Results for "safety sensor"

Engine Medium varies 1,803 👍 1

Newmar Motorhome Rough Ride Fix: Suspension & Air Pressure

Noticed my 2013 Newmar still rides incredibly rough through every crack and pothole even after replacing all six air bags. The ride height was never adjusted after the air bag replacement, and I'm worried I might be causing more damage or creating a safety hazard.

I upgraded from a Super C expecting a much smoother ride with the air suspension system, but this feels just as jarring. Am I missing something critical with the suspension setup? Could improper air pressure or ride height settings be causing this rough ride, and what other components should I be concerned about? I don't want to make things worse by continuing to drive it if there's a fundamental issue I'm overlooking. …more

Read answer

Engine Hard 4-6 hours 509 👍 0

Ford F53 7.5L RV Won't Start: Fuel Pump Relay Voltage Drop Fix

Woke up to my 1996 Ford F53 7.5L motorhome eating through my patience and wallet with this no-start issue that keeps coming back. It cranks strong but absolutely will not start, and I've been chasing this problem for weeks now. The engine ran fine for about 3-4 minutes one day, then just died and hasn't started since.

I've already done quite a bit of diagnostic work:
- Replaced PCM and distributor
- Fuel pump works when powered directly
- Battery is fully charged
- Checked fuses and relays
- PCM relay voltage drops from 12.2V to 9.3V with key on
- Fuel pump relay only shows 3.3V at pin 86 (should be 12V)
- Inertia switch tested at 1.7V at connector
- ANL 178 fusible link fluctuates between 0.3-0.6V

The engine will only start with starter fluid when the SPOUT is removed. I'm getting only 5.5V at the fuel pump connector.

Has anyone dealt with this specific issue on an F53 chassis? I really need to get this RV back on the road and I'm running out of ideas! …more

Read answer

Electrical Medium 2-4 hours 410 👍 0

Protect Your RV Alternator When Charging Lithium

Tried everything my neighbor did to charge his LiFePO4 batteries but mine keeps frying the alternator while his works flawlessly — what's different? I want to install a temperature sensing device that can interrupt charging by opening the solenoid between chassis and house charging systems if the alternator gets too hot. I'm looking to spec out components and understand the installation process, and I'm open to hearing why this might not be a good approach. My goal is preventing alternator overheating when these lithium batteries draw high current compared to my old flooded or AGM batteries. I'm looking for technical feedback and am totally open to critique. …more

Read answer

Product Ranking 8 compared

Best RV Water Heaters

4.4 (6,800 reviews)

Engine Easy 15 minutes to inspect 353 👍 0

Michelin RV Tire Age: Inspect After 5 Years, Replace by 10

Called three different tire shops this month about my 2020 Newmar Ventana's Michelin 275/70R22.5 tires and all want them replaced just for being 6 years old despite perfect tread. I'm meticulous about tire maintenance - I check air pressure religiously before and after every trip, whether it's a short weekend getaway or an extended cross-country journey like the 5000-mile trip I just completed.

Despite my careful maintenance routine, I experienced a blowout on the right rear inside tire during the final leg of that recent long trip. When the roadside service technician came out to help, he recommended replacing all six tires specifically because of their age, even though the remaining tires still have plenty of tread depth and appear to be in excellent condition visually.

This has me confused because I've heard conflicting advice from other RV owners - some say well-maintained motorhome tires can safely last up to 10 years, while others insist on much shorter replacement intervals. I'm trying to understand what the actual safety guidelines are for RV tire replacement based on age versus tread wear. Should I really replace tires that still look good just because of when they were manufactured? What's the real story on how tire age affects safety, and how do I properly check the manufacturing date to make this decision? …more

Read answer

Engine Medium 2-4 hours diagnosis 351 👍 0

RV Engine Stalling & Transmission Issues - Diagnosis Help

Replaced multiple parts but I'm still standing in the auto parts store aisle staring at diagnostic tools with no clue which one I actually need for my RV's stalling and transmission issues. When I'm cruising and let off the gas, sometimes the RPMs drop like a rock, other times they just hang there until I slow down more. That's weird enough, but here's the real kicker - every now and then the whole engine just dies on me when I'm rolling up to a stop sign or red light. Maybe happens twice in 600 miles or so, so it's not constant but definitely not normal either.

I'm wondering if these two issues are connected somehow? Like could whatever's causing the stalling also be messing with how the transmission acts when I let off the throttle? Really hoping someone has seen this combo before because I'm in Germany and finding RV-specific help is tough.

I'm looking for any insights from folks who might know what could cause this - hoping to get to the bottom of this before it becomes a bigger problem! …more

Read answer

Propane Hard 2-4 hours 343 👍 0

How to Wire Girard Tankless Water Heater: Complete DSI Suburban Replacement Guide

Ripping out my old Suburban water heater to install a Girard tankless but the wiring is completely different — DSI ignition board, different voltage requirements, and the old thermostat wiring doesn't match up. Need a clear wiring diagram for this swap. …more

Read answer

Plumbing Medium 1-2 hours 315 👍 0

RV Grey Water Tank Clogged? 7 Proven Solutions to Clear Blockages Fast

Found out my RV service tech wants $800+ to replace the entire grey water system on my 2007 RV for an intermittent blockage that seems fixable. It doesn't seem to matter if we're level or not - it's completely random.

I've tried using a high suction shop vac and even attempted snaking it, but I'm nervous about forcing things and making the problem worse. I suspect it might be a manufacturing plug that fell into the tank, but I'm not sure. I found one solution with a reverse flush valve that seems to work temporarily, but I'm concerned about the underlying cause.

What are the safest and most proven methods to diagnose and fix these random grey water blockages? I don't want to damage the tank or create bigger problems, but this unpredictable draining is driving me crazy. Are there specific cleaning products or techniques that actually work without risking harm to the system? …more

Read answer

Solar Batteries Medium 45 minutes 308 👍 0

RV MPPT Solar Controller E1 Error Code: Causes & Fixes

Halfway through troubleshooting my MPPT solar charge controller's E1 error, the controller was working fine for months, but now it's completely stopped charging my batteries and just displays this E1 fault code on the screen.

From what I've read, this could be related to battery over-voltage conditions or possibly some kind of wiring fault, but I want to make sure I understand all the potential causes before I start troubleshooting. I'm comfortable doing basic electrical work myself, but I also want to know when this might be something that requires professional attention for safety reasons.

Can someone provide a detailed breakdown of what the E1 error specifically indicates, walk me through the proper diagnostic steps to identify the root cause, and explain the repair process? I'd especially appreciate guidance on how to safely approach this troubleshooting and what warning signs would indicate I should call in an expert instead of attempting the fix myself. …more

Read answer

Plumbing Medium 1-2 hours 304 👍 0

RV Tank Sensor Removal Guide: Gray & Black Water Tank Sensors (Step-by-Step Process)

Somewhere between throwing $150 at new RV tank sensors and just ripping out these faulty gray and black water sensors completely, I'm wondering which route makes more sense? Was looking at changing my gray/black water tank sensors, but when I crawled under there, this is what I found. What kind of sensors are these and how do you remove them? I'd really appreciate some specific advice about the sensor type and removal technique. …more

Read answer

Propane Medium 45 minutes 302 👍 0

RV Gas Detector Beeps Every Minute at Night - How to Fix

Before my wife mentioned it, I had no idea our RV gas detector was beeping every single minute from 7PM to 7AM—now it's driving me absolutely crazy. It only does this during nighttime hours - never during the day. I'm plugged into shore power with 4 batteries (2 coach, 2 engine). What would cause this specific timing pattern? Is it actually detecting gas or is something else going on with the detector itself? …more

Read answer

General Medium 30 min research 294 👍 0

Best Cummins 6.7 Scan Tools for RV Diesel & DPF Regen

The internet seems to give me six different answers about which scan tool actually works with my 2019 Fleetwood's Cummins 6.7L—am I missing something obvious here? Need comprehensive coverage for reading and clearing fault codes, monitoring engine parameters, and performing forced DPF regeneration cycles.

Considering several options including the Foxwell HD500, Ancel heavy-duty scanners, and various BlueFire/Inline adapters available through different suppliers. Price ranges vary significantly from budget OBD2 adapters to professional-grade diagnostic equipment.

Looking for detailed comparison of available scan tools specifically for Cummins 6.7 applications - both professional-grade and DIY-friendly options. What are the key features, compatibility considerations, and real-world performance differences between the various diagnostic solutions for this engine platform? …more

Read answer

Product Ranking 8 compared

Best RV Generators

4.6 (18,900 reviews)

Plumbing Medium 1-4 hours 293 👍 0

How to Fix RV Fresh Water Tank Leaks: Complete Diagnosis & Repair Guide

Nobody warned me how tricky RV fresh water tank leaks could be — got my tools ready and determined to fix this dripping mess under my trailer myself. The dripping was pretty steady at first but seems to have slowed down overnight to just occasional drops. My tank gauge still shows full, so I don't think it's completely emptying out.

I can see there's an underbelly cover that would need to come down to access everything underneath, but I'm hoping maybe there are some easier spots I should check first? I'd rather not tackle removing panels if I don't have to - any guidance on where these leaks typically start would be really helpful, especially near the drain valve! …more

Read answer

Electrical Easy 10 min read 285 👍 0

RV Battery Disconnect Switch Guide: When to Use, What Loses Power & Staying Safe

Wondering if I can skip the $400 shop diagnosis for my electrical issues and just figure out this battery disconnect switch myself, even though I'm getting conflicting advice.

Specifically, I'm concerned about what happens to things like my LP gas detector, carbon monoxide alarm, and refrigerator when I disconnect the battery. Will I lose all my radio presets and clock settings? Are there certain situations where I absolutely shouldn't use the disconnect switch?

I want to use it for storage to prevent battery drain, but I'm also wondering about daily use scenarios. What are the best practices to avoid any problems or safety issues? I really don't want to mess anything up or put my family at risk. …more

Read answer

Propane Easy 30 min 285 👍 0

RV LP Gas Detector False Alarms: Complete Troubleshooting Guide

Already tried everything but my RV's LP gas detector has false alarms in the garage, keeps beeping at random times, AND won't reset properly. Even with the LP tank completely shut off, the alarm still goes off within hours. It's located in the bottom of the fridge cabinet.

I've checked everywhere for actual leaks - can't smell anything, and all my appliances still light immediately when I take the RV out. The detector seems fine outside but becomes a nightmare indoors. I'm wondering if it's the sensor going bad, poor placement, or if there are other things that can trigger these detectors besides actual propane leaks?

I really need a complete breakdown of what causes these false alarms and how to fix this issue once and for all. Should I be looking at replacing the detector entirely, or are there troubleshooting steps I'm missing? …more

Read answer

Plumbing Medium 2-3 hours 282 👍 0

RV Black Tank Not Holding Full Capacity: 7 Common Causes and DIY Repair Solutions

Somewhere between embarrassed and desperate, I have to ask this probably dumb question: why does my RV's black tank act full when it should hold way more? We have a 40-gallon black tank, but when I try to fill it with water for cleaning, it starts overflowing through the vent pipe at only 23 gallons. I'm afraid there might be something seriously wrong with the installation or that I could damage the system.

A professional cleaning service said the tank was completely clean with no blockages, so I'm confused about why it won't hold its full capacity. The water is definitely coming out the vent pipe, so I assume that means the vent isn't blocked? I'm hesitant to keep trying things without understanding what's actually causing this - could this be a safety issue or sign of improper installation? What should I be looking for to diagnose this safely? …more

Read answer

Loading more Q&A...

You've seen all 134 Q&A articles!