. Between the control panel and what I assume is some fancy smartphone app, surely there's a way to make this old road warrior ride like a dream without turning into a mechanical engineer, right? …more

Read answer

Electrical Medium 2-6 hours 453 👍 4

RV Electrical Problems: 12V & 120V Troubleshooting Guide

Around $500 in parts later — replaced the main breaker, cleaned all connections, checked the transfer switch — my 2007 Holiday Rambler Admiral SE still won't recognize shore power.

I'm pretty sure 110V is making it to the rig since I can measure it, but somewhere between the plug and my appliances, something's not happy. Energy management panel is dark too. What's the logical troubleshooting order here? I keep hearing about transfer switches and breaker panels but honestly don't know where to start without making things worse! …more

Read answer

Engine Hard 4-6 hours 424 👍 0

Ford F53 7.5L RV Won't Start: Fuel Pump Relay Voltage Drop Fix

Woke up to my 1996 Ford F53 7.5L motorhome eating through my patience and wallet with this no-start issue that keeps coming back. It cranks strong but absolutely will not start, and I've been chasing this problem for weeks now. The engine ran fine for about 3-4 minutes one day, then just died and hasn't started since.

I've already done quite a bit of diagnostic work:
- Replaced PCM and distributor
- Fuel pump works when powered directly
- Battery is fully charged
- Checked fuses and relays
- PCM relay voltage drops from 12.2V to 9.3V with key on
- Fuel pump relay only shows 3.3V at pin 86 (should be 12V)
- Inertia switch tested at 1.7V at connector
- ANL 178 fusible link fluctuates between 0.3-0.6V

The engine will only start with starter fluid when the SPOUT is removed. I'm getting only 5.5V at the fuel pump connector.

Has anyone dealt with this specific issue on an F53 chassis? I really need to get this RV back on the road and I'm running out of ideas! …more

Read answer

Ac Refrigeration Medium 45 minutes 416 👍 0

Dometic 12V Refrigerator Not Cooling on Battery Power - Complete Troubleshooting Guide

Staring at my Dometic DMC compressor refrigerator that runs perfectly on 12V DC when it's cool but stops cooling completely once temperatures hit 85°F or higher. The unit works perfectly when I'm plugged into shore power at campgrounds - everything stays cold and the freezer compartment keeps items frozen solid. However, when I'm boondocking and running solely on my RV's battery bank, the performance drops significantly. The refrigerator struggles to maintain proper temperatures, and the freezer can't keep things frozen.

I have a relatively new battery setup with what should be adequate capacity for my power needs. The batteries test fine with a multimeter when the refrigerator isn't running, but I'm wondering if there's something I'm missing about power requirements or electrical connections. I've heard that 12V compressor refrigerators can be pretty demanding on battery systems, but I'm not sure what specific issues to look for.

What are the most common causes when a 12V Dometic compressor refrigerator works fine on shore power but fails to cool properly when running on batteries? I want to troubleshoot this systematically before calling in a technician. …more

Read answer

Engine Medium 2-4 hours 374 👍 0

Generac 7.5kW Diesel Generator Repair Guide - RV Troubleshooting

Planning to ignore the weird noises from our Generac 7.5kW diesel generator backfired when my wife pointed out I definitely made things worse during my repair attempt. I have a 2007 Monaco with a Generac 7.5kW diesel generator, and yesterday when I tried starting it, the battery was really weak. I probably held the starter button too long - maybe 15 seconds or so - because it was cranking so slowly and I kept hoping it would catch.

Now when I try to start it, I just get a single click and nothing happens. I'm worried I damaged something by cranking it so long with that weak battery. Should I be looking at the starter solenoid or starter motor? Is there anything I can check myself before I have to take it to a repair shop? I'd really appreciate any guidance on troubleshooting this. …more

Read answer

Electrical Medium 2-6 hours 365 👍 1

ECM Low Battery Warning RV: Complete Diagnosis & Fix Guide

During a family trip, my 2005 Fleetwood Discovery 39S threw code 168-1 for low ECM battery voltage and went into full shutdown mode—is this dangerous with kids onboard? Engine cut out, transmission selector went dark, ABS warnings everywhere - the whole nine yards. Scared the heck out of me when it happened on the interstate!

I'm seeing this seems to be a thing with these diesel pushers, but I'm drowning in conflicting info online. Some say it's the chassis battery, others blame alternator issues, and I've even seen posts about ECM power supply problems on the Caterpillar engines. What's the actual step-by-step process to track this down? And more importantly, how do I fix it so it doesn't leave me stranded again? Really need a complete walkthrough of what causes this code and the proper repair approach. …more

Read answer

Product Ranking 8 compared

Best RV Water Heaters

4.4 (6,800 reviews)

Plumbing Medium 1-2 hours 363 👍 0

Monaco Diplomat Rear Air Suspension Won't Dump Fully - Troubleshooting Guide

Last week my 2006 Monaco Diplomat's rear air bags started refusing to dump all the way down when I hit the air dump before leveling. The front dumps fine, but the back stays partially inflated.

I'm still pretty new to RV maintenance and not sure where to start troubleshooting this. Should I be hearing air escaping when I activate the dump? What are the most common causes when rear air bags won't dump completely? Any guidance on what to check would be really appreciated! …more

Read answer

Exterior Hard 2-8 hours for temporary fix, 1-5 days for permanen 348 👍 1

RV Sidewall Blistering & Delamination Repair Guide

According to three different RV shops, fixing my bubbling sidewall delamination will cost thousands, but I'm wondering if tackling this DIY repair myself is actually feasible. My 2004 Itasca Sunova has decided to sprout some lovely blisters on the right sidewall - two beauties that are about 12-14 inches long and 3-4 inches wide, running vertically right behind the awning arm. Perfect timing since we're currently on the road living our best RV life!

I'm pretty sure water snuck in somewhere (probably from the roof rail or that shower skylight we never use), and now my RV looks like it's got chicken pox. Since we can't exactly pull into the nearest RV surgeon's office, I need to know: what can I do right now to stop this from getting worse, and what's involved in actually fixing this mess properly? I'm hoping there's some kind of emergency containment plan that doesn't involve duct tape and prayers! …more

Read answer

Ac Refrigeration Medium 30 minutes 330 👍 0

RV Refrigerator Ammonia Smell: Leak Repair & Safety Guide

Last spring when I opened up my RV for the first camping trip, that same overwhelming ammonia stench hit me the moment I cracked open the refrigerator door. It seems to be getting worse and I can smell it throughout the coach now. I'm scared this might be some kind of refrigerant leak but I'm not sure.

Is it safe to keep using the refrigerator? Should I be concerned about health risks from breathing this in? I don't want to make the situation worse or put my family in danger. What should I do immediately to stay safe? …more

Read answer

Slideouts Medium 2-4 hours 318 👍 2

Power Gear Leveler Won't Retract: Complete Repair Guide

Called Power Gear support and they said press retract after leveling, but my system deployed perfectly and now just sits there doing absolutely nothing. The system appears to receive the retract command since I can hear some activity, but the legs remain extended. The only way to get them up is by engaging the transmission which triggers the emergency retract function.

I need a systematic approach to diagnose this retraction failure. What are the most likely causes when Power Gear levelers deploy normally but won't respond to the retract command, and what's the proper troubleshooting sequence to identify whether it's a solenoid valve issue, wiring problem, or control module failure? …more

Read answer

Loading more Q&A...

You've seen all 264 Q&A articles!