Results for "battery monitor"

Electrical Medium 2-6 hours 232 👍 1

ECM Low Battery Warning RV: Complete Diagnosis & Fix Guide

During a family trip, my 2005 Fleetwood Discovery 39S threw code 168-1 for low ECM battery voltage and went into full shutdown mode—is this dangerous with kids onboard? Engine cut out, transmission selector went dark, ABS warnings everywhere - the whole nine yards. Scared the heck out of me when it happened on the interstate!

I'm seeing this seems to be a thing with these diesel pushers, but I'm drowning in conflicting info online. Some say it's the chassis battery, others blame alternator issues, and I've even seen posts about ECM power supply problems on the Caterpillar engines. What's the actual step-by-step process to track this down? And more importantly, how do I fix it so it doesn't leave me stranded again? Really need a complete walkthrough of what causes this code and the proper repair approach. …more

Read answer

Engine Easy N/A 164 👍 0

Ford V10 Triton Engine Maintenance Guide: EGR Delete vs Regular Service Tips

Spent years doing regular EGR maintenance on my old gas motorhome without issues — but this 2007 Fleetwood 31' Tioga with Ford V10 Triton has me second-guessing everything. I keep reading conflicting information about EGR delete procedures on V10 engines, and I'm worried I might make things worse if I mess with it.

Is the EGR delete modification actually necessary on this 2007 3-valve V10, or am I overthinking this? I don't want to void any warranties or create problems that weren't there before. Would I be better off just sticking to regular maintenance instead of modifications? I'm looking for reassurance that I'm taking the right approach to keep this engine running reliably for years to come. …more

Read answer

Electrical Medium 45 minutes 154 👍 0

RV Backup Camera Not Working? Complete Troubleshooting Guide

Spent all winter enjoying a perfectly working RV backup camera, but the second temperatures hit 85 degrees outside, my screen goes completely black. My wireless backup camera decided to give me the silent treatment right when I need it most. The monitor is just sitting there mocking me with a "no signal" message, and honestly, my spatial awareness isn't what it used to be.

The camera worked fine on our last camping trip (when I only needed to back up twice), but now that I'm trying to navigate tight campground spots, it's gone completely dark. I'm dealing with a wireless system, so I know there are more things that can go wrong than with a wired setup.

Before I resort to using my spouse as a very expensive parking sensor, what's the best way to troubleshoot this? I'm hoping it's something simple like a loose connection rather than having to explain to my insurance company why there's a picnic table embedded in my bumper. …more

Read answer

Product Ranking 8 compared

Best RV Water Heaters

4.4 (6,800 reviews)

Ac Refrigeration Medium 2-3 hours 133 👍 0

Norcold 1210 Not Cooling: No Error Codes Troubleshooting Guide

During my morning RV check I spotted my Norcold 1210 completely dead with zero cooling that was running perfectly yesterday with no error codes. Unit appears to be operating normally with no error codes displayed, but it's not cooling properly. Interior temperature is staying above 50 degrees. Thermistor has been tested and checks out fine. What else should I look at? …more

Read answer

Electrical Medium 30 min read 131 👍 0

RV DC Electrical System: Expert Guide to 12 Volt Systems

Opened my RV this morning to find the 12V system going haywire — lights dimming randomly, fans slowing down, and the inverter shutting off despite full batteries.

Specifically, I need to understand the fundamentals of RV batteries - different types, proper sizing, charging requirements, and maintenance. I'm also confused about DC wiring best practices, what gauge wire to use for different applications, how to properly route and protect circuits, and where fuses and breakers should go. Voltage monitoring is another area where I'm lost - I see all these battery monitors and don't know what I actually need or how to interpret the readings.

I'm also planning some system upgrades down the road like adding solar or upgrading to lithium batteries, so I'd love to understand how all these components work together and what I need to consider for future modifications. Is there a comprehensive resource that covers all aspects of RV DC electrical systems from batteries and wiring through monitoring and upgrades? …more

Read answer

General Hard 45-60 min 131 👍 0

How to Remove Firefly RV Control Panel: Complete DIY Guide (2024)

Our 2019 Fleetwood Discovery LXE has a malfunctioning Firefly multiplex control panel that needs to be completely removed. I've been putting this off for months because I keep hearing horror stories about people cracking their panels or damaging the surrounding woodwork during removal.

I need to access the back of the unit for some electrical work, but I'm honestly terrified of breaking something expensive. The panel seems to be mounted flush with no obvious screws or clips visible from the front. I've searched everywhere but can't find a complete walkthrough that covers the preparation, actual removal process, and how to get everything back together properly.

Can someone please provide a detailed DIY guide that covers all the steps? I'm willing to take my time and do this right - I just need to know the proper technique so I don't end up with a broken control panel or damaged wall. …more

Read answer

Solar Batteries Medium 2-4 hours 128 👍 0

How to Upgrade Progressive Dynamics Converter for Lithium RV Batteries Safely

Got a 15-year-old Progressive Dynamics converter that's starting to throw fault codes with my new lithium setup — worth upgrading or try making it work? I have a 2006 Lance 915 cabover that I recently upgraded with 2-200 watt Bouge solar panels and 2-100ah SOK lithium batteries.

The problem is I'm still running the original Progressive Dynamics converter charger that came with the RV, and I've learned it's not designed for lithium batteries. I'm worried about damaging my new battery investment.

What are my options for upgrading? I'm not sure if I need to replace the whole converter unit or if there's some kind of upgrade kit available. Any advice would be really appreciated since I don't want to mess this up! …more

Read answer

Solar Batteries Medium 45 minutes 126 👍 0

RV Inverter Beeping 3 Times Then Shutting Off: Complete Troubleshooting Guide

Standing next to my RV watching what started as occasional inverter beeps last month escalate into exactly three beeps and complete shutdown after just minutes. My multimeter shows the batteries at 12.8V when I check them, so they seem fine.

I'm worried there might be something more serious going on that I'm missing. Could this be a safety issue? What would cause an inverter to shut itself off like this even when the battery voltage looks normal? I don't want to keep trying to restart it if there's a risk of damaging the system or creating a safety hazard. …more

Read answer

Ac Refrigeration Medium 2-3 hours for diagnosis, professional repair likely needed 122 👍 0

Coleman Mach AC Fuse Blows With Battery On - Rockwood Fix

Found out the hard way that the previous owner of my 2019 Rockwood Minilite 2509s left me with a Coleman Mach AC that blows fuses instantly when I flip on the battery. The AC fuse blows instantly when I turn on the battery disconnect, before the AC is even activated. The fuse literally blows before it's completely seated in the panel.

This began two weeks ago without warning - the system had been functioning normally prior to this. Initial fuse replacement provided temporary operation, but the problem returned on the next trip with the fuse already blown upon arrival.

Given the immediate fuse failure with just battery power connected, what type of electrical fault would cause this symptom pattern in a Coleman Mach unit, and what's the most likely location of the problem in the AC circuit? …more

Read answer

Solar Batteries Medium 45 minutes 119 👍 0

RV MPPT Solar Controller E1 Error Code: Causes & Fixes

Halfway through troubleshooting my MPPT solar charge controller's E1 error — would this be covered under warranty, or am I stuck paying out-of-pocket? The controller was working fine for months, but now it's completely stopped charging my batteries and just displays this E1 fault code on the screen.

From what I've read, this could be related to battery over-voltage conditions or possibly some kind of wiring fault, but I want to make sure I understand all the potential causes before I start troubleshooting. I'm comfortable doing basic electrical work myself, but I also want to know when this might be something that requires professional attention for safety reasons.

Can someone provide a detailed breakdown of what the E1 error specifically indicates, walk me through the proper diagnostic steps to identify the root cause, and explain the repair process? I'd especially appreciate guidance on how to safely approach this troubleshooting and what warning signs would indicate I should call in an expert instead of attempting the fix myself. …more

Read answer

Solar Batteries Medium 2-4 hours 113 👍 0

How to Upgrade Your RV Converter Charger for Lithium Batteries with Gentle Care

Halfway through planning our three-week cross-country trip next month, I realized my PD4560 60-amp converter/charger won't properly handle the lithium batteries I'm installing. My existing Progressive Dynamics unit obviously isn't designed for LiFePO4 batteries - I can use boost mode to charge them up, but I know that's not ideal for battery longevity.

I just purchased a 30 amp generator and I'm wondering if it will have enough capacity to handle not just my current charger, but potentially a larger lithium-compatible unit. I'm considering upgrading to a 75 or even 90 amp charger to reduce charging times, but I need to make sure my generator can handle the load. I'm trying to figure out the actual AC amp draw of these higher-capacity chargers and whether my 30 amp generator will be sufficient.

What are the best lithium-compatible converter/charger options that would work with my generator setup, and how do I properly size the charger capacity to match my lithium battery bank? …more

Read answer

Product Ranking 8 compared

Best RV Sewer Hoses & Kits

4.6 (31,500 reviews)

Solar Batteries Medium 2-4 hours 109 👍 0

RV Battery Draining Overnight? Find & Fix Parasitic Drain

The day after I installed that new solar charge controller last month, my RV batteries started mysteriously draining from fully charged to completely dead overnight. I've already confirmed that all visible lights, fans, and appliances are turned off, and I've switched off the main interior power, but something is still drawing power continuously. I understand this is likely a parasitic drain where some component or circuit is staying energized when it shouldn't be, but I'm not sure how to systematically track down which specific circuit is causing the problem. I have a basic multimeter but I'm not entirely sure about the proper methodology for testing each circuit individually to isolate where exactly the power draw is coming from. What's the step-by-step process for using a multimeter to methodically work through the electrical system, starting from the main disconnect and testing individual fuses or circuits until I can pinpoint the exact source of this parasitic drain? …more

Read answer

Electrical Medium 3-4 hours 105 👍 0

Sony VCB-62MH RV Camera Monitor Replacement: Complete Installation Guide for RV Coaches

Already cleared my Saturday schedule to swap out this Sony VCB-62MH RV camera monitor — what tools and prep work should I have ready beforehand? The Sony VCB-62MH rear view camera monitor in my 2008 Phaeton finally died, and of course Sony doesn't make them anymore. I've been searching everywhere for a replacement but everything I find is either way too big for the existing dash opening or doesn't work with the Sony cameras that are still perfectly fine.

I really don't want to replace the entire camera system - that would cost a fortune and the cameras work great. I just need the monitor replaced. Has anyone successfully found a workaround that reuses the existing Sony cameras and wiring? I'd love to keep the automatic switching feature for the side cameras when using turn signals if possible, but at this point I just need something that works and fits in the dash opening. …more

Read answer

Electrical Medium 2-4 hours 105 👍 0

How to Protect Your RV Alternator When Charging Lithium Batteries: DC-

Tried everything my neighbor did to charge his LiFePO4 batteries but mine keeps frying the alternator while his works flawlessly — what's different? I want to install a temperature sensing device that can interrupt charging by opening the solenoid between chassis and house charging systems if the alternator gets too hot. I'm looking to spec out components and understand the installation process, and I'm open to hearing why this might not be a good approach. My goal is preventing alternator overheating when these lithium batteries draw high current compared to my old flooded or AGM batteries. I'm looking for technical feedback and am totally open to critique. …more

Read answer

Engine Easy 15 minutes 105 👍 0

5 Star Tuner X4 for Ford V10 RV: Complete Performance & Upgrade Guide

Planning to tune my 2018 Ford 6.8L V10 RV but got quoted $800 for professional tuning and wondering if the 5 Star X4 is DIY-friendly. Specifically want to know about real-world performance improvements - does it actually improve throttle response and shift points? What about fuel economy gains?

Which of the 3 programs works best for RV towing? Is the investment worth it for better drivability or just hype? …more

Read answer

Loading more Q&A...

You've seen all 139 Q&A articles!