Results for "control board"

Ac Refrigeration Medium 2-3 hours 2,222 👍 0

Norcold 1210 Not Cooling: No Error Codes Troubleshooting Guide

During my morning RV check I spotted my Norcold 1210 completely dead with zero cooling that was running perfectly yesterday with no error codes. Unit appears to be operating normally with no error codes displayed, but it's not cooling properly. Interior temperature is staying above 50 degrees. Thermistor has been tested and checks out fine. What else should I look at? …more

Read answer

Appliances Hard Professional repair required 1,044 👍 0

Splendide WDC7100XC Drum Bearing Repair & Replacement Guide

Splendide combo washer-dryer started making a grinding noise during the spin cycle and now it vibrates so hard it walks across the floor. Pretty sure it's the drum bearings based on the sound. Debating between a $400 repair bill and just replacing the whole unit. …more

Read answer

Electrical Medium 2-4 hours 1,037 👍 0

RV Chassis Battery Draining & Dead Outlets - Troubleshooting

Finally followed the manual's advice to check the converter first when my outlets died, but my RV chassis battery keeps draining even though the converter tests perfectly. here and I'm at my wit's end with my 2018 Winnebago Vista. The chassis battery keeps going completely dead every few days, even when we're plugged into shore power at the campground. I've already replaced the battery twice thinking it was just old, checked all the obvious stuff like dome lights and radio, and even had the alternator tested - everything checks out fine.

What's really driving me crazy is that this just started happening about a month ago out of nowhere. We've been full-timing for three years without any major electrical issues. I'm wondering if there's some parasitic draw I'm missing or if the battery isolator could be acting up? Has anyone else dealt with this nightmare? I'm getting tired of jump-starting this thing every other day and my wife is about ready to sell the rig and get a travel trailer instead! …more

Read answer

Product Ranking 8 compared

Best RV Batteries

4.5 (15,400 reviews)

Engine Medium 2-6 hours 773 👍 1

Onan 5500 Generator Problems: Complete Repair Guide

Spent three hours testing my 2014 Hurricane's Onan 5500 gen getting 11.8 volts output when every manual says it should be 12+ volts! Here's the weird part - when I disconnect the remote harness, the generator fires right up and purrs like a kitten. But the second I plug that remote connection back in, boom - both the remote start light AND the generator start light come on, and then... nothing. Won't start at all.

The really bizarre symptom is this chattering from the fuel pump when the remote is connected. I can literally feel the fuel line jumping around when I put my hand on it. It's like the pump is having some kind of seizure or something!

I'm guessing this has to be some kind of electrical issue between the control board and the remote system, but I've never seen anything quite like this before. Anyone dealt with this specific combo of symptoms on an Onan 5500? Really hoping there's a known fix because pulling this thing out of the RV again would be a major pain! …more

Read answer

Plumbing Medium 1-2 hours 543 👍 0

Monaco Diplomat Rear Air Suspension Won't Dump Fully - Troubleshooting Guide

Last week my 2006 Monaco Diplomat's rear air bags started refusing to dump all the way down when I hit the air dump before leveling. The front dumps fine, but the back stays partially inflated.

I'm still pretty new to RV maintenance and not sure where to start troubleshooting this. Should I be hearing air escaping when I activate the dump? What are the most common causes when rear air bags won't dump completely? Any guidance on what to check would be really appreciated! …more

Read answer

Solar Batteries Medium 2-4 hours 376 👍 0

RC7-GS Inverter AGM Battery Settings: Complete Setup Guide

Replaced my 105Ah AGM battery and now my RC7-GS inverter charger is completely rejecting it like this capacity doesn't exist in its programming.

The charging settings only go from 125Ah up to 1000Ah, with an 'auto' option that supposedly 'learns' my battery but resets every time the low voltage cutoff trips (which feels like cheating, honestly). I'm worried about undercharging or cooking my expensive new AGMs if I pick the wrong setting.

Oh, and while we're talking about things that don't work as advertised - the generator auto-start feature might as well be a myth. Can't even manually start the generator from the RC7 panel. At this point I'm wondering if I should have just stuck with my old setup that actually worked! Anyone know what I'm doing wrong here? …more

Read answer

Propane Hard 2-4 hours 343 👍 0

How to Wire Girard Tankless Water Heater: Complete DSI Suburban Replacement Guide

Ripping out my old Suburban water heater to install a Girard tankless but the wiring is completely different — DSI ignition board, different voltage requirements, and the old thermostat wiring doesn't match up. Need a clear wiring diagram for this swap. …more

Read answer

Ac Refrigeration Medium 2-3 hours 326 👍 0

Dometic RV AC Not Cooling? 5 Common Fixes for Air Conditioner Troubleshooting Guide

Walked out to my RV this morning trying to decide between calling a repair tech or troubleshooting my Dometic Brisk Air rooftop AC myself since it's showing weird operational issues. The compressor engages and fan motor operates normally, but the unit fails to produce cold air output. Temperature differential across the evaporator coil is minimal.

Unit functioned properly through previous cooling season with no apparent issues. Current symptoms include normal airflow volume but inadequate cooling capacity. What systematic diagnostic procedure should I follow to identify the root cause? Looking for a methodical troubleshooting sequence that addresses the most probable failure points in order of likelihood. …more

Read answer

Ac Refrigeration Medium 2-3 hours 317 👍 0

Norcold RV Refrigerator Won't Stay On Propane - Complete Troubleshooting Guide

Called my buddy at midnight when my Norcold RV refrigerator quit staying lit on propane — need to figure this out before our food spoils by morning. and by dream, I mean my Norcold refrigerator has decided it's too good for propane! The thing fires up just fine on LP gas - I can hear it purring away like a happy cat. But then, like a fair-weather friend, it abandons me after an hour or two and shuts itself off.

I'm starting to feel personally rejected by my own appliances. The electric mode works perfectly fine, but when I'm boondocking, my generator and I aren't exactly best friends either. I've heard this could be a thermocouple issue, burner problems, or maybe the control board throwing a tantrum. How do I figure out which component is giving me the cold shoulder (pun intended)? Any diagnostic tips to help me troubleshoot this temperamental beast? …more

Read answer

Ac Refrigeration Easy 30 minutes 278 👍 0

RV AC Freezing Up? Fix Ice on Coils in 5 Steps

Turned on my RV's AC as a total newbie and watched it run perfectly for an hour before becoming a frozen disaster that won't cool. I can literally see ice building up on the coils, and then it's game over until everything thaws out.

This has happened a few times now and I'm getting tired of sitting in a hot RV waiting for the thing to defrost. What actually causes AC units to freeze up like this? And more importantly, how do I stop it from happening again? I'm guessing it's something simple I'm missing, but I'd rather fix it right than keep dealing with this cycle. …more

Read answer

Appliances Medium 2-4 hours 274 👍 0

RV Water Heater Not Hot Enough: Fix Lukewarm Water Issues

Looked forward to our two-week cross-country trip starting tomorrow until I discovered my RV water heater that used to produce scalding hot water now barely gets lukewarm. Both the electric and gas functions appear to be working - I can hear the gas igniting and see the electric indicator light - but the water temperature just won't get hot enough for a decent shower.

I've been dealing with this for weeks now and it's driving me crazy. The water gets warm, but nowhere near the hot temperatures I used to get. Is this a common problem with RV water heaters? What are the most likely culprits when you're getting lukewarm water instead of hot? I really need to figure out what's causing this and how to fix it before my next camping trip. …more

Read answer

Product Ranking 8 compared

Best RV Leveling Blocks & Jacks

4.6 (9,800 reviews)

Propane Medium 30-60 minutes 268 👍 1

Atwood AFMD35 Furnace Playing Peek-a-Boo - How to Clean Flame Sensor & Fix Short Cycling

Staring at my Atwood AFMD35 manual that claims it should stay running once lit, but mine keeps shutting off every few minutes like it's playing peek-a-boo. It fires up beautifully for about 5-10 seconds, gets my hopes up that I won't freeze tonight, then promptly shuts off like it's having second thoughts about this whole "heating the RV" thing.

I've ruled out the sail switch and high temp limit since it actually lights (small victories in RV life, right?). I'm pretty sure the flame sensor is the culprit here, but I've never cleaned one before. How do I clean this mysterious little part, and what's the best way to access it on this model? Because apparently my furnace thinks playing hard-to-get is charming! …more

Read answer

Propane Medium 1-2 hours 258 👍 0

Dometic RV Furnace Runs 10 Seconds Then Shuts Off - Complete Troubleshooting Guide

The YouTube tutorials I followed to fix my Dometic DFMD35111 furnace that runs 10 seconds then dies actually made it worse—now it won't even start! Every time I try to run it, the same thing happens - it fires up, runs for exactly 10 seconds, then just shuts off completely. This has been going on for weeks now and I'm getting desperate since the weather is getting colder.

I've been trying to troubleshoot this myself but honestly don't know where to start. I can hear the blower running and the unit seems to ignite initially, but then it just dies. Is this a common problem with these Dometic units? I'm really hoping this is something I can fix myself rather than having to call out an expensive repair tech.

What are the most likely culprits when a furnace runs for just 10 seconds then shuts down? I need to know what components to check first before I start taking things apart. …more

Read answer

Slideouts Medium 4-6 hours 253 👍 0

How to Replace Atwood Levelegs Control System with GAMA Electronics RF340-4PR Controller

Noticed my Tiffin Allegro Bay's Atwood Levelegs control pad has a completely blank display, won't respond to any commands, AND all the leveling jacks are totally dead. I'm looking at expensive repair options - around $400 for repair service or $3000+ for a complete Bigfoot replacement system.

I researched alternatives and found the GAMA Electronics RF340-4PR-ASL controller with HP4PR-ASL handheld pendant, which cost around $235 shipped. I customized the solution by 3D printing a switch panel with 4 DPST on/off switches and a momentary DPDT switch for jack control.

Is this type of aftermarket replacement reliable and compatible with existing Atwood jacks and wiring? I want something I can easily troubleshoot and maintain. …more

Read answer

Electrical Hard 2-4 hours 248 👍 0

RV Automatic Transfer Switch Dead: AC Power Fixes

Every time I flip the breaker, my 21-year-old coach's automatic transfer switch stays completely dead and I'm stuck with zero AC power. My Automated Engineering Corp ATS (model M10040A with M10041 display) is showing no AC on the LED readout even though shore power is definitely good.

I popped the cover off and confirmed power is getting TO the shore power terminals, but nothing's coming OUT to feed the AC system. Even manually pushed the contacts in and they stayed, but still no juice on the output side. Generator won't make it switch over either - it's like the whole transfer function is dead.

This thing has to be repairable right? Or am I looking at replacing the whole ATS unit? Really hoping someone has dealt with this before because losing AC in an RV is no joke! …more

Read answer

Loading more Q&A...

You've seen all 99 Q&A articles!