Results for "awning arm"

Exterior Hard 2-8 hours for temporary fix, 1-5 days for permanen 213 👍 1

RV Sidewall Blistering & Delamination Repair Guide 2024

According to three different RV shops, fixing my bubbling sidewall delamination will cost thousands, but I'm wondering if tackling this DIY repair myself is actually feasible. My 2004 Itasca Sunova has decided to sprout some lovely blisters on the right sidewall - two beauties that are about 12-14 inches long and 3-4 inches wide, running vertically right behind the awning arm. Perfect timing since we're currently on the road living our best RV life!

I'm pretty sure water snuck in somewhere (probably from the roof rail or that shower skylight we never use), and now my RV looks like it's got chicken pox. Since we can't exactly pull into the nearest RV surgeon's office, I need to know: what can I do right now to stop this from getting worse, and what's involved in actually fixing this mess properly? I'm hoping there's some kind of emergency containment plan that doesn't involve duct tape and prayers! …more

Read answer

Exterior Medium 45 minutes 106 👍 0

RV Awning Won't Extend or Retract: Complete Troubleshooting & Repair Guide

This power awning manual says hold the extend button for 3 seconds, but mine's completely dead and won't budge no matter how long I hold it. When I hit the extend button, it moves out maybe 6-8 inches and then immediately retracts on its own. I have to turn the power switch off and back on each time to get even that little bit of movement.

I'm hesitant to keep forcing it since I don't want to burn out the motor or make whatever's wrong even worse. Could this be an electrical issue with low voltage, or maybe the tracks are too dirty? I've also heard about limit switches causing problems but I'm not sure how to check those safely.

What are the most common causes when an awning does this short extend-then-retract cycle? I want to start with the safest troubleshooting steps before calling a repair shop. …more

Read answer

General Medium Varies by issue 101 👍 0

How to Fix RV Slide Out Topper Awning Problems: Common Issues and Solutions for Smooth Operation

Before buying our first RV, I never even knew slide topper awnings existed, and now ours is acting up and I'm completely lost. We're having all three slide toppers professionally replaced next week, but I'm honestly worried we'll end up with the same problems all over again if they're not installed properly.

I've been reading horror stories about misaligned toppers, wrong spring tension, and fabric bunching up during slide operation. Since this is costing us a pretty penny, I really need to know what specific things I should insist the installer check and test before they leave. What are the critical adjustments that need to be made during installation to prevent these common topper problems from happening again? …more

Read answer

Product Ranking 8 compared

Best RV Water Heaters

4.4 (6,800 reviews)

Exterior Medium 2-3 hours 100 👍 0

Dometic 8300 Series Awning Torsion Assembly Replacement Guide (834AV44

Already burned through three Dometic 8300 torsion assemblies in six months and I'm hemorrhaging money as a new RV owner. The model number is 834AV44.138 and I'm not even sure what series this is - is it part of the 8300 series maybe?

The torsion assembly lever broke off and I can't seem to find exact replacement parts anywhere. I'm wondering if there are compatible parts from other Dometic awning models that would work with mine? I don't want to order the wrong thing and make the problem worse. Any guidance on finding the right replacement parts or temporary fixes would be really helpful! …more

Read answer

Exterior Hard Varies 93 👍 0

Carefree RV Awning Spring and Arm Replacement Guide - Model Compatibility Tips

According to my mechanic, fixing my 18-foot Carefree of Colorado awning's busted spring mechanism will cost $800, but I'm wondering if I can tackle this myself since there's zero tension left. Along with that, one of the support arms that helps transition the awning from travel position to deployed position is also damaged and needs replacement.

Before I start ordering parts or calling repair shops, I'm trying to understand how Carefree's replacement parts work. Are their springs and support arms universal components that work across different awning sizes and models, or does Carefree use proprietary parts that are specific to each awning series? I've been browsing their website but the parts compatibility information isn't very clear about what fits what.

I'd really appreciate any guidance on part compatibility and whether this is something I should tackle myself or leave to a professional. The spring replacement in particular seems like it might be tricky given the tension involved. …more

Read answer

Exterior Medium 2-4 hours 92 👍 0

RV Awning Repair vs Replacement: When to Fix Torn Fabric

Apparently my RV manual says to replace the entire awning when the fabric tears, but everyone online seems to just patch or swap the fabric instead. My 2020 motorhome's awning fabric has developed a few tears - some small ones that are maybe 4-5 inches, but also a couple larger rips. The fabric also feels kind of stiff and brittle in places, especially where it's been exposed to the most sun.

I'm trying to figure out if I should attempt repairs or just bite the bullet and replace the fabric entirely. The frame itself seems to be in decent shape, so I think I'd only need new fabric rather than a whole new awning system. I've seen repair tapes advertised but I'm not sure if they actually work or how long they last.

What's the general rule of thumb for when awning fabric can be repaired versus when replacement makes more sense? And if I do need to replace just the fabric, what should I expect to pay for something decent? Thanks for any advice - I really don't want to make the wrong choice here! …more

Read answer

Exterior Medium 45 minutes 87 👍 0

Carefree HD Awning Stabilizer Review: Box Awning Install

Between the wind gusts hitting camp right now, I can see my box awning doing this wild flapping dance that's making me nervous. The Carefree HD Awning Stabilizer appears to be designed specifically for this application, but I need technical assessment of its actual performance characteristics.

Primary concerns are bounce reduction effectiveness, compatibility across different box awning manufacturers, and installation complexity for self-service repair. Wind stability is the critical performance metric - current setup shows significant sway at wind speeds above 10-15 mph.

Looking for factual analysis of this stabilizer's capabilities on box awning configurations, particularly regarding installation requirements and real-world wind resistance improvements. …more

Read answer

Slideouts Medium 1-2 hours to diagnose 87 👍 0

How to Fix RV Slide Out Water Leak from Bottom - Wiper Seal Repair Guide for 2023 Models

About two weeks into living in my 2023 Forest River Forester MBS2401B and this slide out I've never dealt with before is leaking water from the bottom. The leak occurs specifically when the slide is in the retracted position during wind-driven rain events. Water is penetrating at floor level beneath the dinette area of the full wall slide assembly.

I have verified that all visible seals appear to be properly seated and the topper awning shows no obvious damage. Given that this is occurring on a current model year unit, I need to understand if this represents a manufacturing defect covered under warranty, and what specific component is likely causing the failure at the bottom of the slide mechanism. …more

Read answer

Exterior Medium 2-4 hours 84 👍 0

RV Awning Water Damage: Complete Repair vs Replace Guide (2024)

Tried getting quotes for my water-damaged RV awning and the $800 replacement estimate has me wondering if I can tackle this repair myself instead. Water pooled on it during a light rain because I had the angle wrong, and now something seems to be wrong with the spring mechanism - it's not retracting properly anymore.

I'm afraid to mess with it further without knowing what I'm dealing with. How can I safely assess whether the fabric, spring, or roller tube is damaged? I need to know if this is something I can repair or if I'm looking at a complete replacement. I don't want to make things worse by trying the wrong approach. …more

Read answer

Exterior Medium 45 minutes 81 👍 0

RV Electric Awning Won't Retract Fully: Fix Bunching and Alignment Issues with Easy Steps

Woke up to my electric awning stuck 2 feet short of fully retracting, now I'm standing in the RV parts store staring at motors and alignment tools with zero clue which one I need. During the retraction process, I've observed the fabric bunching up significantly on one side while the opposite side appears to retract normally.

The motor continues to run when this occurs, suggesting it's not a power issue. I suspect this may be related to fabric tension irregularities or potential misalignment in the awning arm mechanism, but I need to confirm the root cause and understand the proper correction procedure.

What are the most likely causes of this partial retraction with uneven fabric bunching, and what systematic troubleshooting steps should I follow to resolve this issue? …more

Read answer

Exterior Medium 2-3 hours with help 74 👍 0

Fix Detached RV Awning Arm After Storm - Removal Guide

Finally discovered my RV awning arm completely detached and hanging loose after yesterday's storm - is this dangerous with kids running around the campsite? The rear arm completely detached during high winds and the whole thing partially deployed while I was driving. I managed to push it back in and tape it down temporarily, but it won't latch properly and keeps wanting to roll back out.

I've tried everything I can think of from ground level, but I can't reach high enough to see what's actually broken up there. The arm just won't stay in position no matter what I do. I'm worried about driving home with it like this - it could deploy again or cause damage to the RV.

I have help coming with ladders tomorrow, but I need to know my options. Is this something that can be secured well enough for travel, or am I looking at having to remove the entire awning assembly? I really need to get this resolved so I can get home safely! …more

Read answer

Loading more Q&A...

You've seen all 11 Q&A articles!