Results for "electrical installation"

Engine Medium 2-6 hours 290 👍 1

Onan 5500 Generator Problems: Complete Repair Guide 2024

Spent three hours testing my 2014 Hurricane's Onan 5500 gen getting 11.8 volts output when every manual says it should be 12+ volts! Here's the weird part - when I disconnect the remote harness, the generator fires right up and purrs like a kitten. But the second I plug that remote connection back in, boom - both the remote start light AND the generator start light come on, and then... nothing. Won't start at all.

The really bizarre symptom is this chattering from the fuel pump when the remote is connected. I can literally feel the fuel line jumping around when I put my hand on it. It's like the pump is having some kind of seizure or something!

I'm guessing this has to be some kind of electrical issue between the control board and the remote system, but I've never seen anything quite like this before. Anyone dealt with this specific combo of symptoms on an Onan 5500? Really hoping there's a known fix because pulling this thing out of the RV again would be a major pain! …more

Read answer

Solar Batteries Medium 4-6 hours for inverter replacement 250 👍 1

RV Inverter Guide: Modified vs Pure Sine Wave - Safe Power

My multimeter's out and I'm ready to tackle this RV electrical mess myself — pretty sure the inverter's the culprit but need to know where to start. I have a 2000 Winnebago Ultimate Advantage with four deep cycle house batteries and recently installed a Xantrex 758 inverter to replace my old Freedom 15 unit. The first time I tried using the inverter power while unplugged from shore power, something very strange happened - a hair dryer in the bathroom started running by itself and wouldn't shut off when I tried the switch. I had to unplug it, and the handle was warm. The hair dryer appears to be ruined now.

When I bought the Xantrex 758, I paid around $725 for what I thought was a good unit, but I'm now learning there's a difference between modified sine wave and pure sine wave inverters. I wasn't aware of this distinction when I made the purchase, and it turns out the 758 is a modified sine wave unit. I've since heard that modern electronics, especially things like residential refrigerators, computers, and sensitive electronic components, can be damaged by modified sine wave power.

I'm really concerned about potentially damaging my new residential refrigerator, stereo system, and computer equipment. Should I be worried about using this modified sine wave inverter with modern RV electronics? Is the hair dryer incident a sign that I need to upgrade to a pure sine wave unit, or are there other factors that could have caused this problem? I'm trying to understand if my current setup is putting my expensive electronics at risk. …more

Read answer

General Medium 1-2 days for initial setup 220 👍 1

RV Storage on Gravel: Preventing Weed and Moisture Issues

Nobody warned me that buying a house with RV storage meant inheriting the previous owner's 13-year-old weedy, muddy gravel disaster. While considering this location's storage options, I want to mitigate potential issues with weed growth and moisture retention under the RV.

I'm seeking advice on effective strategies for storing on a gravel surface that shows significant weed penetration and moisture retention. Initial ideas include pre-treatment herbicide application and installing a protective barrier, but I want input from experienced RV owners.

My primary concerns are preventing undercarriage damage and managing moisture/vegetation growth. I plan to spray weed killer beforehand and potentially lay down a weed barrier, pending facility approval. What techniques or materials do you recommend to protect my RV during storage? …more

Read answer

Product Ranking 8 compared

Best RV Generators

4.6 (18,900 reviews)

Engine Medium 2-4 hours 216 👍 0

Generac 7.5kW Diesel Generator Repair Guide - RV Troubleshooting

Planning to ignore the weird noises from our Generac 7.5kW diesel generator backfired when my wife pointed out I definitely made things worse during my repair attempt. I have a 2007 Monaco with a Generac 7.5kW diesel generator, and yesterday when I tried starting it, the battery was really weak. I probably held the starter button too long - maybe 15 seconds or so - because it was cranking so slowly and I kept hoping it would catch.

Now when I try to start it, I just get a single click and nothing happens. I'm worried I damaged something by cranking it so long with that weak battery. Should I be looking at the starter solenoid or starter motor? Is there anything I can check myself before I have to take it to a repair shop? I'd really appreciate any guidance on troubleshooting this. …more

Read answer

Solar Batteries Medium 2-4 hours 201 👍 0

RC7-GS Inverter AGM Battery Settings: Complete Setup Guide

Replaced my 105Ah AGM battery and now my RC7-GS inverter charger is completely rejecting it like this capacity doesn't exist in its programming.

The charging settings only go from 125Ah up to 1000Ah, with an 'auto' option that supposedly 'learns' my battery but resets every time the low voltage cutoff trips (which feels like cheating, honestly). I'm worried about undercharging or cooking my expensive new AGMs if I pick the wrong setting.

Oh, and while we're talking about things that don't work as advertised - the generator auto-start feature might as well be a myth. Can't even manually start the generator from the RC7 panel. At this point I'm wondering if I should have just stuck with my old setup that actually worked! Anyone know what I'm doing wrong here? …more

Read answer

Engine Hard 4-6 hours 171 👍 0

Ford F53 7.5L RV Won't Start: Fuel Pump Relay Voltage Drop Fix

Woke up to my 1996 Ford F53 7.5L motorhome eating through my patience and wallet with this no-start issue that keeps coming back. It cranks strong but absolutely will not start, and I've been chasing this problem for weeks now. The engine ran fine for about 3-4 minutes one day, then just died and hasn't started since.

I've already done quite a bit of diagnostic work:
- Replaced PCM and distributor
- Fuel pump works when powered directly
- Battery is fully charged
- Checked fuses and relays
- PCM relay voltage drops from 12.2V to 9.3V with key on
- Fuel pump relay only shows 3.3V at pin 86 (should be 12V)
- Inertia switch tested at 1.7V at connector
- ANL 178 fusible link fluctuates between 0.3-0.6V

The engine will only start with starter fluid when the SPOUT is removed. I'm getting only 5.5V at the fuel pump connector.

Has anyone dealt with this specific issue on an F53 chassis? I really need to get this RV back on the road and I'm running out of ideas! …more

Read answer

Exterior Medium 30-60 min 155 👍 1

Kwikee RV Steps Not Working? Complete Troubleshooting Guide (2024)

Apparently we're leaving for a three-week cross-country trip next Monday and my Kwikee electric RV steps are still having intermittent retraction issues even after replacing both the gear box and motor. My steps are exhibiting intermittent retraction issues - they extend normally but require manual assistance to retract fully, stopping approximately a quarter inch through the cycle without intervention. I've already installed a new gear box and motor, yet the problem persists.

What systematic diagnostic approach should I follow to identify the root cause? I need to understand the complete troubleshooting sequence for motor functionality, electrical switch operation, and mechanical linkage components. Are there specific voltage measurements, resistance checks, or mechanical adjustments that should be performed to isolate whether this is an electrical or mechanical failure?

Thanks,
Pete …more

Read answer

Propane Hard 6-8 hours 149 👍 0

Atwood GC10A-4E Replacement: Best Tankless RV Water Heater Upgrades 20

Halfway through draining my Atwood GC10A-4E's supposed 10-gallon capacity, the water's already running cold but my gauge shows I've only pulled maybe 6 gallons. Are there any dual-fuel tankless units that would work as a replacement? I know there's no plug-and-play option, but what are the best tankless water heaters that offer both gas and electric operation for RVs? …more

Read answer

General Hard 45-60 min 131 👍 0

How to Remove Firefly RV Control Panel: Complete DIY Guide (2024)

Our 2019 Fleetwood Discovery LXE has a malfunctioning Firefly multiplex control panel that needs to be completely removed. I've been putting this off for months because I keep hearing horror stories about people cracking their panels or damaging the surrounding woodwork during removal.

I need to access the back of the unit for some electrical work, but I'm honestly terrified of breaking something expensive. The panel seems to be mounted flush with no obvious screws or clips visible from the front. I've searched everywhere but can't find a complete walkthrough that covers the preparation, actual removal process, and how to get everything back together properly.

Can someone please provide a detailed DIY guide that covers all the steps? I'm willing to take my time and do this right - I just need to know the proper technique so I don't end up with a broken control panel or damaged wall. …more

Read answer

Ac Refrigeration Medium 2-3 hours 128 👍 0

Dometic RV AC Not Cooling? 5 Common Fixes for Air Conditioner Troubleshooting Guide

Walked out to my RV this morning trying to decide between calling a repair tech or troubleshooting my Dometic Brisk Air rooftop AC myself since it's showing weird operational issues. The compressor engages and fan motor operates normally, but the unit fails to produce cold air output. Temperature differential across the evaporator coil is minimal.

Unit functioned properly through previous cooling season with no apparent issues. Current symptoms include normal airflow volume but inadequate cooling capacity. What systematic diagnostic procedure should I follow to identify the root cause? Looking for a methodical troubleshooting sequence that addresses the most probable failure points in order of likelihood. …more

Read answer

Solar Batteries Medium 2-4 hours 127 👍 0

How to Upgrade Progressive Dynamics Converter for Lithium RV Batteries Safely

Got a 15-year-old Progressive Dynamics converter that's starting to throw fault codes with my new lithium setup — worth upgrading or try making it work? I have a 2006 Lance 915 cabover that I recently upgraded with 2-200 watt Bouge solar panels and 2-100ah SOK lithium batteries.

The problem is I'm still running the original Progressive Dynamics converter charger that came with the RV, and I've learned it's not designed for lithium batteries. I'm worried about damaging my new battery investment.

What are my options for upgrading? I'm not sure if I need to replace the whole converter unit or if there's some kind of upgrade kit available. Any advice would be really appreciated since I don't want to mess this up! …more

Read answer

Product Ranking 8 compared

Best RV Sewer Hoses & Kits

4.6 (31,500 reviews)

Appliances Medium 3-4 hours 125 👍 0

Best RV Thermostatic Shower Mixing Valves 2024 - Installation Guide

According to my screaming every morning, there's this scalding burn followed by an icy shock sensation hitting my back in my RV shower. There's no middle ground - it's like my water heater has anger management issues.

I'm shopping for a thermostatic mixing valve to save myself from daily temperature shock therapy. I keep seeing mechanical models like the Symmons Temptrol and Phoenix PF213200, but honestly have no idea if they're any good. And don't get me started on those fancy digital ones like the Kohler DTV+ - they look amazing but I'm guessing they're about as RV-friendly as a pet elephant.

Anyone know which thermostatic valves actually work well in RVs without requiring me to rewire half my rig or sacrifice my firstborn to the plumbing gods? …more

Read answer

Ac Refrigeration Medium 2-3 hours for diagnosis, professional repair likely needed 122 👍 0

Coleman Mach AC Fuse Blows With Battery On - Rockwood Fix

Found out the hard way that the previous owner of my 2019 Rockwood Minilite 2509s left me with a Coleman Mach AC that blows fuses instantly when I flip on the battery. The AC fuse blows instantly when I turn on the battery disconnect, before the AC is even activated. The fuse literally blows before it's completely seated in the panel.

This began two weeks ago without warning - the system had been functioning normally prior to this. Initial fuse replacement provided temporary operation, but the problem returned on the next trip with the fuse already blown upon arrival.

Given the immediate fuse failure with just battery power connected, what type of electrical fault would cause this symptom pattern in a Coleman Mach unit, and what's the most likely location of the problem in the AC circuit? …more

Read answer

Electrical Easy 30 minutes 120 👍 0

RV 12V Lights Dimming: Complete Troubleshooting Guide

My neighbor insists it's the converter, the RV dealer swears it's bad wiring, and every YouTube video claims it's a dying battery—but my 12V ceiling lights keep dimming! One evening they're blazing bright like a casino, the next morning they're giving off all the enthusiasm of a sleepy firefly.

I've already checked my batteries, and they seem to be charging fine and in good shape. The converter is still humming and its fan is running normally. I'm pretty sure this isn't some fancy mood lighting feature I accidentally activated (though knowing my tech skills, anything's possible). The dimming seems totally random - sometimes they're fine, sometimes they look like they're on their last legs.

I've got a basic multimeter that I pretend to know how to use, but I'm not sure where to even start poking around. As a bonus weirdness, some of my under-cabinet light switches and the wall switch for the ceiling lights are getting really hot. Anyone know what typically causes this whole disco light show situation with 12V lighting systems? …more

Read answer

General Easy 15-30 min 119 👍 0

RV Windshield Washer System: Complete Maintenance Guide & Troubleshooting Tips

Somewhere between following three different YouTube tutorials, I managed to turn my RV's windshield washer repair into a sprinkler system that hits everything except the actual windshield. The specific issue I'm experiencing is fluid running back into the reservoir after each use, which means washer fluid isn't effectively hitting bugs before they dry and smear. I actually found a clever solution - using an aquarium air pump check valve from PetSmart for just $3.00. Sometimes it's these little fixes that make a big difference.

Sometimes the washer sprays like a garden sprinkler gone rogue, other times it dribbles like a leaky faucet. The fluid seems to have a mind of its own - either freezing up in cold weather or not hitting the windshield where it's supposed to.

I'm dealing with nozzles that spray everywhere except where the bugs are, a reservoir that I can never seem to locate when it's empty, and wipers that just smear everything around instead of actually cleaning. Could someone help me troubleshoot and confirm if my check valve solution might help? …more

Read answer

Loading more Q&A...

You've seen all 270 Q&A articles!