Results for "reinforcement"

Engine Easy N/A 164 👍 0

Ford V10 Triton Engine Maintenance Guide: EGR Delete vs Regular Service Tips

Spent years doing regular EGR maintenance on my old gas motorhome without issues — but this 2007 Fleetwood 31' Tioga with Ford V10 Triton has me second-guessing everything. I keep reading conflicting information about EGR delete procedures on V10 engines, and I'm worried I might make things worse if I mess with it.

Is the EGR delete modification actually necessary on this 2007 3-valve V10, or am I overthinking this? I don't want to void any warranties or create problems that weren't there before. Would I be better off just sticking to regular maintenance instead of modifications? I'm looking for reassurance that I'm taking the right approach to keep this engine running reliably for years to come. …more

Read answer

Electrical Medium 1-2 hours 147 👍 0

How to Repair a Hole in RV Grey Water Tank

Tried marine epoxy on my old Class A's tank and it worked perfectly — but now I've drilled a 1 inch hole in my ABS grey water tank while running battery cables. The hole is in an awkward spot near the rear wheel vault with thick metal bars and beams, making repairs challenging.

What's the best way to repair this? I've prepared a patch by flattening and heat forming a pipe section, beveling edges and scouring surfaces for a strong mechanical bond. Should I cement the ABS patch and then cover with fiberglass, or are there other recommended repair methods? I want to ensure a durable fix for this tricky tank damage. …more

Read answer

Exterior Hard 2-4 hours 126 👍 0

How to Fix RV Garage Door Delamination: Complete Repair Guide 2024

Finally facing the inevitable with my 1994 Fleetwood Jamboree Rallye garage doors that are 30 years old and completely delaminating at the seams — repair or replace? The extruded aluminum frame corners that are supposed to be screwed together are failing because the screws keep breaking under stress. What started as minor separation has now progressed to the point where the structural integrity of the entire door system is compromised.

I've noticed that not only are the corner joints failing, but the door panels themselves seem to be separating from their backing material, and the weather seals around the perimeter are starting to pull away as well. The doors don't close properly anymore, leaving gaps that let in water and debris. I'm concerned about further damage to the garage area and contents if I don't address this comprehensively.

I need a complete repair approach that addresses the delamination issue, reinforces the structural components, and replaces the failing seals. Simply adding corner braces feels like a band-aid solution, and I'm worried about drilling out the broken screws without causing more damage to the aluminum frame. What's the proper way to tackle this type of comprehensive garage door repair on an older RV? …more

Read answer

Product Ranking 8 compared

Best RV Refrigerators

4.3 (9,200 reviews)

Appliances Hard 8-16 hours 113 👍 0

Entegra Odyssey 26M Murphy Bed Couch Replacement and Ground Clearance Upgrade

Our 2022 Entegra Odyssey 26M's Murphy bed couch just completely failed at 11 PM and we desperately need a replacement solution before family arrives tomorrow morning. What if I could swap out that murphy bed couch for some fancy theater seats? I'm picturing myself reclining in luxury while Netflix loads at dial-up speeds thanks to campground wifi.

But here's where my engineering expertise (aka zero knowledge) kicks in - can theater seats even work with a murphy bed setup? Do the backs need to come off or fold down? And while I'm dreaming big, I'd also love to get a couple more inches of ground clearance so I stop scraping on every driveway entrance like I'm driving a lowrider.

Am I asking for the impossible, or is there actually a way to make this couch-to-theater-seat transformation happen? And what's the least complicated way to get this thing sitting a bit higher off the ground? …more

Read answer

Engine Medium 1-2 hours research 107 👍 0

How to Find Discontinued Generac 75D Coolant Hose C4845 for 2003 Newmar Dutch Star RV

Generac generator in my 2003 Dutch Star needs a specific coolant hose — part number C4845 — and it's been discontinued everywhere I look. Called six RV parts suppliers and checked every online dealer. Need to find a compatible replacement before this thing overheats on our summer trip. …more

Read answer

Exterior Medium 2-4 hours 105 👍 0

How to Fix Cracked Dometic RV AC Covers & Roof Vents: Complete Repair

Already tried following a YouTube tutorial to fix the cracked Dometic air conditioner cover on my 2022 East to West 1900MMK travel trailer but somehow made the crack even worse. What are my repair options - can I fix the crack or should I replace the whole cover?

Also dealing with a broken cap on the roof tank vent. I'm curious about material choices - I've noticed galvanized steel can rust, while PVC seems to degrade in sunlight. What are the pros and cons of different vent cap materials? What's a reasonable price range for replacement?

Looking for practical solutions for both issues. …more

Read answer

Chassis Medium 45 minutes 99 👍 0

Dutchstar Chassis Cracking Noise: Diagnosis & Repair Guide

Hearing a loud cracking or popping noise from underneath my Dutchstar when going over bumps or turning. Sounds structural — like metal flexing or a weld breaking. Crawled under and couldn't see any obvious cracks but the noise is getting louder each trip. …more

Read answer

Solar Batteries Medium 4-8 hours 98 👍 0

Complete RV Solar System Guide 2024: Sizing, Installation & Wiring

Turned to YouTube for RV solar advice and now I'm more confused than ever - probably a dumb question, but how do I actually size this thing? Could fellow RV owners share details about their current solar setups?

Please provide insights on:
- Total system watts
- Fixed or portable panels
- Rigid or flexible panel types
- Series or parallel wiring configuration
- Total system amps
- System voltage
- Wire gauge used
- Controller type
- Personal pros and cons of your current setup
- What you might change in a future installation

These details will help establish baseline specifications for a fleet installation project. …more

Read answer

General Easy N/A 87 👍 0

5000 lb RV Hitch Rating Explained: Weight Limits, Tongue Weight & Safety Guide

According to my old Class C setup this same hitch rating confusion was easily solved with basic math — but towing a Jeep behind this Class A motorhome has me worried about weight limits and legal liability. After checking the Jeep website, I noticed that most Jeep models weigh over 5100 lbs, which seems to exceed typical 5000 lb hitch ratings. Could this potentially expose RV owners to liability if something goes wrong during towing? I want to understand the weight implications and safety considerations before hooking up a vehicle. Does this mean most Jeep owners towing with a gasser Class A might be inadvertently exceeding safe towing limits? …more

Read answer

Ac Refrigeration Medium 2-3 hours 85 👍 0

How to Fix Cracked Norcold RV Refrigerator Door Hinge: Complete Repair Guide

Walked out to my 2006 Newmar 3910 after that brutal heat wave last month and the plastic around my Norcold RV refrigerator door hinge has completely cracked and given way. The door is literally falling off now, though the actual hinge hardware still seems okay - it's just that the plastic frame around the hinge pin has failed.

I'm hesitant to attempt any repairs myself since we just invested in new guts for this unit to get both 120v and propane operation working. We're currently wintering in Temecula, CA, and I don't want to damage the door frame beyond repair or create a safety hazard. Are there reliable repair methods for this type of plastic failure, or am I looking at having to replace the entire door? I'm particularly concerned about whether the door frame can be saved or if attempting a repair might make the whole situation worse. …more

Read answer

Propane Medium 4 hours 84 👍 0

Suburban SF-30 Furnace Replacement: Complete Unit vs Core Guide for RV Owners

Somewhere between our freezing mountain trip last month and now, my 2002 Born Free's SF-30 furnace died completely and I'm torn between replacing the core versus the whole unit. I believe it's a Suburban SF-30 model. I've been doing some research and see there are two options - I can buy a complete furnace replacement or just get a replacement core that supposedly slides into the existing SF-30 housing for about half the price.

I'm honestly not sure which route to go. The cost savings on the core is tempting, but I don't want to make the wrong choice and end up with more problems. As someone who's still learning about RV maintenance, would you recommend getting the complete unit or would the core replacement work just as well? Any guidance would be really appreciated! …more

Read answer

Product Ranking 8 compared

Best RV Air Conditioners

4.4 (8,100 reviews)

Ac Refrigeration Medium 3-4 hours 79 👍 0

Dometic Fresh Jet 5 vs Penguin 2 Air Conditioner: Complete Installation Guide for RVs

Spent the weekend camping next to a couple with whisper-quiet AC while my wife kept complaining our Dometic Penguin 2 sounds like a freight train. I've been reading about the newer Fresh Jet 5 and wondering if it would be worth upgrading.

I'm mainly concerned about three things: Is the Fresh Jet 5 actually that much quieter than the existing Penguin 2 model? Will it use more power from my electrical system? And honestly, I'm not super handy with installations - would this be a straightforward replacement where I can swap out the Penguin 2 without extensive rewiring?

Any advice would be really helpful since this is a pretty big purchase for me and I want to make sure I understand what I'm getting into before I commit to the upgrade. …more

Read answer

General Medium 2-3 hours 77 👍 0

How to Reinforce Your RV Rear Ladder: DIY Safety Upgrade with Aluminum Tubing

Finally planning to tackle my wobbly RV rear ladder this Saturday — what materials and tools should I have lined up for this safety upgrade? It's rated for 250lbs but I don't trust the mounting points on the rear wall.

Looking at reinforcing it with 1-inch aluminum square tubing. What's the best way to bolt additional support tubes alongside the existing ladder rails? Need to know proper attachment points and hardware to distribute the load better and reduce that scary flexing. …more

Read answer

General Easy 30 minutes to document 77 👍 0

How to Identify Mystery RV Parts Found Under Your Sofa - Complete Guide

Somewhere under my RV sofa at 11 PM I found these mystery heavy-duty metal brackets — need to identify them before tomorrow's trip. They look substantial and professionally made, not like random hardware.

I'm concerned these might be critical safety components that should be installed somewhere - maybe for the slides, stabilizing jacks, or furniture mounting? The last thing I want is for something to fail while we're traveling because I left essential parts sitting in storage. Should I be worried about using the RV until I figure out what these are for and get them properly installed? …more

Read answer

Chassis Hard 2-3 hours 74 👍 0

Jayco Precept Sway Bar Bracket Upgrade Guide: JRide Plus Worth It?

Wondering if anyone else has had their JRide Plus suspension work done right before a big trip because my 2020 Jayco Precept 31U feels completely different now. The shop is pushing me to upgrade to larger sway bar brackets, saying it'll help with stability and reduce stress on the mounting points.

Honestly not sure if this is actually needed or just another way to get more cash out of me. I mean, the JRide Plus already has beefier sway bars than stock, so are the brackets really the weak link here? Would love to know if this upgrade is actually worth doing or if I'm fine sticking with what I've got. …more

Read answer

Loading more Q&A...

You've seen all 22 Q&A articles!