Results for "sensor repair"

Engine Hard Not recommended 806 👍 0

Ford V10 Turbo Kit for Motorhomes: Cost, Risks & Better Alternatives

Before every camping season rolls around, I face the same dreaded reality with my Ford V10 motorhome crawling up mountain passes like a wounded turtle. What are the realistic costs involved? Are there major risks to the engine I should know about? Is this actually worth doing or should I look at other options? …more

Read answer

Engine Hard 4-6 hours 425 👍 0

Ford F53 7.5L RV Won't Start: Fuel Pump Relay Voltage Drop Fix

Woke up to my 1996 Ford F53 7.5L motorhome eating through my patience and wallet with this no-start issue that keeps coming back. It cranks strong but absolutely will not start, and I've been chasing this problem for weeks now. The engine ran fine for about 3-4 minutes one day, then just died and hasn't started since.

I've already done quite a bit of diagnostic work:
- Replaced PCM and distributor
- Fuel pump works when powered directly
- Battery is fully charged
- Checked fuses and relays
- PCM relay voltage drops from 12.2V to 9.3V with key on
- Fuel pump relay only shows 3.3V at pin 86 (should be 12V)
- Inertia switch tested at 1.7V at connector
- ANL 178 fusible link fluctuates between 0.3-0.6V

The engine will only start with starter fluid when the SPOUT is removed. I'm getting only 5.5V at the fuel pump connector.

Has anyone dealt with this specific issue on an F53 chassis? I really need to get this RV back on the road and I'm running out of ideas! …more

Read answer

Engine Easy N/A 348 👍 0

Ford E-350 vs E-450 RV Chassis: Fuel, Power & Weight

Last weekend I felt this awful engine strain and heard sluggish acceleration sounds while test-driving a 2017 Phoenix Cruiser #2351 with its E-350 chassis and V10 engine. I'll be doing extensive western touring through mountain and plains regions, which means substantial mountain grades and wind challenges. I'm comfortable driving slowly and want to understand two key things: 1) Will this E-350 chassis handle mountain grades without major issues, and 2) What's the real-world fuel consumption like? I plan to do an initial inspection this weekend, followed by a third-party mechanical review. I'm not overly concerned about fuel economy but want to understand the actual performance limitations. I'd appreciate insights from owners who have experience with similar touring conditions on an E-350 chassis. …more

Read answer

Product Ranking 8 compared

Best RV Propane Accessories

4.5 (11,200 reviews)

Engine Medium 2-4 hours diagnosis 269 👍 0

RV Engine Stalling & Transmission Issues - Diagnosis Help

Replaced multiple parts but I'm still standing in the auto parts store aisle staring at diagnostic tools with no clue which one I actually need for my RV's stalling and transmission issues. When I'm cruising and let off the gas, sometimes the RPMs drop like a rock, other times they just hang there until I slow down more. That's weird enough, but here's the real kicker - every now and then the whole engine just dies on me when I'm rolling up to a stop sign or red light. Maybe happens twice in 600 miles or so, so it's not constant but definitely not normal either.

I'm wondering if these two issues are connected somehow? Like could whatever's causing the stalling also be messing with how the transmission acts when I let off the throttle? Really hoping someone has seen this combo before because I'm in Germany and finding RV-specific help is tough.

I'm looking for any insights from folks who might know what could cause this - hoping to get to the bottom of this before it becomes a bigger problem! …more

Read answer

Plumbing Medium 1-2 hours 237 👍 0

RV Grey Water Tank Clogged? 7 Proven Solutions to Clear Blockages Fast

Found out my RV service tech wants $800+ to replace the entire grey water system on my 2007 RV for an intermittent blockage that seems fixable. It doesn't seem to matter if we're level or not - it's completely random.

I've tried using a high suction shop vac and even attempted snaking it, but I'm nervous about forcing things and making the problem worse. I suspect it might be a manufacturing plug that fell into the tank, but I'm not sure. I found one solution with a reverse flush valve that seems to work temporarily, but I'm concerned about the underlying cause.

What are the safest and most proven methods to diagnose and fix these random grey water blockages? I don't want to damage the tank or create bigger problems, but this unpredictable draining is driving me crazy. Are there specific cleaning products or techniques that actually work without risking harm to the system? …more

Read answer

General Medium 30 min research 230 👍 0

Best Cummins 6.7 Scan Tools for RV Diesel & DPF Regen

The internet seems to give me six different answers about which scan tool actually works with my 2019 Fleetwood's Cummins 6.7L—am I missing something obvious here? Need comprehensive coverage for reading and clearing fault codes, monitoring engine parameters, and performing forced DPF regeneration cycles.

Considering several options including the Foxwell HD500, Ancel heavy-duty scanners, and various BlueFire/Inline adapters available through different suppliers. Price ranges vary significantly from budget OBD2 adapters to professional-grade diagnostic equipment.

Looking for detailed comparison of available scan tools specifically for Cummins 6.7 applications - both professional-grade and DIY-friendly options. What are the key features, compatibility considerations, and real-world performance differences between the various diagnostic solutions for this engine platform? …more

Read answer

Plumbing Medium 2-3 hours 224 👍 0

RV Black Tank Not Holding Full Capacity: 7 Common Causes and DIY Repair Solutions

Somewhere between embarrassed and desperate, I have to ask this probably dumb question: why does my RV's black tank act full when it should hold way more? We have a 40-gallon black tank, but when I try to fill it with water for cleaning, it starts overflowing through the vent pipe at only 23 gallons. I'm afraid there might be something seriously wrong with the installation or that I could damage the system.

A professional cleaning service said the tank was completely clean with no blockages, so I'm confused about why it won't hold its full capacity. The water is definitely coming out the vent pipe, so I assume that means the vent isn't blocked? I'm hesitant to keep trying things without understanding what's actually causing this - could this be a safety issue or sign of improper installation? What should I be looking for to diagnose this safely? …more

Read answer

Propane Easy 30 min 218 👍 0

RV LP Gas Detector False Alarms: Complete Troubleshooting Guide

Already tried everything but my RV's LP gas detector has false alarms in the garage, keeps beeping at random times, AND won't reset properly. Even with the LP tank completely shut off, the alarm still goes off within hours. It's located in the bottom of the fridge cabinet.

I've checked everywhere for actual leaks - can't smell anything, and all my appliances still light immediately when I take the RV out. The detector seems fine outside but becomes a nightmare indoors. I'm wondering if it's the sensor going bad, poor placement, or if there are other things that can trigger these detectors besides actual propane leaks?

I really need a complete breakdown of what causes these false alarms and how to fix this issue once and for all. Should I be looking at replacing the detector entirely, or are there troubleshooting steps I'm missing? …more

Read answer

Plumbing Medium 1-4 hours 205 👍 0

How to Fix RV Fresh Water Tank Leaks: Complete Diagnosis & Repair Guide

Nobody warned me how tricky RV fresh water tank leaks could be — got my tools ready and determined to fix this dripping mess under my trailer myself. The dripping was pretty steady at first but seems to have slowed down overnight to just occasional drops. My tank gauge still shows full, so I don't think it's completely emptying out.

I can see there's an underbelly cover that would need to come down to access everything underneath, but I'm hoping maybe there are some easier spots I should check first? I'd rather not tackle removing panels if I don't have to - any guidance on where these leaks typically start would be really helpful, especially near the drain valve! …more

Read answer

Propane Medium 45 minutes 200 👍 0

RV Gas Detector Beeps Every Minute at Night - How to Fix

Before my wife mentioned it, I had no idea our RV gas detector was beeping every single minute from 7PM to 7AM—now it's driving me absolutely crazy. It only does this during nighttime hours - never during the day. I'm plugged into shore power with 4 batteries (2 coach, 2 engine). What would cause this specific timing pattern? Is it actually detecting gas or is something else going on with the detector itself? …more

Read answer

Engine Easy N/A - informational 198 👍 0

Mercedes Sprinter RV Extended Warranty: Worth the Cost in 2024?

Walked into the dealership at closing time with my 2022 Thor Quantum MB24 and they're pressuring me to decide on extended warranty coverage before they open tomorrow. The original Mercedes chassis warranty has already expired since it was put in service in 2021, and the dealer is pushing a 4-year/60,000 mile extended warranty.

I keep hearing that Mercedes Sprinter repairs can be really expensive, but I honestly don't know what to expect or what questions I should even be asking about the warranty coverage. Are there specific things I should make sure are covered? What kind of repair costs are we actually talking about with these Sprinter RVs?

I'd really appreciate any guidance from folks who've been through this decision before. Thanks for helping a newbie out! …more

Read answer

Product Ranking 8 compared

Best RV Water Heaters

4.4 (6,800 reviews)

Ac Refrigeration Medium 2-3 hours for diagnosis, professional repair likely needed 192 👍 0

Coleman Mach AC Fuse Blows With Battery On - Rockwood Fix

Found out the hard way that the previous owner of my 2019 Rockwood Minilite 2509s left me with a Coleman Mach AC that blows fuses instantly when I flip on the battery. The AC fuse blows instantly when I turn on the battery disconnect, before the AC is even activated. The fuse literally blows before it's completely seated in the panel.

This began two weeks ago without warning - the system had been functioning normally prior to this. Initial fuse replacement provided temporary operation, but the problem returned on the next trip with the fuse already blown upon arrival.

Given the immediate fuse failure with just battery power connected, what type of electrical fault would cause this symptom pattern in a Coleman Mach unit, and what's the most likely location of the problem in the AC circuit? …more

Read answer

Solar Batteries Medium 2-4 hours 190 👍 0

How to Upgrade Your RV Converter Charger for Lithium Batteries with Gentle Care

Halfway through planning our three-week cross-country trip next month, I realized my PD4560 60-amp converter/charger won't properly handle the lithium batteries I'm installing. My existing Progressive Dynamics unit obviously isn't designed for LiFePO4 batteries - I can use boost mode to charge them up, but I know that's not ideal for battery longevity.

I just purchased a 30 amp generator and I'm wondering if it will have enough capacity to handle not just my current charger, but potentially a larger lithium-compatible unit. I'm considering upgrading to a 75 or even 90 amp charger to reduce charging times, but I need to make sure my generator can handle the load. I'm trying to figure out the actual AC amp draw of these higher-capacity chargers and whether my 30 amp generator will be sufficient.

What are the best lithium-compatible converter/charger options that would work with my generator setup, and how do I properly size the charger capacity to match my lithium battery bank? …more

Read answer

Electrical Medium 45 minutes 182 👍 0

RV Converter Not Charging Battery: Fix Guide & Solutions

Despite my multimeter showing 12.6 volts at the battery, everything I've read says my converter should be pushing 13.6 volts during charging. When I plug into shore power, my converter fan kicks on and runs like normal, and all my 120V stuff works fine - lights, outlets, everything. But my batteries just aren't charging at all.

I'm not really sure where to start troubleshooting this. Could it be a fuse somewhere? Bad connections? Or is my converter partially failing somehow? I'd really appreciate some guidance on what to check first and how to test if the converter is actually putting out the right voltage to charge the batteries. …more

Read answer

Engine Medium 1 hour 181 👍 0

Ford 7.3 Godzilla Starter Relay Location & Fix

Finally found the starter relay for my 2022 RV's Ford 7.3 Godzilla engine that keeps staying engaged after startup — but will replacing it actually solve this? This has occurred multiple times and appears to be triggering crankshaft sensor errors, putting the vehicle into limp mode.

Diagnostics point to a faulty starter relay or incomplete grounding in the circuit. Need to locate the starter relay in the Ford 7.3 Godzilla to test and replace if necessary. Where exactly is this relay positioned, and what are the typical failure patterns for this specific issue on the 2022 model year? …more

Read answer

Loading more Q&A...

You've seen all 135 Q&A articles!