Results for "troubleshoot"

Plumbing Medium 2-4 hours 446 👍 9

RV Water Pump Losing Prime: Troubleshooting & Winterization

Got a 2022 Tiffin Open Road 34PA with a water pump that keeps losing prime during winterization — about to buy a replacement but wondering if I'm throwing money at the wrong problem? I can get it back by quickly opening and closing one of the lowest drain valves, but then it just loses prime again after a while. This has happened on other RVs I've winterized too, but it's particularly stubborn on this Tiffin.

I'm suspecting it might be the inline check valve next to the pump or maybe the one behind the Truma hot water heater, but I'd love some guidance on proper diagnosis. What are the most common causes of prime loss during winterization, and what's the best way to troubleshoot and fix this? I want to make sure I'm covering all my bases for winter storage prep. …more

Read answer

Electrical Medium 2-6 hours 301 👍 4

RV Electrical Problems: 12V & 120V Troubleshooting Guide 2024

Around $500 in parts later — replaced the main breaker, cleaned all connections, checked the transfer switch — my 2007 Holiday Rambler Admiral SE still won't recognize shore power.

I'm pretty sure 110V is making it to the rig since I can measure it, but somewhere between the plug and my appliances, something's not happy. Energy management panel is dark too. What's the logical troubleshooting order here? I keep hearing about transfer switches and breaker panels but honestly don't know where to start without making things worse! …more

Read answer

Electrical Medium 2-6 hours 230 👍 1

ECM Low Battery Warning RV: Complete Diagnosis & Fix Guide

During a family trip, my 2005 Fleetwood Discovery 39S threw code 168-1 for low ECM battery voltage and went into full shutdown mode—is this dangerous with kids onboard? Engine cut out, transmission selector went dark, ABS warnings everywhere - the whole nine yards. Scared the heck out of me when it happened on the interstate!

I'm seeing this seems to be a thing with these diesel pushers, but I'm drowning in conflicting info online. Some say it's the chassis battery, others blame alternator issues, and I've even seen posts about ECM power supply problems on the Caterpillar engines. What's the actual step-by-step process to track this down? And more importantly, how do I fix it so it doesn't leave me stranded again? Really need a complete walkthrough of what causes this code and the proper repair approach. …more

Read answer

Product Ranking 8 compared

Best RV Awnings & Accessories

4.5 (7,600 reviews)

Engine Medium 2-4 hours 216 👍 0

Generac 7.5kW Diesel Generator Repair Guide - RV Troubleshooting

Planning to ignore the weird noises from our Generac 7.5kW diesel generator backfired when my wife pointed out I definitely made things worse during my repair attempt. I have a 2007 Monaco with a Generac 7.5kW diesel generator, and yesterday when I tried starting it, the battery was really weak. I probably held the starter button too long - maybe 15 seconds or so - because it was cranking so slowly and I kept hoping it would catch.

Now when I try to start it, I just get a single click and nothing happens. I'm worried I damaged something by cranking it so long with that weak battery. Should I be looking at the starter solenoid or starter motor? Is there anything I can check myself before I have to take it to a repair shop? I'd really appreciate any guidance on troubleshooting this. …more

Read answer

General Medium 30-60 minutes 208 👍 0

RV Liquid Spring Adjustment Guide: Setup & Tuning Tips

Three different adjustment knobs on my 2022 Tiffin Open Road 34PA's LiquidSpring suspension and I'm staring at them with zero clue about the limits.

I've got LiquidSpring suspension on all four corners, but I'm specifically wondering about the rear struts. Can I raise and lower just the rear ones independently, or am I stuck adjusting everything at once like some kind of suspension caveman? I'd love to dial in the perfect ride height and handling, but I need to know if I can fine-tune the back end separately from the front. Between the control panel and what I assume is some fancy smartphone app, surely there's a way to make this old road warrior ride like a dream without turning into a mechanical engineer, right? …more

Read answer

Slideouts Medium 2-4 hours 208 👍 2

Power Gear Leveler Won't Retract: Complete Repair Guide

Called Power Gear support and they said press retract after leveling, but my system deployed perfectly and now just sits there doing absolutely nothing. The system appears to receive the retract command since I can hear some activity, but the legs remain extended. The only way to get them up is by engaging the transmission which triggers the emergency retract function.

I need a systematic approach to diagnose this retraction failure. What are the most likely causes when Power Gear levelers deploy normally but won't respond to the retract command, and what's the proper troubleshooting sequence to identify whether it's a solenoid valve issue, wiring problem, or control module failure? …more

Read answer

Solar Batteries Medium 2-4 hours 201 👍 0

RC7-GS Inverter AGM Battery Settings: Complete Setup Guide

Replaced my 105Ah AGM battery and now my RC7-GS inverter charger is completely rejecting it like this capacity doesn't exist in its programming.

The charging settings only go from 125Ah up to 1000Ah, with an 'auto' option that supposedly 'learns' my battery but resets every time the low voltage cutoff trips (which feels like cheating, honestly). I'm worried about undercharging or cooking my expensive new AGMs if I pick the wrong setting.

Oh, and while we're talking about things that don't work as advertised - the generator auto-start feature might as well be a myth. Can't even manually start the generator from the RC7 panel. At this point I'm wondering if I should have just stuck with my old setup that actually worked! Anyone know what I'm doing wrong here? …more

Read answer

Plumbing Medium 1-2 hours 169 👍 0

Monaco Diplomat Rear Air Suspension Won't Dump Fully - Troubleshooting Guide

Last week my 2006 Monaco Diplomat's rear air bags started refusing to dump all the way down when I hit the air dump before leveling. The front dumps fine, but the back stays partially inflated.

I'm still pretty new to RV maintenance and not sure where to start troubleshooting this. Should I be hearing air escaping when I activate the dump? What are the most common causes when rear air bags won't dump completely? Any guidance on what to check would be really appreciated! …more

Read answer

Exterior Medium 30-60 min 155 👍 1

Kwikee RV Steps Not Working? Complete Troubleshooting Guide (2024)

Apparently we're leaving for a three-week cross-country trip next Monday and my Kwikee electric RV steps are still having intermittent retraction issues even after replacing both the gear box and motor. My steps are exhibiting intermittent retraction issues - they extend normally but require manual assistance to retract fully, stopping approximately a quarter inch through the cycle without intervention. I've already installed a new gear box and motor, yet the problem persists.

What systematic diagnostic approach should I follow to identify the root cause? I need to understand the complete troubleshooting sequence for motor functionality, electrical switch operation, and mechanical linkage components. Are there specific voltage measurements, resistance checks, or mechanical adjustments that should be performed to isolate whether this is an electrical or mechanical failure?

Thanks,
Pete …more

Read answer

Plumbing Medium 1-2 hours 155 👍 0

RV Grey Water Tank Clogged? 7 Proven Solutions to Clear Blockages Fast

Found out my RV service tech wants $800+ to replace the entire grey water system on my 2007 RV for an intermittent blockage that seems fixable. It doesn't seem to matter if we're level or not - it's completely random.

I've tried using a high suction shop vac and even attempted snaking it, but I'm nervous about forcing things and making the problem worse. I suspect it might be a manufacturing plug that fell into the tank, but I'm not sure. I found one solution with a reverse flush valve that seems to work temporarily, but I'm concerned about the underlying cause.

What are the safest and most proven methods to diagnose and fix these random grey water blockages? I don't want to damage the tank or create bigger problems, but this unpredictable draining is driving me crazy. Are there specific cleaning products or techniques that actually work without risking harm to the system? …more

Read answer

Electrical Medium 45 minutes 154 👍 0

RV Backup Camera Not Working? Complete Troubleshooting Guide

Spent all winter enjoying a perfectly working RV backup camera, but the second temperatures hit 85 degrees outside, my screen goes completely black. My wireless backup camera decided to give me the silent treatment right when I need it most. The monitor is just sitting there mocking me with a "no signal" message, and honestly, my spatial awareness isn't what it used to be.

The camera worked fine on our last camping trip (when I only needed to back up twice), but now that I'm trying to navigate tight campground spots, it's gone completely dark. I'm dealing with a wireless system, so I know there are more things that can go wrong than with a wired setup.

Before I resort to using my spouse as a very expensive parking sensor, what's the best way to troubleshoot this? I'm hoping it's something simple like a loose connection rather than having to explain to my insurance company why there's a picnic table embedded in my bumper. …more

Read answer

Product Ranking 8 compared

Best RV Air Conditioners

4.4 (8,100 reviews)

General Medium 30 min research 149 👍 0

Best Cummins 6.7 Scan Tools for RV Diesel Diagnosis & DPF Regen (2024

The internet seems to give me six different answers about which scan tool actually works with my 2019 Fleetwood's Cummins 6.7L—am I missing something obvious here? Need comprehensive coverage for reading and clearing fault codes, monitoring engine parameters, and performing forced DPF regeneration cycles.

Considering several options including the Foxwell HD500, Ancel heavy-duty scanners, and various BlueFire/Inline adapters available through different suppliers. Price ranges vary significantly from budget OBD2 adapters to professional-grade diagnostic equipment.

Looking for detailed comparison of available scan tools specifically for Cummins 6.7 applications - both professional-grade and DIY-friendly options. What are the key features, compatibility considerations, and real-world performance differences between the various diagnostic solutions for this engine platform? …more

Read answer

General Medium 30-60 min 148 👍 1

RV Infotainment System Update Guide: Step-by-Step Safety Instructions

Three weeks ago my 2023 Aspire's infotainment system occasionally wouldn't recognize the update USB, but now it just blinks endlessly without doing anything. Has anyone experienced this specific issue with this RV model's system? I want to understand what might be preventing the update from proceeding. …more

Read answer

Electrical Medium 30-90 min 140 👍 0

No 12 Volt Power in RV: Complete Troubleshooting Guide

Turned the key and nothing works on 12 volt — no lights, no water pump, no slides. Batteries show 12.6 volts on the multimeter so they're fully charged. House batteries seem fine but zero power is getting to any of the 12V circuits inside the coach. …more

Read answer

General Easy 20 min research 137 👍 0

How to Find Reliable RV Repair Shops: Expert Tips & Red Flags to Watch Out For

About every summer my 2004 Adventurer runs like a dream until temps hit 85°F, then it breaks down constantly and no shop can figure out why. The main slide out has been acting up with the HWH hydraulic system, and I honestly don't know enough to fix it myself.

I'm worried about getting taken advantage of since I don't really know what questions to ask or what warning signs to watch out for. I've heard horror stories about people paying huge bills for shoddy work. What's the best way to research and find a reliable shop? Are there specific things I should ask them before I commit to having work done?

Any guidance would be really appreciated - I just want to make sure I'm being smart about this and not walking into a bad situation. …more

Read answer

Loading more Q&A...

You've seen all 225 Q&A articles!