Results for "12V problems"

Electrical Medium 2-6 hours 301 👍 4

RV Electrical Problems: 12V & 120V Troubleshooting Guide 2024

Around $500 in parts later — replaced the main breaker, cleaned all connections, checked the transfer switch — my 2007 Holiday Rambler Admiral SE still won't recognize shore power.

I'm pretty sure 110V is making it to the rig since I can measure it, but somewhere between the plug and my appliances, something's not happy. Energy management panel is dark too. What's the logical troubleshooting order here? I keep hearing about transfer switches and breaker panels but honestly don't know where to start without making things worse! …more

Read answer

Engine Medium 2-6 hours 289 👍 1

Onan 5500 Generator Problems: Complete Repair Guide 2024

Spent three hours testing my 2014 Hurricane's Onan 5500 gen getting 11.8 volts output when every manual says it should be 12+ volts! Here's the weird part - when I disconnect the remote harness, the generator fires right up and purrs like a kitten. But the second I plug that remote connection back in, boom - both the remote start light AND the generator start light come on, and then... nothing. Won't start at all.

The really bizarre symptom is this chattering from the fuel pump when the remote is connected. I can literally feel the fuel line jumping around when I put my hand on it. It's like the pump is having some kind of seizure or something!

I'm guessing this has to be some kind of electrical issue between the control board and the remote system, but I've never seen anything quite like this before. Anyone dealt with this specific combo of symptoms on an Onan 5500? Really hoping there's a known fix because pulling this thing out of the RV again would be a major pain! …more

Read answer

Engine Hard 4-6 hours 171 👍 0

Ford F53 7.5L RV Won't Start: Fuel Pump Relay Voltage Drop Fix

Woke up to my 1996 Ford F53 7.5L motorhome eating through my patience and wallet with this no-start issue that keeps coming back. It cranks strong but absolutely will not start, and I've been chasing this problem for weeks now. The engine ran fine for about 3-4 minutes one day, then just died and hasn't started since.

I've already done quite a bit of diagnostic work:
- Replaced PCM and distributor
- Fuel pump works when powered directly
- Battery is fully charged
- Checked fuses and relays
- PCM relay voltage drops from 12.2V to 9.3V with key on
- Fuel pump relay only shows 3.3V at pin 86 (should be 12V)
- Inertia switch tested at 1.7V at connector
- ANL 178 fusible link fluctuates between 0.3-0.6V

The engine will only start with starter fluid when the SPOUT is removed. I'm getting only 5.5V at the fuel pump connector.

Has anyone dealt with this specific issue on an F53 chassis? I really need to get this RV back on the road and I'm running out of ideas! …more

Read answer

Product Ranking 8 compared

Best RV Surge Protectors

4.6 (14,200 reviews)

Electrical Medium 45 minutes 154 👍 0

RV Backup Camera Not Working? Complete Troubleshooting Guide

Spent all winter enjoying a perfectly working RV backup camera, but the second temperatures hit 85 degrees outside, my screen goes completely black. My wireless backup camera decided to give me the silent treatment right when I need it most. The monitor is just sitting there mocking me with a "no signal" message, and honestly, my spatial awareness isn't what it used to be.

The camera worked fine on our last camping trip (when I only needed to back up twice), but now that I'm trying to navigate tight campground spots, it's gone completely dark. I'm dealing with a wireless system, so I know there are more things that can go wrong than with a wired setup.

Before I resort to using my spouse as a very expensive parking sensor, what's the best way to troubleshoot this? I'm hoping it's something simple like a loose connection rather than having to explain to my insurance company why there's a picnic table embedded in my bumper. …more

Read answer

Electrical Medium 30 min read 131 👍 0

RV DC Electrical System: Expert Guide to 12 Volt Systems

Opened my RV this morning to find the 12V system going haywire — lights dimming randomly, fans slowing down, and the inverter shutting off despite full batteries.

Specifically, I need to understand the fundamentals of RV batteries - different types, proper sizing, charging requirements, and maintenance. I'm also confused about DC wiring best practices, what gauge wire to use for different applications, how to properly route and protect circuits, and where fuses and breakers should go. Voltage monitoring is another area where I'm lost - I see all these battery monitors and don't know what I actually need or how to interpret the readings.

I'm also planning some system upgrades down the road like adding solar or upgrading to lithium batteries, so I'd love to understand how all these components work together and what I need to consider for future modifications. Is there a comprehensive resource that covers all aspects of RV DC electrical systems from batteries and wiring through monitoring and upgrades? …more

Read answer

Solar Batteries Medium 1-2 hours 120 👍 0

Xantrex Freedom X 1200 Inverter Low Battery Warning: Critical 11.2V Fix Guide

Walked into my new RV and discovered the previous owner left the Xantrex Freedom X 1200 inverter constantly throwing critical 11.2V low battery warnings. My Xantrex Freedom X 1200 inverter is displaying warning indicators on the panel, and I'm seeing some concerning voltage readings that have me worried about potential damage to my electrical system.

Here's the complete situation: My house battery is reading 11.2 volts, while the chassis battery shows 13.1 volts. The inverter panel is lit up with what I assume are low voltage warnings. I've been noticing the interior lights dimming significantly, especially when trying to run any appliances through the inverter. To make matters worse, it's currently overcast and getting dark, so my solar panels aren't generating any meaningful charge to help recover the battery.

I'm particularly concerned because I know lead-acid batteries can be permanently damaged if they're discharged too deeply. The voltage reading of 11.2V seems critically low to me, but I want to understand exactly how urgent this situation is and what my immediate next steps should be. Should I be looking at shore power connection, generator use, or is there something wrong with my charging system that caused this in the first place? I need to know both the immediate fix and what might have caused this failure. …more

Read answer

Electrical Easy 30 minutes 120 👍 0

RV 12V Lights Dimming: Complete Troubleshooting Guide

My neighbor insists it's the converter, the RV dealer swears it's bad wiring, and every YouTube video claims it's a dying battery—but my 12V ceiling lights keep dimming! One evening they're blazing bright like a casino, the next morning they're giving off all the enthusiasm of a sleepy firefly.

I've already checked my batteries, and they seem to be charging fine and in good shape. The converter is still humming and its fan is running normally. I'm pretty sure this isn't some fancy mood lighting feature I accidentally activated (though knowing my tech skills, anything's possible). The dimming seems totally random - sometimes they're fine, sometimes they look like they're on their last legs.

I've got a basic multimeter that I pretend to know how to use, but I'm not sure where to even start poking around. As a bonus weirdness, some of my under-cabinet light switches and the wall switch for the ceiling lights are getting really hot. Anyone know what typically causes this whole disco light show situation with 12V lighting systems? …more

Read answer

Propane Medium 45 minutes 118 👍 0

RV Gas Detector Beeps Every Minute at Night - How to Fix

Before my wife mentioned it, I had no idea our RV gas detector was beeping every single minute from 7PM to 7AM—now it's driving me absolutely crazy. It only does this during nighttime hours - never during the day. I'm plugged into shore power with 4 batteries (2 coach, 2 engine). What would cause this specific timing pattern? Is it actually detecting gas or is something else going on with the detector itself? …more

Read answer

Solar Batteries Medium 45 minutes 118 👍 0

RV MPPT Solar Controller E1 Error Code: Causes & Fixes

Halfway through troubleshooting my MPPT solar charge controller's E1 error — would this be covered under warranty, or am I stuck paying out-of-pocket? The controller was working fine for months, but now it's completely stopped charging my batteries and just displays this E1 fault code on the screen.

From what I've read, this could be related to battery over-voltage conditions or possibly some kind of wiring fault, but I want to make sure I understand all the potential causes before I start troubleshooting. I'm comfortable doing basic electrical work myself, but I also want to know when this might be something that requires professional attention for safety reasons.

Can someone provide a detailed breakdown of what the E1 error specifically indicates, walk me through the proper diagnostic steps to identify the root cause, and explain the repair process? I'd especially appreciate guidance on how to safely approach this troubleshooting and what warning signs would indicate I should call in an expert instead of attempting the fix myself. …more

Read answer

Exterior Medium 30-45 minutes 113 👍 0

How to Test RV Door Magnetic Switch - Electric Steps Fix

Three steps this morning to my RV and noticed my electric steps weren't extending like they did perfectly fine yesterday. I've already verified that I have 12VDC at the 4-pin connector, and I even tried swapping in a different control module, but still nothing happens when I open the door.

Everything points to the door magnetic switch being the issue, but I'm honestly nervous about testing electrical components - I don't want to damage anything or create a safety hazard. Is there a safe way to test the magnetic switch with a multimeter? I want to make sure I'm doing this right before I start poking around with test leads. …more

Read answer

Solar Batteries Medium 2-4 hours 109 👍 0

RV Battery Draining Overnight? Find & Fix Parasitic Drain

The day after I installed that new solar charge controller last month, my RV batteries started mysteriously draining from fully charged to completely dead overnight. I've already confirmed that all visible lights, fans, and appliances are turned off, and I've switched off the main interior power, but something is still drawing power continuously. I understand this is likely a parasitic drain where some component or circuit is staying energized when it shouldn't be, but I'm not sure how to systematically track down which specific circuit is causing the problem. I have a basic multimeter but I'm not entirely sure about the proper methodology for testing each circuit individually to isolate where exactly the power draw is coming from. What's the step-by-step process for using a multimeter to methodically work through the electrical system, starting from the main disconnect and testing individual fuses or circuits until I can pinpoint the exact source of this parasitic drain? …more

Read answer

Product Ranking 8 compared

Best RV Batteries

4.5 (15,400 reviews)

Ac Refrigeration Medium 4-6 hours 107 👍 0

RV 3-Way to 12V Compressor Fridge Replacement: Cut Power Use 80%

Three weeks into owning this RV and the previous owner left me with a power-hungry Norcold 3-way absorption fridge that's absolutely demolishing my 600AH battery bank daily.

I keep hearing people rave about switching to 12V compressor fridges like the Dometic DMC4101, claiming they'll solve all my power woes. But here's the thing - everyone says "it uses way less power" but nobody gives me actual numbers! I need the cold hard facts: exactly how much power will I save making this switch? Will it really make that big of a difference, or am I just trading one expensive problem for another?

Please tell me someone has real-world experience with the power consumption difference between these fridge types! …more

Read answer

Electrical Medium 3-4 hours 105 👍 0

Sony VCB-62MH RV Camera Monitor Replacement: Complete Installation Guide for RV Coaches

Already cleared my Saturday schedule to swap out this Sony VCB-62MH RV camera monitor — what tools and prep work should I have ready beforehand? The Sony VCB-62MH rear view camera monitor in my 2008 Phaeton finally died, and of course Sony doesn't make them anymore. I've been searching everywhere for a replacement but everything I find is either way too big for the existing dash opening or doesn't work with the Sony cameras that are still perfectly fine.

I really don't want to replace the entire camera system - that would cost a fortune and the cameras work great. I just need the monitor replaced. Has anyone successfully found a workaround that reuses the existing Sony cameras and wiring? I'd love to keep the automatic switching feature for the side cameras when using turn signals if possible, but at this point I just need something that works and fits in the dash opening. …more

Read answer

Engine Easy 15 minutes 105 👍 0

5 Star Tuner X4 for Ford V10 RV: Complete Performance & Upgrade Guide

Planning to tune my 2018 Ford 6.8L V10 RV but got quoted $800 for professional tuning and wondering if the 5 Star X4 is DIY-friendly. Specifically want to know about real-world performance improvements - does it actually improve throttle response and shift points? What about fuel economy gains?

Which of the 3 programs works best for RV towing? Is the investment worth it for better drivability or just hype? …more

Read answer

Slideouts Medium 1-2 hours 103 👍 0

Fleetwood Bounder Slide Out Reset: Fix Lost Stop Points & Controller Issues

Slide out lost its stop points during a power surge at the campground and now it extends way too far and retracts too deep. Fleetwood Bounder forum says I need to reset the controller but the process involves running the slide to its limits and I'm afraid of damaging the mechanism. …more

Read answer

Loading more Q&A...

You've seen all 113 Q&A articles!