Results for "stop points"

Plumbing Medium 2-4 hours 446 👍 9

RV Water Pump Losing Prime: Troubleshooting & Winterization

Got a 2022 Tiffin Open Road 34PA with a water pump that keeps losing prime during winterization — about to buy a replacement but wondering if I'm throwing money at the wrong problem? I can get it back by quickly opening and closing one of the lowest drain valves, but then it just loses prime again after a while. This has happened on other RVs I've winterized too, but it's particularly stubborn on this Tiffin.

I'm suspecting it might be the inline check valve next to the pump or maybe the one behind the Truma hot water heater, but I'd love some guidance on proper diagnosis. What are the most common causes of prime loss during winterization, and what's the best way to troubleshoot and fix this? I want to make sure I'm covering all my bases for winter storage prep. …more

Read answer

Engine Medium 2-6 hours 289 👍 1

Onan 5500 Generator Problems: Complete Repair Guide 2024

Spent three hours testing my 2014 Hurricane's Onan 5500 gen getting 11.8 volts output when every manual says it should be 12+ volts! Here's the weird part - when I disconnect the remote harness, the generator fires right up and purrs like a kitten. But the second I plug that remote connection back in, boom - both the remote start light AND the generator start light come on, and then... nothing. Won't start at all.

The really bizarre symptom is this chattering from the fuel pump when the remote is connected. I can literally feel the fuel line jumping around when I put my hand on it. It's like the pump is having some kind of seizure or something!

I'm guessing this has to be some kind of electrical issue between the control board and the remote system, but I've never seen anything quite like this before. Anyone dealt with this specific combo of symptoms on an Onan 5500? Really hoping there's a known fix because pulling this thing out of the RV again would be a major pain! …more

Read answer

Exterior Hard 2-8 hours for temporary fix, 1-5 days for permanen 213 👍 1

RV Sidewall Blistering & Delamination Repair Guide 2024

According to three different RV shops, fixing my bubbling sidewall delamination will cost thousands, but I'm wondering if tackling this DIY repair myself is actually feasible. My 2004 Itasca Sunova has decided to sprout some lovely blisters on the right sidewall - two beauties that are about 12-14 inches long and 3-4 inches wide, running vertically right behind the awning arm. Perfect timing since we're currently on the road living our best RV life!

I'm pretty sure water snuck in somewhere (probably from the roof rail or that shower skylight we never use), and now my RV looks like it's got chicken pox. Since we can't exactly pull into the nearest RV surgeon's office, I need to know: what can I do right now to stop this from getting worse, and what's involved in actually fixing this mess properly? I'm hoping there's some kind of emergency containment plan that doesn't involve duct tape and prayers! …more

Read answer

Product Ranking 8 compared

Best RV Propane Accessories

4.5 (11,200 reviews)

Engine Easy N/A 162 👍 0

Ford V10 Triton Engine Maintenance Guide: EGR Delete vs Regular Service Tips

Spent years doing regular EGR maintenance on my old gas motorhome without issues — but this 2007 Fleetwood 31' Tioga with Ford V10 Triton has me second-guessing everything. I keep reading conflicting information about EGR delete procedures on V10 engines, and I'm worried I might make things worse if I mess with it.

Is the EGR delete modification actually necessary on this 2007 3-valve V10, or am I overthinking this? I don't want to void any warranties or create problems that weren't there before. Would I be better off just sticking to regular maintenance instead of modifications? I'm looking for reassurance that I'm taking the right approach to keep this engine running reliably for years to come. …more

Read answer

Exterior Medium 30-60 min 155 👍 1

Kwikee RV Steps Not Working? Complete Troubleshooting Guide (2024)

Apparently we're leaving for a three-week cross-country trip next Monday and my Kwikee electric RV steps are still having intermittent retraction issues even after replacing both the gear box and motor. My steps are exhibiting intermittent retraction issues - they extend normally but require manual assistance to retract fully, stopping approximately a quarter inch through the cycle without intervention. I've already installed a new gear box and motor, yet the problem persists.

What systematic diagnostic approach should I follow to identify the root cause? I need to understand the complete troubleshooting sequence for motor functionality, electrical switch operation, and mechanical linkage components. Are there specific voltage measurements, resistance checks, or mechanical adjustments that should be performed to isolate whether this is an electrical or mechanical failure?

Thanks,
Pete …more

Read answer

Engine Easy 1-2 hours inspection 146 👍 0

Ford E450 V10 Reliability: Expected Mileage and Longevity Guide for RV Owners

Nobody prepared me for staring at this 2018 Jayco Greyhawk 29MVP with Ford E450 chassis showing 54,000 miles and wondering if I'm looking at a money pit. The unit appears well-maintained with quality features including auto-leveling, fiberglass roof and nose, plus J-ride suspension. However, the odometer shows 54,000 miles, which exceeds my initial target range.

I need to assess whether this mileage represents significant wear on the E450/V10 drivetrain combination. What is the typical service life expectation for these engines when properly maintained? At what point should mileage become a primary concern versus overall mechanical condition? …more

Read answer

General Hard 45-60 min 129 👍 0

How to Remove Firefly RV Control Panel: Complete DIY Guide (2024)

Our 2019 Fleetwood Discovery LXE has a malfunctioning Firefly multiplex control panel that needs to be completely removed. I've been putting this off for months because I keep hearing horror stories about people cracking their panels or damaging the surrounding woodwork during removal.

I need to access the back of the unit for some electrical work, but I'm honestly terrified of breaking something expensive. The panel seems to be mounted flush with no obvious screws or clips visible from the front. I've searched everywhere but can't find a complete walkthrough that covers the preparation, actual removal process, and how to get everything back together properly.

Can someone please provide a detailed DIY guide that covers all the steps? I'm willing to take my time and do this right - I just need to know the proper technique so I don't end up with a broken control panel or damaged wall. …more

Read answer

Engine Easy N/A 129 👍 0

Ford E-350 vs E-450 Chassis: RV Fuel Economy, Power & Weight Capacity

Last weekend I felt this awful engine strain and heard sluggish acceleration sounds while test-driving a 2017 Phoenix Cruiser #2351 with its E-350 chassis and V10 engine. I'll be doing extensive western touring through mountain and plains regions, which means substantial mountain grades and wind challenges. I'm comfortable driving slowly and want to understand two key things: 1) Will this E-350 chassis handle mountain grades without major issues, and 2) What's the real-world fuel consumption like? I plan to do an initial inspection this weekend, followed by a third-party mechanical review. I'm not overly concerned about fuel economy but want to understand the actual performance limitations. I'd appreciate insights from owners who have experience with similar touring conditions on an E-350 chassis. …more

Read answer

Ac Refrigeration Medium 2-3 hours 128 👍 0

Dometic RV AC Not Cooling? 5 Common Fixes for Air Conditioner Troubleshooting Guide

Walked out to my RV this morning trying to decide between calling a repair tech or troubleshooting my Dometic Brisk Air rooftop AC myself since it's showing weird operational issues. The compressor engages and fan motor operates normally, but the unit fails to produce cold air output. Temperature differential across the evaporator coil is minimal.

Unit functioned properly through previous cooling season with no apparent issues. Current symptoms include normal airflow volume but inadequate cooling capacity. What systematic diagnostic procedure should I follow to identify the root cause? Looking for a methodical troubleshooting sequence that addresses the most probable failure points in order of likelihood. …more

Read answer

Electrical Easy 30 minutes 119 👍 0

RV 12V Lights Dimming: Complete Troubleshooting Guide

My neighbor insists it's the converter, the RV dealer swears it's bad wiring, and every YouTube video claims it's a dying battery—but my 12V ceiling lights keep dimming! One evening they're blazing bright like a casino, the next morning they're giving off all the enthusiasm of a sleepy firefly.

I've already checked my batteries, and they seem to be charging fine and in good shape. The converter is still humming and its fan is running normally. I'm pretty sure this isn't some fancy mood lighting feature I accidentally activated (though knowing my tech skills, anything's possible). The dimming seems totally random - sometimes they're fine, sometimes they look like they're on their last legs.

I've got a basic multimeter that I pretend to know how to use, but I'm not sure where to even start poking around. As a bonus weirdness, some of my under-cabinet light switches and the wall switch for the ceiling lights are getting really hot. Anyone know what typically causes this whole disco light show situation with 12V lighting systems? …more

Read answer

Propane Medium 45 minutes 118 👍 0

RV Gas Detector Beeps Every Minute at Night - How to Fix

Before my wife mentioned it, I had no idea our RV gas detector was beeping every single minute from 7PM to 7AM—now it's driving me absolutely crazy. It only does this during nighttime hours - never during the day. I'm plugged into shore power with 4 batteries (2 coach, 2 engine). What would cause this specific timing pattern? Is it actually detecting gas or is something else going on with the detector itself? …more

Read answer

Product Ranking 8 compared

Best RV Air Conditioners

4.4 (8,100 reviews)

General Easy 15-30 min 118 👍 0

RV Windshield Washer System: Complete Maintenance Guide & Troubleshooting Tips

Somewhere between following three different YouTube tutorials, I managed to turn my RV's windshield washer repair into a sprinkler system that hits everything except the actual windshield. The specific issue I'm experiencing is fluid running back into the reservoir after each use, which means washer fluid isn't effectively hitting bugs before they dry and smear. I actually found a clever solution - using an aquarium air pump check valve from PetSmart for just $3.00. Sometimes it's these little fixes that make a big difference.

Sometimes the washer sprays like a garden sprinkler gone rogue, other times it dribbles like a leaky faucet. The fluid seems to have a mind of its own - either freezing up in cold weather or not hitting the windshield where it's supposed to.

I'm dealing with nozzles that spray everywhere except where the bugs are, a reservoir that I can never seem to locate when it's empty, and wipers that just smear everything around instead of actually cleaning. Could someone help me troubleshoot and confirm if my check valve solution might help? …more

Read answer

Slideouts Medium 2-3 hours 115 👍 0

RV Slide Out Moving Slowly? Complete Lubrication & Repair Guide [2024]

I tried everything I could think of, but after all that heavy rain last week, my slide out went from smooth operation to moving like molasses. It sounds like it's really struggling and straining, making these awful grinding noises that have me worried I'm going to break something expensive.

I've been reading that lubrication might be the answer, but I honestly don't know where to start. Should I be looking at the motor mechanism? The tracks? I've heard about hydraulic fluid but I'm not sure if my system is hydraulic or electric. I really need someone to walk me through what needs lubrication and what else I should check before this thing stops working completely!

Could you help me troubleshoot? Details that might help: Can you tell me the specific model of my RV and the type of slide out system it uses? …more

Read answer

Exterior Medium 45 minutes 104 👍 0

RV Awning Won't Extend or Retract: Complete Troubleshooting & Repair Guide

This power awning manual says hold the extend button for 3 seconds, but mine's completely dead and won't budge no matter how long I hold it. When I hit the extend button, it moves out maybe 6-8 inches and then immediately retracts on its own. I have to turn the power switch off and back on each time to get even that little bit of movement.

I'm hesitant to keep forcing it since I don't want to burn out the motor or make whatever's wrong even worse. Could this be an electrical issue with low voltage, or maybe the tracks are too dirty? I've also heard about limit switches causing problems but I'm not sure how to check those safely.

What are the most common causes when an awning does this short extend-then-retract cycle? I want to start with the safest troubleshooting steps before calling a repair shop. …more

Read answer

Slideouts Medium 1-2 hours 102 👍 0

Fleetwood Bounder Slide Out Reset: Fix Lost Stop Points & Controller Issues

Slide out lost its stop points during a power surge at the campground and now it extends way too far and retracts too deep. Fleetwood Bounder forum says I need to reset the controller but the process involves running the slide to its limits and I'm afraid of damaging the mechanism. …more

Read answer

Loading more Q&A...

You've seen all 86 Q&A articles!