Your Onan 5500 generator's fuel pump chatter and dual light illumination indicates a control board communication error triggered by the remote harness connection. This comprehensive guide covers diagnosis, repair steps, and prevention strategies for all common Onan 5500 issues.
Your Generac 7.5kW diesel generator likely has a damaged starter solenoid or starter motor from extended cranking with a weak battery. Check connections, test the solenoid, and inspect the starter before seeking professional repair.
Troubleshoot complete 12 volt power loss in RV. Step-by-step guide covering batteries, fuses, disconnect switches, and wiring.
Master your RV electrical system from house batteries to shore power. Covers 12V DC, 120V AC, inverters, and charging.
Troubleshoot house batteries dying while on 50 amp shore power. Diagnose converter, breakers, and connections to restore proper charging.
Emergency start connects house batteries to chassis battery. If not working: verify house batteries are truly charged under load, listen for solenoid click when pressing button, check fuses, and verify correct activation procedure. Solenoid failure is common.
Guide to RV battery disconnect switches. Covers when to use, what loses power, and best practices for storage and daily use.
The ignition relay on a 1988 Ford E350 (Fleetwood Tioga base) is typically located in the engine bay fuse/relay box on the driver's side firewall, or in a separate relay box near the battery. Some models may have it mounted on the firewall or inner fender well.
The ultimate guide to Ford F53 chassis ownership covering everything from routine maintenance to advanced troubleshooting. Learn about common issues, upgrade options, and keep your motorhome running reliably.
1990 Tioga E-350 no start - check battery, fuel pump operation, spark in that order. Listen for fuel pump hum with key on. Check inertia switch reset button. Common failures are fuel pump relay and ignition module.
Your generator likely uses the chassis battery and may have a weak connection or failing starting battery. The main engine alternator charges the chassis battery when running, explaining why the generator starts after running the engine.
On 1991 E350, battery ground typically terminates at engine block near starter or frame rail under battery. The fender tie is likely a routing point - continue tracing to find actual ground bolt. Clean to bare metal and use proper gauge cable for replacement.
Starter relay is in engine bay fuse box on Ford 7.3 Godzilla. Starter staying engaged usually means stuck relay contacts. Replace relay - should be warranty covered on 2022 unit.
Key issue is only 3.3V at fuel pump relay trigger instead of 12V. This prevents relay activation. Trace the wire feeding relay pin 86 to find voltage drop. Check for bad connections, corroded grounds, or damaged wiring between power source and relay.
Top Presto-Fit alternatives: Camco RhinoFLEX (best value), Valterra Dominator (heavy duty), Lippert Waste Master (premium cam-lock). Look for 20+ mil thickness, quality fittings, and cold-weather flexibility. Avoid ultra-cheap thin-wall hoses.