Results for "clearance light"

Engine Medium 2-6 hours 581 👍 1

Onan 5500 Generator Problems: Complete Repair Guide

Spent three hours testing my 2014 Hurricane's Onan 5500 gen getting 11.8 volts output when every manual says it should be 12+ volts! Here's the weird part - when I disconnect the remote harness, the generator fires right up and purrs like a kitten. But the second I plug that remote connection back in, boom - both the remote start light AND the generator start light come on, and then... nothing. Won't start at all.

The really bizarre symptom is this chattering from the fuel pump when the remote is connected. I can literally feel the fuel line jumping around when I put my hand on it. It's like the pump is having some kind of seizure or something!

I'm guessing this has to be some kind of electrical issue between the control board and the remote system, but I've never seen anything quite like this before. Anyone dealt with this specific combo of symptoms on an Onan 5500? Really hoping there's a known fix because pulling this thing out of the RV again would be a major pain! …more

Read answer

Exterior Hard 2-4 hours 191 👍 0

How to Fix RV Garage Door Delamination: Complete Repair Guide

Finally facing the inevitable with my 1994 Fleetwood Jamboree Rallye garage doors that are 30 years old and completely delaminating at the seams — repair or replace? The extruded aluminum frame corners that are supposed to be screwed together are failing because the screws keep breaking under stress. What started as minor separation has now progressed to the point where the structural integrity of the entire door system is compromised.

I've noticed that not only are the corner joints failing, but the door panels themselves seem to be separating from their backing material, and the weather seals around the perimeter are starting to pull away as well. The doors don't close properly anymore, leaving gaps that let in water and debris. I'm concerned about further damage to the garage area and contents if I don't address this comprehensively.

I need a complete repair approach that addresses the delamination issue, reinforces the structural components, and replaces the failing seals. Simply adding corner braces feels like a band-aid solution, and I'm worried about drilling out the broken screws without causing more damage to the aluminum frame. What's the proper way to tackle this type of comprehensive garage door repair on an older RV? …more

Read answer

Electrical Medium 3-4 hours 187 👍 0

RV Underbody Lighting Installation: Complete DIY Guide

I'm wondering if anyone else walked out this morning and spotted how embarrassingly bland their RV's underside looks compared to those slick LED setups online? My husband and I are pretty new to the RV world and I've been wanting to add some nice ambient lighting underneath our Class A motorhome. I think it would look really cool when we're set up at campsites in the evenings. I've seen other RVers with these gorgeous blue or white lights that make their rigs look so professional. We're definitely beginners when it comes to electrical work, so I'm hoping someone can walk me through what's involved. Is this something we can tackle ourselves or should we find a professional? Any product recommendations would be super helpful too. Thanks so much for your patience with us newbies! …more

Read answer

Product Ranking 8 compared

Best RV Surge Protectors

4.6 (14,200 reviews)

Appliances Medium 3-4 hours 181 👍 0

Dometic R31 Stove Review + Gas Pressure Test Guide

Walked into my RV this morning to find my Dometic R31 stove flames randomly dying again - probably a dumb question, but is this normal? I've been looking at the Dometic R31 as a potential replacement, but I want to make sure I'm making the right choice before spending the money.

What's really concerning me is this gas pressure test mentioned in the installation manual. It talks about connecting some kind of gauge to a test port on the regulator, but doesn't specify what type of gauge or what pressure readings I should expect. I'm pretty handy with basic repairs, but gas systems make me nervous and I want to do this safely. Has anyone actually done this test, and is the R31 reliable enough to justify the upgrade from my problematic Wedgewood? …more

Read answer

Engine Hard Professional repair required 175 👍 0

Ford F53 V8 Engine Tapping Noise: Complete TSB 25-2200 Repair Guide for RV Owners

Since I replaced the valve cover gaskets on my 2022 motorhome's Ford F53 V8 yesterday, I'm still hearing that annoying tapping noise — did I miss something? I've been noticing this tapping or ticking sound when the engine is idling, and sometimes it seems to run a bit rough. I'm worried I might have a serious problem.

I found a Ford Technical Service Bulletin (TSB 25-2200, NHTSA ID 11018524) that might be related to my issue. The bulletin mentions potential camshaft and valve tappet wear causing ticking noises, rough performance, and diagnostic trouble codes P0301-P0308. According to the bulletin, repairs might even include a new long block.

Can someone help me understand what this TSB covers exactly? Does it apply to my specific year model, and what kind of repairs might be needed?

Any guidance would be really appreciated - I'm still learning about all this mechanical stuff! …more

Read answer

Engine Easy 15 minutes 154 👍 0

Ford 7.3 Godzilla Oil Pressure: Normal PSI Readings

My Ford 7.3 Godzilla is throwing weird oil pressure PSI readings and the shop wants $800 to fix it – can I troubleshoot this myself first? I finally installed a Glowshift electronic oil pressure gauge because I kept hearing horror stories about these engines running dangerously low oil pressure.

Here's what I'm seeing: Cold starts jump over 60 PSI, then drop to 28-30 PSI at 1200 RPM. Once fully warmed up, I'm getting 18-20 PSI at 600 RPM idle, and the pressure stays around 28-30 PSI in my typical 2200 RPM cruising range. It doesn't climb above 30 PSI until I hit 3000 RPM, where it jumps to about 40 PSI.

I know Ford has had issues with some of these engines showing scary low numbers like 8 PSI at idle, so I'm grateful mine isn't that bad. But are these readings actually normal for the 7.3 Godzilla under normal operating conditions? I haven't done any loaded driving tests yet, but I'm trying to figure out if I should be concerned or if this is just how these engines run. …more

Read answer

Engine Easy Informational 153 👍 0

Best Floor Jacks and Jack Stands for Ford E-350 Class C Motorhome: Safety Guide

Despite having the proper jack and stands, is it still dangerous to work under my 2001 Ford E-350 Class C motorhome with grandkids constantly playing nearby? What are the correct tonnage specifications for floor jacks and jack stands when working on this chassis weight? Additionally, what are the designated lift points on the E-350 frame, and what safety protocols should be followed to ensure stable vehicle support during maintenance operations? …more

Read answer

Electrical Hard Professional installation 150 👍 0

48V RV Electrical Systems: Complete Guide to Modern RV Power Upgrades and Efficiency

Tried upgrading my RV's electrical system but I'm standing in the supply store staring at 12V versus 48V components with zero clue what I actually need. The Bluetti RV5 caught my eye as an all-in-one solution that might make the jump easier.

But honestly, I'm still on the fence. What are the real benefits of going 48V? Is it actually that much better than sticking with 12V lithium? And are there any gotchas I should know about, especially with solar integration and getting everything certified for RV use? …more

Read answer

General Medium N/A - shopping 149 👍 0

Best RV GPS Systems with Integrated Dashcam and Backup Camera Display for Safe Travel

Halfway through backing out of my campsite this morning I spotted my dashboard cluttered with three separate screens for GPS, dashcam, and backup camera.

I've been looking around but I'm not sure if fully integrated systems like this actually exist, or if I should be thinking about this differently. Would love some guidance from more experienced folks - are there good options out there, or am I better off going a different route? Thanks for any help! …more

Read answer

Engine Easy 15 min visual, 1 hour full 149 👍 0

Ford F53 Motorhome Brake Inspection: Complete Guide to Checking Rotors and Pads

Turned onto that steep mountain grade last week and heard grinding from my 2014 F53 chassis, but I can't figure out how to properly inspect the brake pads and rotors. I've been crawling around under there, contorting myself into every possible position, but I just can't get a good view of the brake components through the wheel openings.

Is there a specific technique or approach that actually works for getting a proper look at the pad thickness and rotor condition? I really want to stay on top of brake maintenance, but the limited visibility is making this nearly impossible. Should I be using special tools, or is there a better method I'm missing? …more

Read answer

Ac Refrigeration Easy 30 minutes 147 👍 0

RV Whirlpool Fridge Cycling Every 30 Minutes: Normal?

Looked everywhere for answers on my Whirlpool residential refrigerator cycling every 30 minutes—my neighbor says it's normal, RV dealer says it's broken, YouTube says something else entirely. The ambient temperature here is around 65°F, and I have both the fridge and freezer set to the 3rd snowflake setting.

I haven't timed it exactly with a stopwatch, but I keep noticing it kicking on again after what feels like a short time. I'm concerned this frequent cycling might be a sign of a problem or could lead to premature failure. I try to keep the vents clean when I can access them. Should I be worried about this 30-minute cycle pattern, or is this within normal range for an RV refrigerator in these conditions? …more

Read answer

Product Ranking 8 compared

Best RV Awnings & Accessories

4.5 (7,600 reviews)

Ac Refrigeration Hard 4-8 hours 143 👍 0

Dometic RV Fridge Replacement: Residential vs RV-Specific Options Guide for Smart RVers

Replaced my old Dometic RV fridge but now I'm second-guessing whether I should have gone with a residential unit instead of another 12 cu. ft. residential unit - looking at Frigidaire or Whirlpool models. But I keep seeing terrible reviews for small residential fridges in RVs.

What causes these issues with residential fridges in RV applications? Are there better alternatives that give me residential-style features without the problems? Need to know about power requirements and installation considerations too. …more

Read answer

Ac Refrigeration Easy 30 minutes 141 👍 0

RV Refrigerator Door Latch Replacement Options

According to Murphy's Law, our RV's refrigerator door latch completely gave out just days before our big family reunion trip this weekend! The plastic latch on my residential Whirlpool refrigerator door has given up the ghost, and now I'm living in constant fear of opening the door to find my condiments have taken a scenic tour of the RV floor.

I know this has to be a rite of passage for pretty much every RV owner out there. What are the best aftermarket options to replace these flimsy factory latches? I've seen magnetic catches mentioned, and Camco seems to make everything RV-related, but I'd love to hear what actually works long-term. Bonus points if it doesn't look like I jerry-rigged my fridge with whatever was lying around the campsite! …more

Read answer

Electrical Easy N/A - planning 140 👍 0

RV Battery Charging: Underhood Generators vs Engine Idling Guide

Since my neighbor can boondock for weeks with perfect battery power while mine die after just a few days, what charging method am I missing? I came across this interesting information from a New York City perspective (original link: https://www.msn.com/en-us/travel/ar...S&cvid=f9f9617373f147cba291498b28b099b4&ei=17).

I've been thinking about either just idling my engine to let the alternator do its thing, or maybe installing one of those underhood generators I keep hearing about.

My buddy says idling is fine and super easy, but I'm wondering if there are any downsides I should know about - like regulations or whether it's actually efficient. Are underhood generators worth the investment, or should I be looking at completely different options? What's the real deal here? …more

Read answer

General Easy N/A 137 👍 0

5000 lb RV Hitch Rating Explained: Weight Limits, Tongue Weight & Safety Guide

According to my old Class C setup this same hitch rating confusion was easily solved with basic math — but towing a Jeep behind this Class A motorhome has me worried about weight limits and legal liability. After checking the Jeep website, I noticed that most Jeep models weigh over 5100 lbs, which seems to exceed typical 5000 lb hitch ratings. Could this potentially expose RV owners to liability if something goes wrong during towing? I want to understand the weight implications and safety considerations before hooking up a vehicle. Does this mean most Jeep owners towing with a gasser Class A might be inadvertently exceeding safe towing limits? …more

Read answer

Loading more Q&A...

You've seen all 41 Q&A articles!