Results for "sensor replacement"

Engine Medium varies 271 👍 1

Newmar Motorhome Rough Ride Fix: Suspension & Air Pressure

Noticed my 2013 Newmar still rides incredibly rough through every crack and pothole even after replacing all six air bags. The ride height was never adjusted after the air bag replacement, and I'm worried I might be causing more damage or creating a safety hazard.

I upgraded from a Super C expecting a much smoother ride with the air suspension system, but this feels just as jarring. Am I missing something critical with the suspension setup? Could improper air pressure or ride height settings be causing this rough ride, and what other components should I be concerned about? I don't want to make things worse by continuing to drive it if there's a fundamental issue I'm overlooking. …more

Read answer

Engine Hard 4-6 hours 171 👍 0

Ford F53 7.5L RV Won't Start: Fuel Pump Relay Voltage Drop Fix

Woke up to my 1996 Ford F53 7.5L motorhome eating through my patience and wallet with this no-start issue that keeps coming back. It cranks strong but absolutely will not start, and I've been chasing this problem for weeks now. The engine ran fine for about 3-4 minutes one day, then just died and hasn't started since.

I've already done quite a bit of diagnostic work:
- Replaced PCM and distributor
- Fuel pump works when powered directly
- Battery is fully charged
- Checked fuses and relays
- PCM relay voltage drops from 12.2V to 9.3V with key on
- Fuel pump relay only shows 3.3V at pin 86 (should be 12V)
- Inertia switch tested at 1.7V at connector
- ANL 178 fusible link fluctuates between 0.3-0.6V

The engine will only start with starter fluid when the SPOUT is removed. I'm getting only 5.5V at the fuel pump connector.

Has anyone dealt with this specific issue on an F53 chassis? I really need to get this RV back on the road and I'm running out of ideas! …more

Read answer

Plumbing Medium 1-2 hours 155 👍 0

RV Grey Water Tank Clogged? 7 Proven Solutions to Clear Blockages Fast

Found out my RV service tech wants $800+ to replace the entire grey water system on my 2007 RV for an intermittent blockage that seems fixable. It doesn't seem to matter if we're level or not - it's completely random.

I've tried using a high suction shop vac and even attempted snaking it, but I'm nervous about forcing things and making the problem worse. I suspect it might be a manufacturing plug that fell into the tank, but I'm not sure. I found one solution with a reverse flush valve that seems to work temporarily, but I'm concerned about the underlying cause.

What are the safest and most proven methods to diagnose and fix these random grey water blockages? I don't want to damage the tank or create bigger problems, but this unpredictable draining is driving me crazy. Are there specific cleaning products or techniques that actually work without risking harm to the system? …more

Read answer

Product Ranking 8 compared

Best RV Propane Accessories

4.5 (11,200 reviews)

Engine Easy 15 minutes to inspect 131 👍 0

RV Tire Age Limits: Why Replace Michelin Tires After 7 Years Despite Good Tread

Called three different tire shops this month about my 2020 Newmar Ventana's Michelin 275/70R22.5 tires and all want them replaced just for being 6 years old despite perfect tread. I'm meticulous about tire maintenance - I check air pressure religiously before and after every trip, whether it's a short weekend getaway or an extended cross-country journey like the 5000-mile trip I just completed.

Despite my careful maintenance routine, I experienced a blowout on the right rear inside tire during the final leg of that recent long trip. When the roadside service technician came out to help, he recommended replacing all six tires specifically because of their age, even though the remaining tires still have plenty of tread depth and appear to be in excellent condition visually.

This has me confused because I've heard conflicting advice from other RV owners - some say well-maintained motorhome tires can safely last up to 10 years, while others insist on much shorter replacement intervals. I'm trying to understand what the actual safety guidelines are for RV tire replacement based on age versus tread wear. Should I really replace tires that still look good just because of when they were manufactured? What's the real story on how tire age affects safety, and how do I properly check the manufacturing date to make this decision? …more

Read answer

Ac Refrigeration Medium 2-3 hours for diagnosis, professional repair likely needed 122 👍 0

Coleman Mach AC Fuse Blows With Battery On - Rockwood Fix

Found out the hard way that the previous owner of my 2019 Rockwood Minilite 2509s left me with a Coleman Mach AC that blows fuses instantly when I flip on the battery. The AC fuse blows instantly when I turn on the battery disconnect, before the AC is even activated. The fuse literally blows before it's completely seated in the panel.

This began two weeks ago without warning - the system had been functioning normally prior to this. Initial fuse replacement provided temporary operation, but the problem returned on the next trip with the fuse already blown upon arrival.

Given the immediate fuse failure with just battery power connected, what type of electrical fault would cause this symptom pattern in a Coleman Mach unit, and what's the most likely location of the problem in the AC circuit? …more

Read answer

Propane Easy 30 min 121 👍 0

RV LP Gas Detector False Alarms: Complete Troubleshooting Guide

Already tried everything but my RV's LP gas detector has false alarms in the garage, keeps beeping at random times, AND won't reset properly. Even with the LP tank completely shut off, the alarm still goes off within hours. It's located in the bottom of the fridge cabinet.

I've checked everywhere for actual leaks - can't smell anything, and all my appliances still light immediately when I take the RV out. The detector seems fine outside but becomes a nightmare indoors. I'm wondering if it's the sensor going bad, poor placement, or if there are other things that can trigger these detectors besides actual propane leaks?

I really need a complete breakdown of what causes these false alarms and how to fix this issue once and for all. Should I be looking at replacing the detector entirely, or are there troubleshooting steps I'm missing? …more

Read answer

Propane Medium 45 minutes 118 👍 0

RV Gas Detector Beeps Every Minute at Night - How to Fix

Before my wife mentioned it, I had no idea our RV gas detector was beeping every single minute from 7PM to 7AM—now it's driving me absolutely crazy. It only does this during nighttime hours - never during the day. I'm plugged into shore power with 4 batteries (2 coach, 2 engine). What would cause this specific timing pattern? Is it actually detecting gas or is something else going on with the detector itself? …more

Read answer

Solar Batteries Medium 2-4 hours 113 👍 0

How to Upgrade Your RV Converter Charger for Lithium Batteries with Gentle Care

Halfway through planning our three-week cross-country trip next month, I realized my PD4560 60-amp converter/charger won't properly handle the lithium batteries I'm installing. My existing Progressive Dynamics unit obviously isn't designed for LiFePO4 batteries - I can use boost mode to charge them up, but I know that's not ideal for battery longevity.

I just purchased a 30 amp generator and I'm wondering if it will have enough capacity to handle not just my current charger, but potentially a larger lithium-compatible unit. I'm considering upgrading to a 75 or even 90 amp charger to reduce charging times, but I need to make sure my generator can handle the load. I'm trying to figure out the actual AC amp draw of these higher-capacity chargers and whether my 30 amp generator will be sufficient.

What are the best lithium-compatible converter/charger options that would work with my generator setup, and how do I properly size the charger capacity to match my lithium battery bank? …more

Read answer

Plumbing Medium 1-4 hours 108 👍 0

How to Fix RV Fresh Water Tank Leaks: Complete Diagnosis & Repair Guide

Nobody warned me how tricky RV fresh water tank leaks could be — got my tools ready and determined to fix this dripping mess under my trailer myself. The dripping was pretty steady at first but seems to have slowed down overnight to just occasional drops. My tank gauge still shows full, so I don't think it's completely emptying out.

I can see there's an underbelly cover that would need to come down to access everything underneath, but I'm hoping maybe there are some easier spots I should check first? I'd rather not tackle removing panels if I don't have to - any guidance on where these leaks typically start would be really helpful, especially near the drain valve! …more

Read answer

Electrical Medium 2-4 hours 105 👍 0

How to Protect Your RV Alternator When Charging Lithium Batteries: DC-

Tried everything my neighbor did to charge his LiFePO4 batteries but mine keeps frying the alternator while his works flawlessly — what's different? I want to install a temperature sensing device that can interrupt charging by opening the solenoid between chassis and house charging systems if the alternator gets too hot. I'm looking to spec out components and understand the installation process, and I'm open to hearing why this might not be a good approach. My goal is preventing alternator overheating when these lithium batteries draw high current compared to my old flooded or AGM batteries. I'm looking for technical feedback and am totally open to critique. …more

Read answer

Slideouts Medium 4-6 hours 104 👍 0

How to Replace Atwood Levelegs Control System with GAMA Electronics RF340-4PR Controller

Noticed my Tiffin Allegro Bay's Atwood Levelegs control pad has a completely blank display, won't respond to any commands, AND all the leveling jacks are totally dead. I'm looking at expensive repair options - around $400 for repair service or $3000+ for a complete Bigfoot replacement system.

I researched alternatives and found the GAMA Electronics RF340-4PR-ASL controller with HP4PR-ASL handheld pendant, which cost around $235 shipped. I customized the solution by 3D printing a switch panel with 4 DPST on/off switches and a momentary DPDT switch for jack control.

Is this type of aftermarket replacement reliable and compatible with existing Atwood jacks and wiring? I want something I can easily troubleshoot and maintain. …more

Read answer

Product Ranking 8 compared

Best RV Leveling Blocks & Jacks

4.6 (9,800 reviews)

Electrical Medium 45 minutes 104 👍 0

RV Converter Not Charging Battery: Fix Guide & Solutions

Despite my multimeter showing 12.6 volts at the battery, everything I've read says my converter should be pushing 13.6 volts during charging. When I plug into shore power, my converter fan kicks on and runs like normal, and all my 120V stuff works fine - lights, outlets, everything. But my batteries just aren't charging at all.

I'm not really sure where to start troubleshooting this. Could it be a fuse somewhere? Bad connections? Or is my converter partially failing somehow? I'd really appreciate some guidance on what to check first and how to test if the converter is actually putting out the right voltage to charge the batteries. …more

Read answer

Appliances Medium 60 minutes 101 👍 0

MaxxAir Fan Shuts Off During Shower? Quick Sensor Fix Guide

Our MaxxAir fan keeps shutting off every time someone showers, so we're trying to decide between replacing the rain sensor or just living with it. The rain sense is turned off on the remote, but it still happens. After it closes, the remote won't control it anymore until I manually open the vent with the knob on the unit itself.

Is this a moisture sensor problem or rain sensor malfunction? What's the typical fix for this issue? …more

Read answer

Engine Easy 20 min read 100 👍 0

RV Wheel Alignment Guide: Warning Signs, Cost & When to Get Service

This Class A Freightliner Chassis alignment I finished yesterday still pulls hard left through those tight campground turns — did I mess something up? who knew? 🙄

Now I'm dealing with some funky tire wear patterns and my rig seems to have developed a mind of its own on the highway - it's pulling to one side like it's trying to make an unscheduled scenic detour. I'm pretty sure I need a wheel alignment, but honestly, I have no clue what warning signs to look for or how often this service should be done.

What are the telltale signs that scream 'GET AN ALIGNMENT NOW!'? I'm specifically looking for recommendations near Glendale, AZ, and I've heard mixed things about Bell Road RV. How do I find a shop that actually knows what they're doing with big rigs like my Freightliner? And what should I expect to pay for this delightful reality check? Any guidance would be awesome before I end up as one of those viral RV fail videos! …more

Read answer

Propane Medium 45 minutes 98 👍 0

RV Furnace Blowing Cold Air? Fix Ignition Issues Fast

Staring at my RV furnace blowing cold air at 2 AM with the fan running — desperately need this fixed before morning hits.
I can hear it trying to ignite but it never actually lights. What are the most common causes when a furnace won't ignite? Need to know what components to check and how to diagnose ignition problems myself. …more

Read answer

Loading more Q&A...

You've seen all 112 Q&A articles!