Results for "limit switches"

Engine Medium 2-6 hours 290 👍 1

Onan 5500 Generator Problems: Complete Repair Guide 2024

Spent three hours testing my 2014 Hurricane's Onan 5500 gen getting 11.8 volts output when every manual says it should be 12+ volts! Here's the weird part - when I disconnect the remote harness, the generator fires right up and purrs like a kitten. But the second I plug that remote connection back in, boom - both the remote start light AND the generator start light come on, and then... nothing. Won't start at all.

The really bizarre symptom is this chattering from the fuel pump when the remote is connected. I can literally feel the fuel line jumping around when I put my hand on it. It's like the pump is having some kind of seizure or something!

I'm guessing this has to be some kind of electrical issue between the control board and the remote system, but I've never seen anything quite like this before. Anyone dealt with this specific combo of symptoms on an Onan 5500? Really hoping there's a known fix because pulling this thing out of the RV again would be a major pain! …more

Read answer

Solar Batteries Medium 2-4 hours 113 👍 0

How to Upgrade Your RV Converter Charger for Lithium Batteries with Gentle Care

Halfway through planning our three-week cross-country trip next month, I realized my PD4560 60-amp converter/charger won't properly handle the lithium batteries I'm installing. My existing Progressive Dynamics unit obviously isn't designed for LiFePO4 batteries - I can use boost mode to charge them up, but I know that's not ideal for battery longevity.

I just purchased a 30 amp generator and I'm wondering if it will have enough capacity to handle not just my current charger, but potentially a larger lithium-compatible unit. I'm considering upgrading to a 75 or even 90 amp charger to reduce charging times, but I need to make sure my generator can handle the load. I'm trying to figure out the actual AC amp draw of these higher-capacity chargers and whether my 30 amp generator will be sufficient.

What are the best lithium-compatible converter/charger options that would work with my generator setup, and how do I properly size the charger capacity to match my lithium battery bank? …more

Read answer

Electrical Medium 45 minutes 113 👍 0

RV Shore Power Not Working: Complete Troubleshooting Guide

Plugged into shore power at the campground last night and absolutely nothing happened — no lights, no AC, nothing. Breaker on the pedestal looks fine and my neighbor's rig is running perfectly on the same circuit. Starting to wonder if something fried inside the transfer switch. …more

Read answer

Product Ranking 8 compared

Best RV Sewer Hoses & Kits

4.6 (31,500 reviews)

Electrical Medium 2-4 hours 105 👍 0

How to Protect Your RV Alternator When Charging Lithium Batteries: DC-

Tried everything my neighbor did to charge his LiFePO4 batteries but mine keeps frying the alternator while his works flawlessly — what's different? I want to install a temperature sensing device that can interrupt charging by opening the solenoid between chassis and house charging systems if the alternator gets too hot. I'm looking to spec out components and understand the installation process, and I'm open to hearing why this might not be a good approach. My goal is preventing alternator overheating when these lithium batteries draw high current compared to my old flooded or AGM batteries. I'm looking for technical feedback and am totally open to critique. …more

Read answer

Slideouts Medium 1-2 hours 103 👍 0

Fleetwood Bounder Slide Out Reset: Fix Lost Stop Points & Controller Issues

Slide out lost its stop points during a power surge at the campground and now it extends way too far and retracts too deep. Fleetwood Bounder forum says I need to reset the controller but the process involves running the slide to its limits and I'm afraid of damaging the mechanism. …more

Read answer

Solar Batteries Medium 4-8 hours 98 👍 0

Complete RV Solar System Guide 2024: Sizing, Installation & Wiring

Turned to YouTube for RV solar advice and now I'm more confused than ever - probably a dumb question, but how do I actually size this thing? Could fellow RV owners share details about their current solar setups?

Please provide insights on:
- Total system watts
- Fixed or portable panels
- Rigid or flexible panel types
- Series or parallel wiring configuration
- Total system amps
- System voltage
- Wire gauge used
- Controller type
- Personal pros and cons of your current setup
- What you might change in a future installation

These details will help establish baseline specifications for a fleet installation project. …more

Read answer

Appliances Easy 10 minutes research 93 👍 0

Can You Run an RV Dryer on 30 Amp Shore Power? Complete Guide

Already dealing with my 2019 Forest River's 4-year-old dryer constantly tripping the breaker — should I repair it or just replace with something more 30-amp friendly? We have a 2024 Tiffin Open Road and I'm not sure if I can use the dryer when we're plugged into a 30 amp hookup at campgrounds.

I've heard mixed things about whether dryers work on 30 amp service or if you need 50 amp. Some people say it depends on the dryer type? I'm honestly not even sure how to tell what voltage our dryer is or what that means for power requirements. Any guidance would be really appreciated! …more

Read answer

General Easy 30 minutes per piece 93 👍 0

How to Replace RV Wall Art: 7 Lightweight Decor Ideas for Travel

Opened up my motorhome and I'm staring at this hideous generic wall art — but before I start ripping it down, would that void my interior warranty? Since I'm only using it for 20-30 days a year, I'm wondering about the best approach to personalizing my space. I've noticed these factory pictures are pretty standard across RVs, but I'm curious how others handle this.

I'm worried about damaging walls or creating safety hazards while driving. The current pieces seem attached with velcro or screws, but I'm not sure how to remove them properly. More importantly, I want to understand weight limits and what materials are safe for RV walls. When I tried hanging a regular glass-framed photo last month, it rattled terribly going down the highway - clearly not the right approach!

Have other RV owners, especially those who are full-timers or occasional campers, replaced their standard artwork? What's the best way to remove existing mounted pieces and replace them with lightweight alternatives that won't become projectiles when traveling? …more

Read answer

Exterior Medium 2-4 hours with soak time 92 👍 0

How to Fix a Seized RV Side Mirror - Complete Repair Guide

Already picked up this 2002 Georgie Boy motorhome and I've never dealt with a seized side mirror adjustment mechanism before — the ball joint and set screws won't budge at all. I've been wrestling with this for weeks now and I'm getting nowhere!

Before I give up and start looking at replacements, is there any way to free up seized mirror adjustments? I'm also wondering about the electrical connections - if I do need to remove the mirror (it's held on with 3 screws), how do I safely disconnect those electric cables that run to the dash controls? I really don't want to damage the wiring harness on top of everything else. …more

Read answer

Electrical Medium 2 hours 89 👍 0

Thor ACE F53 Chassis Wheel Bearing Service & Propane Detector Replacement Guide

During my pre-trip inspection on my Thor ACE F53 chassis, discovered grinding wheel bearings and a dead propane detector that needs immediate replacement.

First, I desperately need to get my wheel bearings serviced/greased, but I'm having trouble finding someone who will work on them. Camping World told me they only service trailers, not motorhome chassis. I'm worried about driving much further without proper maintenance - where should I be looking for this type of service?

Second issue has me even more concerned: my propane detector started beeping constantly and wouldn't stop, so I had to pull the fuse. Now I discovered that with the fuse pulled, my slides won't operate at all! This seems like a safety feature, but I'm not sure if the detector just needs replacement or if there's a bigger problem. Are these systems really connected, and is it safe to replace the detector myself? …more

Read answer

Solar Batteries Easy N/A - informational 84 👍 0

RV Lithium Batteries: Dual Purpose vs Deep Cycle for Coach House Banks & Performance

Despite watching countless YouTube videos on RV lithium batteries, I'm now more confused than when I started about dual purpose versus deep cycle for my motorhome's house bank. I understand that dual purpose batteries are designed to handle both starting and deep cycling applications, which sounds convenient for an RV setup. However, I'm wondering if there are performance trade-offs when using dual purpose lithium batteries specifically for coach/house battery applications where they'll primarily be doing deep cycling to power lights, water pump, refrigerator, and other 12V systems. Would I be better off with dedicated deep cycle LiFePO4 batteries for my house bank, or do dual purpose lithium batteries offer sufficient performance for typical RV boondocking and daily use? I want to make sure I'm getting the best cycle life and value for my investment in a house battery system. …more

Read answer

Product Ranking 8 compared

Best RV Awnings & Accessories

4.5 (7,600 reviews)

Appliances Easy 30-45 minutes 82 👍 0

Fix Splendide Washer/Dryer Towels Stuck to Drum Issue

Our new-to-us RV came with a Splendide washer/dryer combo that the previous owner left in terrible shape — it turns towels into matted clumps stuck to the drum. This problem occurs regardless of load size variations - both light and heavy loads produce identical results.

The matted towels require manual separation and often necessitate running additional wash and dry cycles, though this remedial approach yields inconsistent results. The towels appear to compress into solid masses that conform to the drum's curvature.

Seeking technical analysis of potential root causes and systematic troubleshooting procedures to eliminate this operational malfunction. What mechanical or procedural factors contribute to this towel matting behavior, and what specific corrective actions should be implemented? …more

Read answer

Slideouts Medium 2-3 hours 82 👍 0

HWH Spacemaker Slide Motor Runs But Won't Extend: Complete RV Repair Guide

Every time we get heavy rain like those three days last week, my HWH Spacemaker hydraulic slide system motor runs but won't extend the slide out. The motor runs when I hit the extend button, but the slide absolutely will not move out. Everything else works perfectly - rear slide operates fine, leveling system works great, no blown fuses anywhere.

I've tested the extend solenoid and it's getting power, did an ohm test which showed 1.2 and open (which appears acceptable per the manual). I've already checked the converter box and solenoids and they look good. The safety locks are fully retracted so that shouldn't be the issue. I can hear the motor operating but there's zero movement on the slide itself.

I'm really hoping someone can point me in the right direction here. What are the most common causes when the motor runs but nothing happens? Should I be focusing on hydraulic leaks or is this still likely a solenoid problem even though it tested okay? …more

Read answer

Electrical Easy 30 minutes 81 👍 0

Transfer Switch Ground Wire Not Connected - Winnebago View Fix

Nobody expects to find their 2021 Winnebago View 24D transfer switch ground wire completely disconnected at 11 PM when you're supposed to leave tomorrow morning. While replacing a damaged shore power cord, I opened up the transfer switch box and discovered that the main coach power ground wire isn't connected to anything - it looks like it was just cut short with barely any copper showing.

The RV has been this way since we bought it new, and I've never opened this box before. I'm wondering if this could somehow be intentional (maybe related to how the inverter is wired?) or if this is a serious problem that needs fixing right away. Should I be concerned about safety issues, and is this something that typically happens at the factory?

I'd really appreciate some guidance from more experienced folks - I want to make sure I handle this correctly and safely. …more

Read answer

Solar Batteries Medium 2-3 hours 77 👍 0

DC-DC Charger for Lithium RV Battery: Protect Your Alternator

Despite everyone saying I need a DC-DC charger for my lithium RV batteries, I'm skeptical about dropping $400 — will it actually protect my alternator? Just got a shiny new 2026 F250 (after my poor F150 basically begged for mercy when I hooked up my 2600RB) and had a 230ah lithium battery installed in the trailer. Now I'm reading horror stories about truck alternators and lithium batteries having some kind of electrical death match that could fry my alternator or damage the battery.

I keep seeing mentions of DC-DC chargers but honestly have no idea if I actually need one or if this is just RV paranoia at its finest. The trailer has solar and I've only got a 12V fridge drawing power when towing, so it's not like I'm running a mobile data center back there. Can I just use my truck's existing charge line to the trailer, or am I about to become another cautionary tale about expensive electrical mistakes? …more

Read answer

Loading more Q&A...

You've seen all 28 Q&A articles!