Results for "intermittent"

Plumbing Medium 2-4 hours 446 👍 9

RV Water Pump Losing Prime: Troubleshooting & Winterization

Got a 2022 Tiffin Open Road 34PA with a water pump that keeps losing prime during winterization — about to buy a replacement but wondering if I'm throwing money at the wrong problem? I can get it back by quickly opening and closing one of the lowest drain valves, but then it just loses prime again after a while. This has happened on other RVs I've winterized too, but it's particularly stubborn on this Tiffin.

I'm suspecting it might be the inline check valve next to the pump or maybe the one behind the Truma hot water heater, but I'd love some guidance on proper diagnosis. What are the most common causes of prime loss during winterization, and what's the best way to troubleshoot and fix this? I want to make sure I'm covering all my bases for winter storage prep. …more

Read answer

Engine Medium 2-6 hours 289 👍 1

Onan 5500 Generator Problems: Complete Repair Guide 2024

Spent three hours testing my 2014 Hurricane's Onan 5500 gen getting 11.8 volts output when every manual says it should be 12+ volts! Here's the weird part - when I disconnect the remote harness, the generator fires right up and purrs like a kitten. But the second I plug that remote connection back in, boom - both the remote start light AND the generator start light come on, and then... nothing. Won't start at all.

The really bizarre symptom is this chattering from the fuel pump when the remote is connected. I can literally feel the fuel line jumping around when I put my hand on it. It's like the pump is having some kind of seizure or something!

I'm guessing this has to be some kind of electrical issue between the control board and the remote system, but I've never seen anything quite like this before. Anyone dealt with this specific combo of symptoms on an Onan 5500? Really hoping there's a known fix because pulling this thing out of the RV again would be a major pain! …more

Read answer

Electrical Medium 2-6 hours 230 👍 1

ECM Low Battery Warning RV: Complete Diagnosis & Fix Guide

During a family trip, my 2005 Fleetwood Discovery 39S threw code 168-1 for low ECM battery voltage and went into full shutdown mode—is this dangerous with kids onboard? Engine cut out, transmission selector went dark, ABS warnings everywhere - the whole nine yards. Scared the heck out of me when it happened on the interstate!

I'm seeing this seems to be a thing with these diesel pushers, but I'm drowning in conflicting info online. Some say it's the chassis battery, others blame alternator issues, and I've even seen posts about ECM power supply problems on the Caterpillar engines. What's the actual step-by-step process to track this down? And more importantly, how do I fix it so it doesn't leave me stranded again? Really need a complete walkthrough of what causes this code and the proper repair approach. …more

Read answer

Product Ranking 8 compared

Best RV Refrigerators

4.3 (9,200 reviews)

Engine Easy N/A 164 👍 0

Ford V10 Triton Engine Maintenance Guide: EGR Delete vs Regular Service Tips

Spent years doing regular EGR maintenance on my old gas motorhome without issues — but this 2007 Fleetwood 31' Tioga with Ford V10 Triton has me second-guessing everything. I keep reading conflicting information about EGR delete procedures on V10 engines, and I'm worried I might make things worse if I mess with it.

Is the EGR delete modification actually necessary on this 2007 3-valve V10, or am I overthinking this? I don't want to void any warranties or create problems that weren't there before. Would I be better off just sticking to regular maintenance instead of modifications? I'm looking for reassurance that I'm taking the right approach to keep this engine running reliably for years to come. …more

Read answer

Plumbing Medium 1-2 hours 155 👍 0

RV Grey Water Tank Clogged? 7 Proven Solutions to Clear Blockages Fast

Found out my RV service tech wants $800+ to replace the entire grey water system on my 2007 RV for an intermittent blockage that seems fixable. It doesn't seem to matter if we're level or not - it's completely random.

I've tried using a high suction shop vac and even attempted snaking it, but I'm nervous about forcing things and making the problem worse. I suspect it might be a manufacturing plug that fell into the tank, but I'm not sure. I found one solution with a reverse flush valve that seems to work temporarily, but I'm concerned about the underlying cause.

What are the safest and most proven methods to diagnose and fix these random grey water blockages? I don't want to damage the tank or create bigger problems, but this unpredictable draining is driving me crazy. Are there specific cleaning products or techniques that actually work without risking harm to the system? …more

Read answer

Electrical Medium 1-2 hours research and setup 140 👍 1

Safari Motorcoach LPG Tank Refill for Stationary RV Setup

Between my toolbox and the YouTube tutorials I've watched, I'm ready to tackle the LPG tank refill setup on my permanently parked 2000 Safari Sahar 32-footer. Since my wife and I live in California and visit several times per year to help her aging parents, the RV serves as a stationary dwelling with full hookups for shore power and water.

The challenge is that the coach won't be moved to drive to propane filling stations, so I'm exploring on-site refill options. I'm specifically interested in potentially transferring propane from a standard 40lb grill tank to our RV's fixed tank. I want to understand what type of fitting our Safari Sahar has and what safety considerations or special equipment might be required for liquid-to-liquid propane transfer.

Since we'll need heating during colder months and my wife will sometimes be at the RV without me, I want to ensure a reliable and safe refill method. What are my options for refilling the LPG tank without moving the motorcoach? …more

Read answer

Electrical Medium 30-90 min 140 👍 0

No 12 Volt Power in RV: Complete Troubleshooting Guide

Turned the key and nothing works on 12 volt — no lights, no water pump, no slides. Batteries show 12.6 volts on the multimeter so they're fully charged. House batteries seem fine but zero power is getting to any of the 12V circuits inside the coach. …more

Read answer

General Easy 20 min research 137 👍 0

How to Find Reliable RV Repair Shops: Expert Tips & Red Flags to Watch Out For

About every summer my 2004 Adventurer runs like a dream until temps hit 85°F, then it breaks down constantly and no shop can figure out why. The main slide out has been acting up with the HWH hydraulic system, and I honestly don't know enough to fix it myself.

I'm worried about getting taken advantage of since I don't really know what questions to ask or what warning signs to watch out for. I've heard horror stories about people paying huge bills for shoddy work. What's the best way to research and find a reliable shop? Are there specific things I should ask them before I commit to having work done?

Any guidance would be really appreciated - I just want to make sure I'm being smart about this and not walking into a bad situation. …more

Read answer

Electrical Medium 30 min read 131 👍 0

RV DC Electrical System: Expert Guide to 12 Volt Systems

Opened my RV this morning to find the 12V system going haywire — lights dimming randomly, fans slowing down, and the inverter shutting off despite full batteries.

Specifically, I need to understand the fundamentals of RV batteries - different types, proper sizing, charging requirements, and maintenance. I'm also confused about DC wiring best practices, what gauge wire to use for different applications, how to properly route and protect circuits, and where fuses and breakers should go. Voltage monitoring is another area where I'm lost - I see all these battery monitors and don't know what I actually need or how to interpret the readings.

I'm also planning some system upgrades down the road like adding solar or upgrading to lithium batteries, so I'd love to understand how all these components work together and what I need to consider for future modifications. Is there a comprehensive resource that covers all aspects of RV DC electrical systems from batteries and wiring through monitoring and upgrades? …more

Read answer

Ac Refrigeration Medium 2-3 hours for diagnosis, professional repair likely needed 122 👍 0

Coleman Mach AC Fuse Blows With Battery On - Rockwood Fix

Found out the hard way that the previous owner of my 2019 Rockwood Minilite 2509s left me with a Coleman Mach AC that blows fuses instantly when I flip on the battery. The AC fuse blows instantly when I turn on the battery disconnect, before the AC is even activated. The fuse literally blows before it's completely seated in the panel.

This began two weeks ago without warning - the system had been functioning normally prior to this. Initial fuse replacement provided temporary operation, but the problem returned on the next trip with the fuse already blown upon arrival.

Given the immediate fuse failure with just battery power connected, what type of electrical fault would cause this symptom pattern in a Coleman Mach unit, and what's the most likely location of the problem in the AC circuit? …more

Read answer

Solar Batteries Medium 1-2 hours 120 👍 0

Xantrex Freedom X 1200 Inverter Low Battery Warning: Critical 11.2V Fix Guide

Walked into my new RV and discovered the previous owner left the Xantrex Freedom X 1200 inverter constantly throwing critical 11.2V low battery warnings. My Xantrex Freedom X 1200 inverter is displaying warning indicators on the panel, and I'm seeing some concerning voltage readings that have me worried about potential damage to my electrical system.

Here's the complete situation: My house battery is reading 11.2 volts, while the chassis battery shows 13.1 volts. The inverter panel is lit up with what I assume are low voltage warnings. I've been noticing the interior lights dimming significantly, especially when trying to run any appliances through the inverter. To make matters worse, it's currently overcast and getting dark, so my solar panels aren't generating any meaningful charge to help recover the battery.

I'm particularly concerned because I know lead-acid batteries can be permanently damaged if they're discharged too deeply. The voltage reading of 11.2V seems critically low to me, but I want to understand exactly how urgent this situation is and what my immediate next steps should be. Should I be looking at shore power connection, generator use, or is there something wrong with my charging system that caused this in the first place? I need to know both the immediate fix and what might have caused this failure. …more

Read answer

Product Ranking 8 compared

Best RV Propane Accessories

4.5 (11,200 reviews)

Electrical Easy 30 minutes 120 👍 0

RV 12V Lights Dimming: Complete Troubleshooting Guide

My neighbor insists it's the converter, the RV dealer swears it's bad wiring, and every YouTube video claims it's a dying battery—but my 12V ceiling lights keep dimming! One evening they're blazing bright like a casino, the next morning they're giving off all the enthusiasm of a sleepy firefly.

I've already checked my batteries, and they seem to be charging fine and in good shape. The converter is still humming and its fan is running normally. I'm pretty sure this isn't some fancy mood lighting feature I accidentally activated (though knowing my tech skills, anything's possible). The dimming seems totally random - sometimes they're fine, sometimes they look like they're on their last legs.

I've got a basic multimeter that I pretend to know how to use, but I'm not sure where to even start poking around. As a bonus weirdness, some of my under-cabinet light switches and the wall switch for the ceiling lights are getting really hot. Anyone know what typically causes this whole disco light show situation with 12V lighting systems? …more

Read answer

Electrical Medium 45 minutes 113 👍 0

RV Shore Power Not Working: Complete Troubleshooting Guide

Plugged into shore power at the campground last night and absolutely nothing happened — no lights, no AC, nothing. Breaker on the pedestal looks fine and my neighbor's rig is running perfectly on the same circuit. Starting to wonder if something fried inside the transfer switch. …more

Read answer

Engine Medium 2-4 hours (including dealer visit) 112 👍 0

Ford F53 Motorhome Key Programming Guide: Security Features & Programming Tips

Apparently my 2008 Ford F53 motorhome is 16 years old and starting to have key programming issues — should I attempt DIY programming or call a locksmith? I just dropped $176 on two new transponder keys for my 2024 Windsport 34R (2022 F53 chassis) because I only had one set and didn't want to get locked out in the middle of nowhere wearing my pajamas and fuzzy slippers (again).

The Ford dealer quoted me another $140-170 to program these fancy chip keys, insisting I'd need to haul my 35-foot house-on-wheels down there for the programming. But the parts guy said "try them first" - and wouldn't you know it, both keys fired right up without any programming!

So what's the deal here? Are these unprogrammed transponder keys going to mysteriously stop working next Tuesday? Did I just dodge a bullet, or am I missing out on some important anti-theft features that actually matter? I'm feeling pretty smug about saving that programming fee, but also slightly paranoid that my motorhome might strand me at the worst possible moment! …more

Read answer

Appliances Medium varies by part 110 👍 0

Furrion FMCM15-SS Microwave Parts & Repair Guide - Complete Replacement Guide

Called three RV repair shops about my dead Furrion FMCM15-SS microwave and they all want $200+ — any DIY fixes for under $50? 🤦‍♂️

I'm trying to track down replacement parts but I'm having about as much luck as finding a level campsite during peak season. Does anyone know the best places to source parts for this model? I'm particularly wondering about common failure items like door latches and turntable motors - seems like these microwaves have their favorite ways to quit on us! …more

Read answer

Loading more Q&A...

You've seen all 123 Q&A articles!