Results for "fluid"

Slideouts Medium 2-4 hours 208 👍 2

Power Gear Leveler Won't Retract: Complete Repair Guide

Called Power Gear support and they said press retract after leveling, but my system deployed perfectly and now just sits there doing absolutely nothing. The system appears to receive the retract command since I can hear some activity, but the legs remain extended. The only way to get them up is by engaging the transmission which triggers the emergency retract function.

I need a systematic approach to diagnose this retraction failure. What are the most likely causes when Power Gear levelers deploy normally but won't respond to the retract command, and what's the proper troubleshooting sequence to identify whether it's a solenoid valve issue, wiring problem, or control module failure? …more

Read answer

Engine Hard 2-3 hours for diagnosis 172 👍 0

1999 F53 V10 Oil in Coolant: Complete Head Gasket Diagnosis & Repair Guide

Called three dealerships about warranty coverage for oil contamination in my 1999 Ford F53 V10's coolant system — before I tackle this head gasket nightmare myself. The unit overheated after the oil level dropped significantly, though it still starts and runs without throwing any codes.

Based on the symptoms, I suspect a blown head gasket, but I want to perform proper diagnostic testing before committing to a major repair. What specific diagnostic procedures should I run to confirm whether this is actually a head gasket failure versus other potential causes like a cracked head or block issue?

Looking for a systematic approach to pinpoint the exact problem before I start tearing into this engine. …more

Read answer

Engine Hard 4-6 hours 171 👍 0

Ford F53 7.5L RV Won't Start: Fuel Pump Relay Voltage Drop Fix

Woke up to my 1996 Ford F53 7.5L motorhome eating through my patience and wallet with this no-start issue that keeps coming back. It cranks strong but absolutely will not start, and I've been chasing this problem for weeks now. The engine ran fine for about 3-4 minutes one day, then just died and hasn't started since.

I've already done quite a bit of diagnostic work:
- Replaced PCM and distributor
- Fuel pump works when powered directly
- Battery is fully charged
- Checked fuses and relays
- PCM relay voltage drops from 12.2V to 9.3V with key on
- Fuel pump relay only shows 3.3V at pin 86 (should be 12V)
- Inertia switch tested at 1.7V at connector
- ANL 178 fusible link fluctuates between 0.3-0.6V

The engine will only start with starter fluid when the SPOUT is removed. I'm getting only 5.5V at the fuel pump connector.

Has anyone dealt with this specific issue on an F53 chassis? I really need to get this RV back on the road and I'm running out of ideas! …more

Read answer

Product Ranking 8 compared

Best RV Awnings & Accessories

4.5 (7,600 reviews)

Engine Easy N/A 164 👍 0

Ford V10 Triton Engine Maintenance Guide: EGR Delete vs Regular Service Tips

Spent years doing regular EGR maintenance on my old gas motorhome without issues — but this 2007 Fleetwood 31' Tioga with Ford V10 Triton has me second-guessing everything. I keep reading conflicting information about EGR delete procedures on V10 engines, and I'm worried I might make things worse if I mess with it.

Is the EGR delete modification actually necessary on this 2007 3-valve V10, or am I overthinking this? I don't want to void any warranties or create problems that weren't there before. Would I be better off just sticking to regular maintenance instead of modifications? I'm looking for reassurance that I'm taking the right approach to keep this engine running reliably for years to come. …more

Read answer

Engine Easy 1-2 hours inspection 148 👍 0

Ford E450 V10 Reliability: Expected Mileage and Longevity Guide for RV Owners

Nobody prepared me for staring at this 2018 Jayco Greyhawk 29MVP with Ford E450 chassis showing 54,000 miles and wondering if I'm looking at a money pit. The unit appears well-maintained with quality features including auto-leveling, fiberglass roof and nose, plus J-ride suspension. However, the odometer shows 54,000 miles, which exceeds my initial target range.

I need to assess whether this mileage represents significant wear on the E450/V10 drivetrain combination. What is the typical service life expectation for these engines when properly maintained? At what point should mileage become a primary concern versus overall mechanical condition? …more

Read answer

General Easy 20 min research 137 👍 0

How to Find Reliable RV Repair Shops: Expert Tips & Red Flags to Watch Out For

About every summer my 2004 Adventurer runs like a dream until temps hit 85°F, then it breaks down constantly and no shop can figure out why. The main slide out has been acting up with the HWH hydraulic system, and I honestly don't know enough to fix it myself.

I'm worried about getting taken advantage of since I don't really know what questions to ask or what warning signs to watch out for. I've heard horror stories about people paying huge bills for shoddy work. What's the best way to research and find a reliable shop? Are there specific things I should ask them before I commit to having work done?

Any guidance would be really appreciated - I just want to make sure I'm being smart about this and not walking into a bad situation. …more

Read answer

Engine Easy N/A 133 👍 0

Ford E-350 vs E-450 Chassis: RV Fuel Economy, Power & Weight Capacity

Last weekend I felt this awful engine strain and heard sluggish acceleration sounds while test-driving a 2017 Phoenix Cruiser #2351 with its E-350 chassis and V10 engine. I'll be doing extensive western touring through mountain and plains regions, which means substantial mountain grades and wind challenges. I'm comfortable driving slowly and want to understand two key things: 1) Will this E-350 chassis handle mountain grades without major issues, and 2) What's the real-world fuel consumption like? I plan to do an initial inspection this weekend, followed by a third-party mechanical review. I'm not overly concerned about fuel economy but want to understand the actual performance limitations. I'd appreciate insights from owners who have experience with similar touring conditions on an E-350 chassis. …more

Read answer

Slideouts Medium 1-2 hours 124 👍 0

RV Slide Out Won't Retract: Motor Runs But Won't Move - Fix

Planning to use the same motor running trick that saved my old Winnebago's slide out, but this new rig's slide won't budge at all. It extended just fine this morning, but now when I try to bring it back in, the motor sounds like it's working but the slide isn't budging at all. I can hear it running but zero movement.

I'm trying to figure out if this is a hydraulic problem or if I've got a cable system that's gone haywire. Could it be something simple like low fluid, or am I looking at broken cables? Don't want to mess around with it too much without knowing what I'm dealing with first. …more

Read answer

General Easy 15-30 min 119 👍 0

RV Windshield Washer System: Complete Maintenance Guide & Troubleshooting Tips

Somewhere between following three different YouTube tutorials, I managed to turn my RV's windshield washer repair into a sprinkler system that hits everything except the actual windshield. The specific issue I'm experiencing is fluid running back into the reservoir after each use, which means washer fluid isn't effectively hitting bugs before they dry and smear. I actually found a clever solution - using an aquarium air pump check valve from PetSmart for just $3.00. Sometimes it's these little fixes that make a big difference.

Sometimes the washer sprays like a garden sprinkler gone rogue, other times it dribbles like a leaky faucet. The fluid seems to have a mind of its own - either freezing up in cold weather or not hitting the windshield where it's supposed to.

I'm dealing with nozzles that spray everywhere except where the bugs are, a reservoir that I can never seem to locate when it's empty, and wipers that just smear everything around instead of actually cleaning. Could someone help me troubleshoot and confirm if my check valve solution might help? …more

Read answer

Slideouts Medium 2-3 hours 115 👍 0

RV Slide Out Moving Slowly? Complete Lubrication & Repair Guide [2024]

I tried everything I could think of, but after all that heavy rain last week, my slide out went from smooth operation to moving like molasses. It sounds like it's really struggling and straining, making these awful grinding noises that have me worried I'm going to break something expensive.

I've been reading that lubrication might be the answer, but I honestly don't know where to start. Should I be looking at the motor mechanism? The tracks? I've heard about hydraulic fluid but I'm not sure if my system is hydraulic or electric. I really need someone to walk me through what needs lubrication and what else I should check before this thing stops working completely!

Could you help me troubleshoot? Details that might help: Can you tell me the specific model of my RV and the type of slide out system it uses? …more

Read answer

Engine Hard Professional repair required 112 👍 0

Ford F53 V8 Engine Tapping Noise: Complete TSB 25-2200 Repair Guide for RV Owners

Since I replaced the valve cover gaskets on my 2022 motorhome's Ford F53 V8 yesterday, I'm still hearing that annoying tapping noise — did I miss something? I've been noticing this tapping or ticking sound when the engine is idling, and sometimes it seems to run a bit rough. I'm worried I might have a serious problem.

I found a Ford Technical Service Bulletin (TSB 25-2200, NHTSA ID 11018524) that might be related to my issue. The bulletin mentions potential camshaft and valve tappet wear causing ticking noises, rough performance, and diagnostic trouble codes P0301-P0308. According to the bulletin, repairs might even include a new long block.

Can someone help me understand what this TSB covers exactly? Does it apply to my specific year model, and what kind of repairs might be needed? I'm hoping this might be something covered under warranty since the RV is still pretty new to me.

Any guidance would be really appreciated - I'm still learning about all this mechanical stuff! …more

Read answer

Product Ranking 8 compared

Best RV Surge Protectors

4.6 (14,200 reviews)

Engine Medium 2-3 hours 106 👍 0

Ford F53 Chassis Firewall Wiring: Finding Brake LED Through-Holes

Opened up my 2022 Holiday Rambler 36DB for spring prep and once again I'm staring at my 2021 Ford F53 chassis firewall wondering where those brake LED through-holes are hiding. I need to run the brake indicator LED wire from my toad to the dashboard inside the motorhome, but I'm having trouble locating the best firewall penetration point.

Rather than drilling a new hole through the firewall (which I'd prefer to avoid for obvious reasons), I'm hoping to find an existing through-hole or grommet that I can utilize. I've heard that Ford F53 chassis typically have several factory access points, but I'm not sure exactly where to look or which ones would be most suitable for this type of low-voltage wiring installation.

Can anyone provide specific guidance on where to find existing firewall through-holes on the F53 chassis that would work well for routing brake indicator wiring? I want to make sure I'm using an appropriate location that won't interfere with existing systems and will provide a clean, professional installation. …more

Read answer

Engine Easy 15 minutes 105 👍 0

5 Star Tuner X4 for Ford V10 RV: Complete Performance & Upgrade Guide

Planning to tune my 2018 Ford 6.8L V10 RV but got quoted $800 for professional tuning and wondering if the 5 Star X4 is DIY-friendly. Specifically want to know about real-world performance improvements - does it actually improve throttle response and shift points? What about fuel economy gains?

Which of the 3 programs works best for RV towing? Is the investment worth it for better drivability or just hype? …more

Read answer

Propane Easy 15 min read 103 👍 0

RV Auto Hold Parking Brake: Complete Guide to Operation and Troubleshooting Basics

Woke up this morning and spotted my 1999 Damon Daybreak 3270's auto hold parking brake light blinking on the dash when it was perfectly fine yesterday. I'm still learning everything about motorhome systems and I'm confused about the auto hold parking brake feature.

The system doesn't seem to be working properly (barely holds at all), but honestly I'm not even sure I understand how it's supposed to operate in the first place. Is this something that engages automatically? Do I need to do something specific to activate it?

Could someone explain how these auto hold parking brake systems work on motorhomes, how to use them properly, and maybe some troubleshooting tips? I want to make sure I understand the basics before I start trying to fix anything. …more

Read answer

Engine Medium 2-3 hours 100 👍 0

Ford E-450 RV Shock Absorber Upgrade Guide: Bilstein 4600 vs Koni FSD

Before spending hundreds on new tires and suspension parts for my 2023 Ford E-450 Class C motorhome, the ride quality is still absolutely brutal. The RV is about 28 feet long and weighs approximately 14,500 pounds loaded. We use it primarily for family camping trips, but I also occasionally tow a small utility trailer with dirt bikes - probably 25% of our trips involve towing that extra 2,000-3,000 pounds.

I've been researching shock absorber upgrades and have narrowed it down to two main options that seem popular in the RV community: the Bilstein 4600 series and the Koni FSD (Frequency Selective Damping) shocks. I understand both are significant improvements over stock, but I'm trying to understand the practical differences between them for my specific setup and usage patterns.

What I really need to know is which option provides the best balance of ride comfort improvement, handling stability (especially when towing), and overall value for money on the E-450 chassis. I want to make sure I'm making the right choice since this is a fairly significant investment and I don't want to have buyer's remorse later. …more

Read answer

Loading more Q&A...

You've seen all 97 Q&A articles!